Front Runner TRAC003 Manual de usuario

ENG

120 min

IMPORTANT WARNING!

Don’t be a hero and muscle through this without ﬁrst reading these ﬁtting instructions! Improper installation of this gear may void certain aspects of

your warranty.

Before you begin, take a moment and open all your Front Runner rack kit boxes and gather the assembly instructions for the various components.

A complete kit will contain:

1. A Front Runner Mounting System speciﬁc to your vehicle

2. A Front Runner Rack Tray or Load Bar Slats

This document will guide you through the assembly of the mounting system and assist you in ﬁtting the roof rack tray or load bars to your speciﬁc

vehicle.

Please refer to the next page for a list of all the components, quantities and tools required.

TRAC003

READ ME FIRST

START HERE!

1800mm - 70.8 inch

Universal Track

IT IS CRITICAL THAT ALL FRONT RUNNER PRODUCTS BE PROPERLY AND SECURELY ASSEMBLED AND ATTACHED TO YOUR VEHICLE. IMPROPER ATTACHMENT COULD

RESULT IN AN AUTOMOBILE ACCIDENT, AND COULD CAUSE SERIOUS BODILY INJURY OR DEATH. YOU ARE RESPONSIBLE FOR ASSEMBLING AND SECURING ALL FRONT

RUNNER PRODUCTS TO YOUR VEHICLE. CHECKING THE ATTACHMENTS PRIOR TO USE, AND PERIODICALLY INSPECTING THE PRODUCTS FOR ADJUSTMENT, WEAR AND

DAMAGE. THEREFORE YOU MUST READ AND UNDERSTAND ALL OF THE INSTRUCTIONS AND PRECAUTIONS SUPPLIED WITH YOUR FRONT RUNNER PRODUCT PRIOR TO

INSTALLATION OR USE. IF YOU DO NOT UNDERSTAND ALL OF THE INSTRUCTIONS AND CAUTIONS, OR IF YOU HAVE NO MECHANICAL EXPERIENCE AND ARE NOT THOROUGHLY

FAMILIAR WITH THE INSTALLATION PROCEDURES, YOU SHOULD HAVE THE PRODUCT INSTALLED BY A PROFESSIONAL INSTALLER OR OTHER QUALIFIED PERSONNEL.

IN THE BOX

FIGURE 1.1

IN THE BOX IN THE BOX

1GET ORGANIZED

Here is what you are looking at for TRAC003

IN THE BOX

1 10 X

2 2 X

3 2 X

4 10 X

5 10 X

M6 x 30 Counter Sunk Bolt

1800mm Roof Track

1800mm Protective Trim

M6x30x1 Flat Washer M6

Nyloc Hex Nut

IN THE BOX TOOLS NEEDED

10 mm

4mm

Allen Key

Measuring

Tape

IN THE BOX

Sealant

Hacksaw

Marker 4mm

7mm

Utility

Knife

TRAC003_REV_A00_MV

2.1

Remove the vehicles' interior head lining and factory ﬁtted roof rails if ﬁtted. Determine best possible

position for mounting the tracks. Positioning over the ditch molding is preferred and take care not to

drill into or through any reinforcements. Mesure and trim the tracks to the desired length.

FIT AND SECURE

10mm

2.6

Fit and secure the tracks with the

supplied fasteners. (Items 1, 4 and 5)

Reinstall vehicles interior head lining

removed in step 2.1

10mm

2.2

Once you are happy with the placement of the track, mark all the holes using a suitable marking pen.

2.3

Drill a 4mm pilot hole and then open up the pilot hole with a 7mm drill bit. Take care when drilling.

2.4

Peel off the double sided tape backing from the tracks (Item 2) and apply the protective rubber trim

(Item 3). Remove the excess with a craft knife.

2.5

Apply a bead of suitable sealant to each hole drilled in step 2.3

INSTALL OTHER VEHICLE AND RACK ACCESSORIES

Now's the time to visit your favorite Front Runner Dealer in person or Online.

COMPLETION

Congratulations. You did it. Take a step back and admire your work!

4mm

Tabla de contenidos

Otros manuales de Accesorios para automóviles de Front Runner

Front Runner

Front Runner RRAC203 Manual de usuario

Front Runner

Front Runner FAJK010 Manual

Front Runner

Front Runner RRAC190 Manual de usuario

Front Runner

Front Runner GOFR001 Manual de usuario

Front Runner

Front Runner KRTT950T Manual de usuario

Front Runner

Front Runner SSDS111 Manual de usuario

Front Runner

Front Runner Easy-Out Manual de usuario

Front Runner

Front Runner FSLI023 Manual de usuario

Front Runner

Front Runner KSTF003T Manual de usuario

Front Runner

Front Runner TBRA034 Manual de usuario

Front Runner

Front Runner RRAC201 Manual de usuario

Front Runner

Front Runner RRAC137 Manual de usuario

Front Runner

Front Runner TRCA009 Manual de usuario

Front Runner

Front Runner LASS026 Manual de usuario

Front Runner

Front Runner SLIMLINE II KRSO004T Manual

Front Runner

Front Runner SSDR002 Manual de usuario

Front Runner

Front Runner JADA010 Manual de usuario

Front Runner

Front Runner LALD007 Manual de usuario

Front Runner

Front Runner LALD009 Manual de usuario

Front Runner

Front Runner SSDS201 Manual de usuario

Front Runner

Front Runner FAJK003 Manual de usuario

Front Runner

Front Runner SLIMLINE II Manual de usuario

Front Runner

Front Runner TBRA039 Manual de usuario

Front Runner

Front Runner RRAC129 Manual de usuario

Manuales populares de Accesorios para automóviles de otras marcas

James Baroud

James Baroud Odyssey Manual de usuario

Motorola

Motorola i50sx Manual de usuario

Yakima

Yakima 9MM STANDARD BIKE MOUNT Manual de usuario

Feniex

Feniex T3 Manual de usuario

Renault

Renault 77 11 423 180 Manual de usuario

Kia

Kia E8300-4D000 Manual de usuario

Brink

Brink 756843 Manual de usuario

Whispbar

Whispbar K085W Manual de usuario

v.link

v.link CI-VL2-PC-HSD Manual de usuario

Viking

Viking Stack-Rack Guía de configuración rápida

Aries

Aries 203015 Manual de usuario

Choetech

Choetech AT0005 Manual de usuario

ZZ2

ZZ2 ZZAIR-PRO Manual de usuario

Holman

Holman 4A80L Manual de usuario

Thule

Thule 2075 Manual de usuario

Motorola

Motorola T325 Manual de usuario

TAUBENREUTHER

TAUBENREUTHER 16-3950 Guía de instalación

DV8

DV8 FBJL-02 Manual de usuario