Dancover CA119011 Manual de usuario

06-07-2017

for

Folding Garage (Car)

2,5x5,4x2m

Manual

TABLE OF CONTENTS

1. GENERAL INFORMATION……………………………………………………………….…....3

1.1 Introduction………………………………………………………………………………...........3

2. BOX DESCRIPTION AND TECHNICAL SHEET………………………………………....….4

2.1 General description…………………………………………………………………………......4

2.2 Components………………………………………………………………………………..……5

2.3 Fabric’s characteristics……………………………………………………………………..…..8

3. INSTALLATION…………………………………………………………………………..........10

3.1 Handling and transport…………………………………………….......................................10

3.2 Place and requirements for the installation…………………………………………….…...10

3.3 Installation…………………………………………………………………………………...…10

3.3.1 Package opening……………………………………………………………………………10

3.3.2 Squared holding devices placement………………………………………………..........11

3.3.3 Box installation…………………………………………………………………………..….11

3.3.4 Bracing system………………………………………………………………….……..........12

3.3.5 Snails opening…………………………………………………………………………..…. .13

4. BOX UTILIZATION…………………………………………………………………….…….. .13

5. CHECKS AND MAINTENANCE………………………………………………………..........14

6. DISASSEMBLY…………………………………………………………………………….…..14

1. GENERAL INFORMATION

1.1. Introduction

This manual is an integral part of the product; it is addressed to the installer and to the final user of

the box, and enables a correct installation and use. For this reason it must be hold with the box

until proper disposal.

In this manual you will find the instructionsto:

•

correctly install the box

understandthe functions of the box and of the whole thereof

correctly do the box scheduled maintenance processes

take care of the basic safety rules

ATTENTION: the installer and the final user must read the whole manual in each part of

it. Keepthis manual in a safe and accessible place.

Before using the box, please read carefully the technical information contained in this

manual and follow them strictly.

2. BOX DESCRIPTION AND TECHNICAL SHEET

2.1. General description

The box must be used only as an ordinary protection cover, for purely temporary use. In case of

bad weather conditions (wind, snow), the box must be removed. Given that the box can not be

fixed to the ground - but only bound to it - its use in these conditions can cause damages to

people and things.

It is particularly important for safety not to hang or apply any type of load at the structure or at the

top cover of the box.

In particular, children must not handle the snails. The failure to respect the conditions of use and

warnings immediately voids the warranty.

BOX MODULARE/BOX MODULARE ECO 1 snail

BOX MODULARE/BOX MODULARE ECO 2 snails

A (cm): 410/480/550

B (cm): 250

C (cm): 200

A (cm): 470/540/610

B (cm): 250

C (cm): 200

2.2. Components

N. DESCRIPTION

1 ALUMINIUM PROFILE MM 45X15

2 ALUMINIUM PROFILE (gables)

3 SQUARED HOLDING DEVICE

4 SQUARED HOLDING DEVICE CAP

5 ANODIZED ALUMINIUM 120x60 FOOT

6 PVC COVERSOL/FABRITARP TOP COVER

7 ALUMINIUM LACQUERED RAL 9010 PLATE (crosses)

8 ALUMINIUM LACQUERED RAL 9010 PLATE (tension bars)

9 NYLON ROPE DIAM. MM 5

10 STRING FASTENER HANDLE

11 HINGE FASTENING RIVET

12 TENTMESH LATERAL COVER (only for Box Modulare)

13 FOOT WITH FINAL HINGE

14 FOOT WITH CENTRAL HINGE

15 FOOT WITH HINGE FOR HEAD-FASTENING PLATE

2.3. Fabric’s characteristics

COVERSOL

BOX MODULARE

Yarn Warp: 100% PES 280 Dtex

Weft: 100% PES 280 Dtex

Construction Warp: 16 yarn/cm

Weft: 16 yarn/cm

Fabric’s weight Ca 400 gr/m2

Tensile strength Warp: Ca 120 DaN/5 cm

(DIN 53354) Weft: Ca 130 DaN/5 cm

Tearing resistance Warp: Ca 5,5 DaN

(DIN 53363) Weft: Ca 7,5 DaN

Grip (ISO 2411) Ca 6 DaN/5 cm

Temperature resistance +70°C/-30°C

Light resistance (DIN 53388) Level: 7/8

Finishing Gloss lacquered (one side)

UV Treated

LG 450

BOX MODULARE ECO

Coating PVC

Fabric’s weight Ca 450 gr/m2

Tensile strength Warp: Ca 250 DaN/5 cm

(DIN 53354) Weft: Ca 180 DaN/5 cm

Tearing resistance Warp: Ca 25 DaN

(DIN 53363) Weft: Ca 25 DaN

Hot / cold resistance

+70° C/ -30°C

Finishing 1 side gloss lacquered

3. INSTALLATION

3.1. Handling and transport

The box installation should only be done by qualified staff.

The products must be unloaded through appropriate lifting equipment, which must be used only by

authorized staff.

If the unloading operation is made by hand, it is important to consider that the weight limit that each

person can handle is 25 Kg; moreover, the operators should be equipped with gloves and safety

shoes.

3.2. Place and requirements for the installation

Before the arrival of the installers the user must arrange:

•any permits required by local regulations

•appropriate ground

3.3. Installation

Before starting the installation, if electrical equipment utilization is needed:

•make sure you do not work in wet areas

•use only intact extension cords, according to the place of use

•use shoes with rubber soles

ATTENTION: it is necessary for the operators to use appropriate personal protective

equipment such as safety shoes and gloves, in order to avoid injuries provoqued by the

fall of the packaging or of components that it contains, perforation and cutting due to

cutting or hanging parts.

3.3.1. Package opening

Packaging must be opened only with scissors with rounded tips, using the best care not to cut the

cloth of the article (Photo 1).

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Carpa de Dancover

Dancover

Dancover PRO EventZone 9m Series Manual de usuario

Dancover

Dancover 2m Series Manual de usuario

Dancover

Dancover SEMI PRO 7x7m Manual de usuario

Dancover

Dancover Garage tent 3,77x7,3x3,24m PVC Manual de usuario

Dancover

Dancover B788 Manual de usuario

Dancover

Dancover Multipavillon 3x6m Manual de usuario

Dancover

Dancover PRO XL Manual de usuario

Dancover

Dancover Basic-1339H Manual de usuario

Dancover

Dancover ST01100 Manual de usuario

Dancover

Dancover SEMI PRO 6m Series Manual de usuario

Dancover

Dancover ProShed MS572012 Manual de usuario

Dancover

Dancover TentZing CT168040 Manual de usuario

Dancover

Dancover TentZing CT168300 Manual de usuario

Dancover

Dancover 5.4m Series Manual de usuario

Dancover

Dancover PA22370 Manual de usuario

Dancover

Dancover Semi Pro XL 6m Series Manual de usuario

Dancover

Dancover Multipavillon 6x9m Manual de usuario

Dancover

Dancover Proshed Garage Manual de usuario

Dancover

Dancover AC153200 Manual de usuario

Dancover

Dancover Pagoda Tent PRO+ 10x10m EventZone Manual de usuario

Dancover

Dancover Semi PRO 4x8m Manual de usuario

Dancover

Dancover PRO EventZone 9m Series Manual de usuario

Dancover

Dancover Pagoda Manual de usuario

Dancover

Dancover Oceancover PVC Manual de usuario

Manuales populares de Carpa de otras marcas

OZTENT

OZTENT JV SIGNATURE EDITION Manual de usuario

GigaTent

GigaTent Summer Chalet Mini Tent Manual de usuario

Coleman

Coleman 2000007827 Manual

ShelterLogic

ShelterLogic 107153 Manual de usuario

Outsunny

Outsunny 84C-230 Manual de usuario

Napier

Napier SPORTZ COVE 61 Series Manual de usuario

EuroTrail

EuroTrail ATLANTIS PRO Manual de usuario

Reimo

Reimo Marina Manual de usuario

TiiTENT

TiiTENT TB300 Manual de usuario

Coleman

Coleman 2000033134 Guía de instalación

Ozark Trail

Ozark Trail W784.1 Guía de inicio rápido

SlingFin

SlingFin CrossBow 2 Manual de usuario

Coleman

Coleman 9600-141 Manual de usuario

Palram

Palram Arizona 5000 Wave - WINGS Manual de usuario

COVERPRO

COVERPRO 56184 Instrucciones de montaje

Vango

Vango Zenith 100 Manual de usuario

Costway

Costway PATIOJOY OP70818 Manual de usuario

Clarke

Clarke PUC 88 Manual de usuario