Outback GD4222S-S Manual de usuario

Drawings are not to scale.

Specifications subject to change

without prior notice.

EN (Europe)

Assembly and Operating Instructions for Outback®

Montana Plus 4 Burner Gas Barbecue with Side Burner

WARNING

For outdoor use only. Not for commercial use.

Read instructions before using the appliance. Failure to follow instructions could

result in death, serious bodily injury, and/or property loss.

Warning: accessible parts may be very hot. Keep young children and pets away.

Do not move the appliance during use.

Turn off the gas supply at the gas bottle after use.

Any modification of the appliance, misuse, or failure to follow the instructions may be

dangerous and will invalidate your warranty. This does not affect your statutory

rights.

Retain these instructions for future reference.

Leak test annually, and whenever the gas bottle is removed or replaced. Check that

the hose connections are tight and leak test each time you reconnect the gas bottle.

For Flare-up control please refer to the ‘OPERATION’ section of this manual.

FOR YOUR SAFETY

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open barbecue lid or hood.

4. If odour continues, discontinue use and contact

your local dealer.

FOR YOUR SAFETY

1. Do not store or use petrol or other flammable

vapours or liquids in the vicinity of this or any

other appliance.

2. A gas bottle not connected for use must not be

stored in the vicinity of this or any other

appliance.

PIN: 598 CP 466

GD4222S-S

1. Parts List

Quantity varies according to model purchased. Specifications subject to change without prior notice. For more

details on hardware, please see the corresponding ‘Hardware Reference Diagram’.

CODE

PART

QTY

HOOD & BODY

Hood (Pre-Assembled to Body)

Flame Tamer

Warming Rack

Cooking Grill

Main Burner

Knob

Knob Bezel

Drip Tray

Grease Cup

A10

Left Drip Tray Bracket

A11

Right Drip Tray Bracket

A12

Side Burner Gas Hose/Injector Assembly

SIDE SHELF

Left Side Shelf

Right Side Burner Shelf

Side Burner

Side Burner Grid

TROLLEY

Upper Body Support

Left Side Trolley Assembly

Right Side Trolley Assembly

Door (Left)

Door (Right)

Rear Panel

Matchstick Lighting Rod Assembly

Bottom Panel

Lockable Caster

C10

Caster

HARDWARE

M6×12 Bolt & Ø6 Spring Washer

Door Axle

Ø6 Washer

M4x8 Bolt & Ø4 Spring Washer



2. Parts Diagram

Quantity varies according to model purchased. Specifications subject to change without prior notice. For more details

on hardware, please see the corresponding ‘Hardware Reference Diagram’.

A12

A11

A10

C10

3. Hardware Reference Diagram

Specifications subject to change without prior notice.

door axe (2PCS)

M4¡ Á8 bolt& 4 spring washer(4PCS)

6 Washer(4PCS)

M6¡ Á12 bolt & 6 spring washer(25PCS)

M6×12 Bolt & Ø6 Spring Washer (25pcs)

M4x8 Bolt & Ø4 Spring Washer

Door Axle

Ø6 Washer

4. Assembly

IMPORTANT!

TOOLS NEEDED FOR ASSEMBLY: Medium size flat blade or Phillips/Crosspoint screwdriver, adjustable spanner

or metric spanner set.

The assembly of this barbecue requires 2 people.

Remove any internal component or packaging from the barbecue body.

Whilst every care is taken in the manufacture of this product, care must be taken during assembly in case sharp

edges are present.

Please read the Important Information section carefully before assembly and use of your barbecue.

Insert the two Lockable Casters (C9) and two standard Casters (C10) into the holes below

the Bottom Panel (C8) as shown and tighten with a wrench. The two Lockable Casters (C9)

should be on the front side.

Attach the two Door Axles (B) to this Bottom Panel in the areas as shown.

Attach the Right Side Trolley Assembly (C3) to the Bottom Panel (C8) using 2 x M6x12 Bolts and

Ø6 Spring Washers (A) as shown. Repeat for the Left Side Trolley Assembly (C2).

C10

A4PCS

Attach the Upper Body Support (C1) to the Left and Right Side Trolley Assembly (C2 & C3) using 4

x M6x12 Bolts and Ø6 Spring Washers (A).

Attach a Rear Panel (C6) to the lower section of the Left and Right Side Trolley Assembly and

Bottom Panel using 5 x M6x12 Bolts and Ø6 Spring Washers (A).

Attach the second Rear Panel (C6) to the upper section of the Left and Right Side Trolley

Assembly using 4 x M6x12 Bolts and Ø6 Spring Washers (A).

Fit the doors (C4 & C5) to the cabinet by placing them into the door axes and then depressing the

spring pins to insert into the upper body support.

Attach the Left Drip Tray Bracket (A10) to the Left Side Trolley Assembly (C2) using 2 x M6x12 Bolts

and Ø6 Spring Washers (A) as shown. Repeat for the Right Drip Tray Bracket (A11).

A 13PCS

16 17

A4PCS

A10

A11

Insert the Left Side Shelf (B1) onto the 5 pre-installed screws (M6x16) on the left side of the

barbecue body, then tighten these pre-installed screws as shown.

Carefully place the Hood and Barbecue Body (A1) onto the

trolley assembly.

WARNING: DO NOT RELEASE THE BARBECUE BODY WHILE

THE BARBECUE HAS NOT BEEN PROPERLY SEATED. THIS

MAY RESULT IN INJURY OR DAMAGE TO YOUR BARBECUE.

Attach the barbecue to the trolley assembly using 4 x M6x12

Bolts and Ø6 Spring Washers (A) and 4 x Ø6 Washers (C) as

illustrated.

Insert the Right Side Burner Shelf (B2) onto the 5 pre-installed screws (M6x16) on the right side

of the barbecue body, then tighten these pre-installed screws as shown.

Insert the Side Burner Gas Hose/Injector Assembly (A12) through the hole on the front of the side

burner shelf and position it such that its screw holes align up. Place a Knob Bezel (A7) on front with its

screw hole indentations aligned up with those on the side shelf and secure it along with the injector

assembly to the shelf using M4x8 Bolts & Ø4 Spring Washers (Dx2pcs).

Attach a Knob (A6) to the exposed gas valve pin.

A12

Place the Side Burner Grid (B4) onto the side burner shelf.

Note: Only use cookware with a base diameter of between 120mm and 220mm on the side burner.

Place the Side Burner (B3) through the central hole in the side burner shelf. Fit the side burner

venturi tube over the gas valve outlet. This is a loose fit and not a gas tight seal. Secure the

burner with 2 x M4x8 Bolts and Ø4 Spring Washers (D).

Insert the ignition wire into the lower position on the side burner electrode.

Carefully lay each Flame Tamer (A2) into the barbecue body ensuring it lies level within the body as illustrated.

Place each Cooking Grill (A4) into the grill body as shown above.

Tabla de contenidos

Otros manuales de Parrilla de Outback

Outback

Outback Modern Classic Trooper Manual de usuario

Outback

Outback CK578T Manual de usuario

Outback

Outback Sapphire THG3216AW Manual de usuario

Outback

Outback Omega 200 Manual de usuario

Outback

Outback MS4464 Manual de usuario

Outback

Outback THG3710SS-3 Manual de usuario

Outback

Outback Saturn 4 Manual de usuario

Outback

Outback OUT371036 Manual de usuario

Outback

Outback Omega 100 Manual de usuario

Outback

Outback Meteor Select MS4431 Manual de usuario

Outback

Outback TRG2301P-3 Manual de usuario

Outback

Outback THG2302P-3 Manual de usuario

Outback

Outback Meteor 4 MS4431H Manual de usuario

Outback

Outback Excel 100T Manual de usuario

Outback

Outback Omega 100 Manual de usuario

Outback

Outback THG3302S-3 Manual de usuario

Outback

Outback CS3200 Manual de usuario

Outback

Outback Dual Fuel 2 Manual de usuario

Outback

Outback Hunter Plus 3 Manual de usuario

Outback

Outback Excel 100 Manual de usuario

Outback

Outback Spectrum TRG3301P Manual de usuario

Outback

Outback Spectrum 2 Burner Manual de usuario

Outback

Outback Meteor MT-H4430-3 Manual de usuario

Outback

Outback THG2302-3 Manual de usuario

Manuales populares de Parrilla de otras marcas

Orbegozo

Orbegozo GR 2300 Manual de usuario

bora

bora PT11 Manual de usuario

Klarstein

Klarstein 10031664 Manual de usuario

Garland

Garland MWE3W Manual de usuario

Char-Broil

Char-Broil 463722714 Manual de usuario

Nexgrill

Nexgrill 720-0830HK Manual de usuario

Kenmore

Kenmore 415.16123800 Manual de usuario

Camp Chef

Camp Chef PG24CLAU Manual de usuario

Tucker Barbecues

Tucker Barbecues GTR Series Instrucciones de montaje

Monogram

Monogram ZGG540NCP1SS Manual de usuario

Equipex

Equipex Sodir Savoy Manual de usuario

Gaggenau

Gaggenau VR 414 610 Manual de usuario

Miele

Miele KM 408-1 Manual de usuario

George Foreman

George Foreman GGR50B Manual de usuario

AOG

AOG T series Manual de usuario

Gorenje

Gorenje TG2000CB Manual de instrucciones

Weber

Weber Genesis Silver-B Permamount NG 051701 Manual de usuario

Glen

Glen SA 3037 Manual de usuario