Cisco CDE 220 Series Manual

Cisco Systems, Inc.

www.cisco.com

Cisco has more than 200 offices worldwide.

Addresses, phone numbers, and fax numbers

are listed on the Cisco website at

www.cisco.com/go/offices.

Cisco Content Delivery Engine

205/220/250/280/285/420/460/475 Hardware

Installation Guide

October 05, 2018

THE SPECIFICATIONS AND INFORMATION REGARDING THE PRODUCTS IN THIS MANUAL ARE SUBJECT TO CHANGE WITHOUT NOTICE. ALL

STATEMENTS, INFORMATION, AND RECOMMENDATIONS IN THIS MANUAL ARE BELIEVED TO BE ACCURATE BUT ARE PRESENTED WITHOUT

WARRANTY OF ANY KIND, EXPRESS OR IMPLIED. USERS MUST TAKE FULL RESPONSIBILITY FOR THEIR APPLICATION OF ANY PRODUCTS.

THE SOFTWARE LICENSE AND LIMITED WARRANTY FOR THE ACCOMPANYING PRODUCT ARE SET FORTH IN THE INFORMATION PACKET THAT

SHIPPED WITH THE PRODUCT AND ARE INCORPORATED HEREIN BY THIS REFERENCE. IF YOU ARE UNABLE TO LOCATE THE SOFTWARE LICENSE

OR LIMITED WARRANTY, CONTACT YOUR CISCO REPRESENTATIVE FOR A COPY.

The Cisco implementation of TCP header compression is an adaptation of a program developed by the University of California, Berkeley (UCB) as part of UCB’s public

NOTWITHSTANDING ANY OTHER WARRANTY HEREIN, ALL DOCUMENT FILES AND SOFTWARE OF THESE SUPPLIERS ARE PROVIDED “AS IS” WITH

ALL FAULTS. CISCO AND THE ABOVE-NAMED SUPPLIERS DISCLAIM ALL WARRANTIES, EXPRESSED OR IMPLIED, INCLUDING, WITHOUT

LIMITATION, THOSE OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE AND NONINFRINGEMENT OR ARISING FROM A COURSE OF

DEALING, USAGE, OR TRADE PRACTICE.

IN NO EVENT SHALL CISCO OR ITS SUPPLIERS BE LIABLE FOR ANY INDIRECT, SPECIAL, CONSEQUENTIAL, OR INCIDENTAL DAMAGES, INCLUDING,

WITHOUT LIMITATION, LOST PROFITS OR LOSS OR DAMAGE TO DATA ARISING OUT OF THE USE OR INABILITY TO USE THIS MANUAL, EVEN IF CISCO

OR ITS SUPPLIERS HAVE BEEN ADVISED OF THE POSSIBILITY OF SUCH DAMAGES.

Cisco and the Cisco logo are trademarks or registered trademarks of Cisco and/or its affiliates in the U.S. and other countries. To view a list of Cisco trademarks, go to this

URL: www.cisco.com/go/trademarks. Third-party trademarks mentioned are the property of their respective owners. The use of the word partner does not imply a partnership

relationship between Cisco and any other company. (1110R)

This product contains watermarking technology that is licensed from Verimatrix, Inc., and such functionality should not be used or distributed further by you without any

additional license(s) required from Verimatrix, Inc.

Any Internet Protocol (IP) addresses used in this document are not intended to be actual addresses. Any examples, command display output, and figures included in the

document are shown for illustrative purposes only. Any use of actual IP addresses in illustrative content is unintentional and coincidental.

Cisco Content Delivery Engine 205/220/250/280/285/420/460/475 Hardware Installation Guide

iii

Cisco Content Delivery Engine 205/220/250/280/285/420/460/475 Hardware Installation Guide

CONTENTS

Preface ix

Document Revision History ix

Document Organization xi

Objectives xi

Audience xii

Related Documentation xii

Conventions xiii

Safety Warning Information Referral xiii

Obtaining Documentation and Submitting a Service Request xix

CHAPTER

1Overview of the Content Delivery Engines 1-1

Cisco VDS Internet Streamer Overview 1-1

Cisco VDS-TV Overview 1-3

Cisco CDA Visual Quality Experience Application Overview 1-5

VQE Major Software Components 1-7

OMD Overview 1-7

Hardware Features 1-7

CDE Configurations 1-15

CDE205 Hardware Overview 1-16

CDE220 Hardware Overview 1-17

CDE250 Hardware Overview 1-18

CDE250 Connectivity 1-20

CDE280 Hardware Overview 1-21

CDE285 Hardware Overview 1-22

CDE420 Hardware Overview 1-23

CDE460 Hardware Overview 1-24

CDE475 Hardware Overview 1-25

CDE Storage Drives and Expansion Cards 1-26

CDE205 1-26

CDE220 2A-C 1-26

CDE220 2A-F 1-27

CDE220 2C1-C 1-27

Contents

Cisco Content Delivery Engine 205/220/250/280/285/420/460/475 Hardware Installation Guide

CDE220 2C1-F 1-28

CDE220 2C2-C 1-28

CDE220 2C2-F 1-29

CDE220 2D1-C 1-29

CDE220 2D1-F 1-30

CDE220 2G2-C 1-30

CDE220 2G2-F 1-31

CDE220 2S1-C 1-32

CDE220 2S1-F 1-32

CDE220 2S3-C 1-33

CDE220 2S3-F 1-33

CDE220 2S3I-C 1-34

CDE220 2S3I-F 1-34

CDE250 2A4 1-35

CDE250 2A2 1-35

CDE250 2G3 1-36

CDE250 2M0 1-37

CDE250 2S5 1-37

CDE250 2S6 1-38

CDE250 2S8 1-39

CDE250 2S9 1-39

CDE250 2S10 1-40

CDE250 2V0 1-41

CDE280 1-41

CDE285-S 1-42

CDE285-L 1-43

CDE420 4A-C 1-44

CDE420 4A-F 1-44

CDE420 4G-C 1-45

CDE420 4G-F 1-45

CDE460 1-46

CDE460-4R1 1-47

CDE460-4R3 1-48

CDE475 1-49

Front Panel Control Buttons and LEDs 1-50

Front Panel Control Panel Buttons 1-50

Front Panel LEDs 1-51

Rear Panels LEDs and Buttons 1-55

Storage Drive LEDs 1-57

Input/Output Ports and Connectors 1-57

Contents

Cisco Content Delivery Engine 205/220/250/280/285/420/460/475 Hardware Installation Guide

CHAPTER

2Preparing to Install the Content Delivery Engines 2-1

Site Requirements 2-1

Preventing Electrostatic Discharge Damage 2-1

Environmental and Physical Specifications 2-2

Storage Drive Cautions 2-3

Safety Warnings 2-4

AC Power Option Warnings 2-7

DC Power Option Warnings 2-7

Safety Guidelines 2-8

Emissions Disclaimer 2-9

Intended Uses 2-9

If AC Power Supplies Are Installed 2-9

Supplemental Grounding Connection 2-10

If DC Power Supplies Are Installed 2-12

Temperature and Ventilation 2-13

CHAPTER

3Installing the Content Delivery Engines 3-1

Tools and Parts Required 3-1

Unpacking the Box 3-1

Inspecting for Damage 3-2

Installing the CDEs 3-2

Reviewing Rack Installation Safety Guidelines 3-3

Preparing the CDEs for Rack Installation 3-3

Replacing External Storage Drives 3-3

Replacing a CDE280 Drive 3-8

Replacing a Power Supply 3-9

Replacing a CDE280 Power Supply 3-12

Device Connection Test in a VDS-TV Environment 3-13

Installing SFPs 3-13

Rail Kits 3-14

Installing a CDE205, CDE220, in the Rack Using a Rev. A Rail Kit 3-14

Installing a CDE285 3-19

Replacing CDE285 3-19

Installing a CDE420 in the Rack Using a Rev. A Rail Kit 3-19

Installing a CDE205, CDE220, CDE420, and CDE460 in the Rack Using a Rev. B Rail

Kit 3-24

Installing a CDE280 in the Rack Using a Rail Kit 3-30

Unpacking and Inspecting the Server 3-31

Contents

Cisco Content Delivery Engine 205/220/250/280/285/420/460/475 Hardware Installation Guide

Preparing for Server Installation 3-31

Installation Guidelines 3-31

Rack Requirements 3-32

Equipment Requirements 3-33

Slide Rail Adjustment Range 3-33

Installing the Server In a Rack 3-33

Installing the Slide Rails 3-33

Installing the Cable Management Arm (Optional) 3-35

Reversing the Cable Management Arm (Optional) 3-37

Making Physical Connections 3-37

Connecting Power Cords 3-38

Server Types 3-38

Connecting Network Cables 3-38

CHAPTER

4Installing the VDS Internet Streamer Software and Initially Configuring a CDE 4-1

Launching a New CDE for the First Time 4-1

Launching a CDE280 for the First Time 4-3

Configure the CIMC IP 4-3

Configure Remote Presence 4-5

Connect to the Console 4-7

Configure VDS-IS Software 4-7

Configuring SNMP 4-8

Re manufacturing a CDE 4-14

Before You Begin 4-14

Installing a CDE 4-15

Re-manufacturing and Installing CDE280 4-17

CDE280 Model Migration 4-23

Replacing CDE280 chassis 4-25

Requirement 4-25

Installing the VDS-IS Software 4-27

Verifying the CDSM 4-30

BIOS Settings 4-32

CDE280 BIOS and CIMC Settings 4-34

CHAPTER

5Installing the VDS-TV Software and Initially Configuring a CDE 5-39

Hardware/Platform specific performance numbers for VDS-TV 5-39

CHAPTER

6Installing the VQE and Initially Configuring a CDE 6-1

Launching a New CDE250 for the First Time 6-1

Contents

vii

Cisco Content Delivery Engine 205/220/250/280/285/420/460/475 Hardware Installation Guide

Launching a New CDE280 for the First Time 6-1

Configure the CIMC IP 6-1

Configure Remote Presence 6-2

Connect to the Console 6-2

Configure VQE Software 6-2

Configuring SNMP 6-2

Re-manufacturing a CDE 6-2

Before You Begin 6-2

Installing a CDE 6-3

Re-Manufacturing and Installing CDE280 6-3

Installing the VQE Software 6-6

BIOS Settings 6-7

APPENDIX

ATechnical Specifications A-1

CDE205 Specifications A-1

CDE220 Specifications A-2

CDE280 Specifications A-3

CDE285 Specifications A-4

CDE420 Specifications A-5

CDE460 Specifications A-6

CDE475 Specifications A-7

CDE Management A-7

CDE Heat Rate Load A-8

APPENDIX

BConnector Pin Assignments B-1

Serial Console-Interface Connector Pin Assignments B-1

Serial Port Connector B-2

KVM Console B-3

Ethernet Connector Pin Assignments B-3

Ethernet Port Connector B-5

Fiber Connector Type B-5

Cable Pin Assignments B-6

APPENDIX

CPower Cord Specifications C-1

Supported Power Cords and Plugs C-1

AC Power Cord Illustrations C-3

Contents

viii

Cisco Content Delivery Engine 205/220/250/280/285/420/460/475 Hardware Installation Guide

APPENDIX

DCDE280 and CDE285 Troubleshooting Tips D-1

Troubleshooting Tips D-1

Obtaining Show Tech Support to TAC D-1

Display of System Event Log Events D-4

Display of Sensor Readings D-4

Display of CIMC Log D-5

Common Troubleshooting Scenarios D-6

Common Troubleshooting Scenarios Host Does not Boot D-7

Common Troubleshooting Scenarios - BMC D-7

Accessing CIMC on CDE280 Service Engine D-7

Connecting to the console D-9

APPENDIX

EConfiguring VDS-IS CDE280 Disks E-1

Changing the Disk Status Using KVM Console E-1

Changing Drive Status Using CIMC Console E-9

APPENDIX

FVDS-IS and VQE CDE280 and CDE285 CIMC / BIOS Firmware F-1

VDS-IS and VQE CDE 280 CIMC Firmware and BIOS Firmware Upgrade F-1

VDS-IS and VQE CDE280 CIMC Firmware and BIOS Firmware Downgrade F-11

OMD CDE285 CIMC Firmware and BIOS Firmware Upgrade F-15

Cisco Content Delivery Engine 205/220/250/280/285/420/460/475 Hardware Installation Guide

Preface

This preface describes the objectives and organization of this guide.

•Document Revision History, page ix

•Document Organization, page xi

•Objectives, page xi

•Audience, page xii

•Related Documentation, page xii

•Conventions, page xiii

•Safety Warning Information Referral, page xiii

•Obtaining Documentation and Submitting a Service Request, page xix

Document Revision History

Table 1 records technical changes to this document.

Table 1 Document Revision History

Document Version Date Change Summary

— October 05, 2018 Added CDE475 support for VDS-TV.

— January 31, 2018 CDE470 is not supported in VDS-TV.

— December 09, 2016 Added CDE285 support for OMD (Open

Media Distribution).

— September 29, 2016 Added CDE280-2U4 support for VDS-TV.

— June 15, 2016 •Added CDE280 support for VDS-TV.

•Added CDE280 support for VQE.

— March 31, 2016 Added Hardware/Platform specific

performance numbers for VDS-TV.

Cisco Content Delivery Engine 205/220/250/280/285/420/460/475 Hardware Installation Guide

— February 29, 2016 •Added Configuring VDS-IS CDE280

Disks.

•Added CDE 280 CIMC Firmware and

BIOS Firmware Upgrade and

downgrade.

— June 5, 2015 Added Troubleshooting tips for CDE280,

and the port cable specifications for CDE.

— April 30, 2015 Added CDE280 support for Internet

Streaming.

OL-16887-13 June 27, 2014 Update for VDS-TV Plymouth release.

OL-16887-12 January 13, 2014 Updated CDS to VDS, recorder

information, and miscellaneous

corrections.

OL-16887-11 October 31, 2013 Added CDE470.

OL-16887-10 July 19, 2013 Added CDE250 2S5 support for Internet

Streaming.

OL-16887-09 September 14, 2012 Added CDE460.

OL-16887-08 June 22, 2012 Added VQE Server (CDE250, model 2V0)

for Visual Quality Experience (VQE), and

the Very Dense TV and IS Flash Streamers

(CDE250, models 2S8, 2S9 and 2S10).

OL-16887-07 October 31, 2011 Added Dense IS Streamer (CDE250, model

2M0). Updated baud information for the

TV CDS installation, and the storage device

removal procedure.

OL-16887-05 March 31, 2010 Added Dense Cisco Internet Streamer

(CDE220, model 2S3I).

OL-16887-04 October 30, 2009 Added Flash SSD, Entry-Level Cisco TV

Streamer (CDE220, model 2S1), and Dense

Cisco TV Streamer (CDE220, model 2S3).

OL-16887-03 June 16, 2009 Added storage drive cautions, additional

DC power connect information, and

CDE220 2A-C, CDE220 2A-F, CDE420

4G-C, and CDE420 4G-F models.

OL-16887-02 April 4, 2009 Added CDE220 2G2-C model and

additional DC power supply specifications.

Removed CDE remanufacture instructions.

OL-16887-01 March 4, 2009 This is the first version of this document.

Table 1 Document Revision History

Document Version Date Change Summary

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Servidor de Cisco

Cisco

Cisco UCS B420 M3 Manual de usuario

Cisco

Cisco TelePresence Video Communication Server... Manual de usuario

Cisco

Cisco SCE 8000 10GBE Manual de usuario

Cisco

Cisco 700 series Manual de instalación y operación

Cisco

Cisco Nexus 7000 Series Manual de usuario

Cisco

Cisco TelePresence Manual de servicio

Cisco

Cisco UCS X9508 Guía de inicio rápido

Cisco

Cisco CSACS-1121-K9 Manual de usuario

Cisco

Cisco UCS B420 M3 Manual de instalación y operación

Cisco

Cisco SNS-3415 series Manual de programación

Cisco

Cisco C880 M5 Manual de usuario

Cisco

Cisco Sourcefire Defense Center 750 Manual de usuario

Cisco

Cisco UCS C460 M4 Manual de instalación y operación

Cisco

Cisco UCS C420 Instrucciones de instalación y mantenimiento

Cisco

Cisco 6400 Manual de usuario

Cisco

Cisco UCS C240 M3 Manual de usuario

Cisco

Cisco UCS B460 M4 Manual

Cisco

Cisco Nexus 7000 Series Manual de usuario

Cisco

Cisco UCS C220 Manual de usuario

Cisco

Cisco ONS 15454 SONET Manual de usuario

Cisco

Cisco Firepower 1120 Manual de usuario

Cisco

Cisco UCS C220 M5 Manual de usuario

Cisco

Cisco UCS C220 Instrucciones de instalación y mantenimiento

Cisco

Cisco UCS C220 M4 Guía de inicio rápido

Manuales populares de Servidor de otras marcas

HP AlphaServer ES47 Manual de usuario

Dell

Dell PowerEdge R410 Manual de usuario

PowerNAS

PowerNAS CMA Manual de usuario

Supero

Supero FatTwin F617R3-FT Manual de usuario

MSI

MSI P1-109N-L70 Manual de usuario

Dell

Dell PowerEdge XE9640 Manual

Dell

Dell PS4100 Instrucciones de montaje

EtroVISION

EtroVISION EV3151 Manual de usuario

NEC

NEC Express5800/T110j Manual de usuario

HP ProLiant Gen9 Manual de usuario

Compaq

Compaq ProLiant 3000 Manual

Dell

Dell PowerEdge 3YPMN Manual de usuario

iRobo

iRobo IPC2U Manual de usuario

Nortel

Nortel 1000 Con?guration guide Manual de usuario

Asus

Asus AP7500 Manual de operación y mantenimiento

Avid Technology

Avid Technology AirSpeed 5000 Manual de usuario

HP Integrity rx2600 Guía de instalación

Milestone

Milestone Husky IVO 350T Manual de usuario