Xtreme XG-575DS Manual de usuario

X-Treme™ Gas Scooters

XG-575DS

Owner’s Manual

PLEASE BE SAFE WHEN RIDING

ALWAYS WEAR A HELMET AND OBEY ALL LAWS!

TABLE OF CONTENTS

Table of Contents………………………………………………………………………………………2

Important Information………………………………………………………………………………3

Safety Information…………………………………………………………………………………….4

Getting To Know Your XG-575DS……………………………………………………………… 5

Package Contents…………………………………………………………………………………….. 6

Getting Started………………………………………………………………………………………….6

Folding and Storage…………………………………………………………………………………..8

Operating Procedures………………………………………………………………………………. 8

Maintenance……………………………………………………………………………………………. 10-16

Recommended Tools……………………………………………………………………. 10

Carburetor Adjustments………………………………………………………………..10

Braking System………………………………………………………………………………11

Tires and Wheels………………………………………………………………………….. 12

Adjusting the Head Unit…………………………………………………………….... 12

Adjusting the Belt and Chain………………………………………………………… 13

Adjusting the Second Gear Clutch Free Play…………………………………..14

Maintenance Schedule…………………………………………………………………. 15

Warranty/Technical Support……………………………………………………………………. 16

PLEASE READ THIS FIRST BEFORE OPERATING THIS PRODUCT

WHERE TO USE YOUR XG-575DS:

This product does not conform to Federal Motor Vehicle Standards and is not intended for

operation on public streets, roads or highways. Serious injury can result from the unsafe

operations of this vehicle. Operators can minimize these risks by using certain safety

equipment such as: safety helmet, goggles, gloves elbow and kneepads and appropriate

footwear.

HOW TO USE THIS PRODUCT:

DO NOT operate this product in traffic, on wet, frozen, oily or unpaved surfaces or under the

influence of drugs and/or alcohol. Avoid uneven surfaces, potholes, surface cracks and

obstacles. This product is designed for paved or tarred smooth flat surfaces. BE CAREFUL when

riding this product in the rain or in wet conditions.

CHECKS:

It is the customer’s responsibility to check all nuts and bolts (as per box) and ensure that the

product is in a safe roadworthy condition at all times.

WARNING!!

Never let a child or inexperienced person operate this product.

Not intended for use of children under the age of 16 years old.

Never start the engine inside a closed room or building. Breathing exhaust fumes can be

fatal.

This product should not be used by persons without excellent vision, balance,

coordination, reflexes, muscle and bone strength and good decision-making capabilities.

This product should not be used by minors without adult supervision.

This product should not be used by persons unwilling or unable to take responsibility for

their own actions.

The user of this product assumes ALL risks associated with its use. To minimize these

RISKS, the user must wear safety helmet, goggles, gloves, elbow and kneepads and

appropriate footwear.

FUEL SAFETY

Mix and pour fuel outdoors away from sparks and flames.

Use only a container approved for fuel.

Do not smoke or allow smoking near the scooter while working on the engine, or while the engine is

running.

Wipe up and clean all fuel spills before starting the engine.

Move at least 10 meters away from where you fueled before starting the engine.

Stop the engine before removing the fuel cap.

It is recommended that you empty the fuel tank prior to shipping or storage to prevent any fuel leaks.

Do not store your scooter near open flames, furnaces, electric motors or switches.

MAINTENACE SAFETY

Maintaining your scooter is recommended in this Owner’s Manual.

Disconnect the spark plug cap before performing any engine maintenance, except carburetor

adjustments.

Keep others away while making carburetor adjustments.

Use only quality replacement parts as recommended by the manufacturer.

TRANSPORTATION AND STORAGE

Carry your scooter by the handlebar down tube with the engine turned off and the muffler away from

your body.

Allow the engine to cool, empty the fuel tank and fold the scooter before carrying or storage.

It is recommended that you empty the fuel tank prior to shipping or storage to prevent any fuel leaks.

Clean the scooter carefully and store in a cool, dry place.

PRODUCT SAFETY

Keep hands and feet away from moving parts.

Inspect the entire product prior to each use. Replace damaged parts. Check for fuel leaks and make sure

all fasteners are in place and securely fastened.

Replace all parts that are cracked, chipped or damaged before use.

Use only parts and accessories that are recommended by the manufacturer.

If a situation arises that is not covered in this manual,

Proceed with caution and use good judgment.

Contact your dealer or X-Treme (www.x-tremescooters/support) if you need further

assistance.

Getting To Know Your

A-Blaze Signature Series

XG-575DS

1. Gas/Throttle Lever 13. Choke

2. Front Brake Lever 14. Belt Cover and Mud Guard

3. Rear Brake Lever 15. Handlebar Down Tube

4. Gearshift 16. Pull Starter

5. Front Disc Brake 17. Gas Tank

6. 2-Stroke Engine 18. Gas Cap

7. Front Fork Folding Mechanism 19. Choke Lever

8. Kickstand 20. Carburetor

9. Head Unit 21. Carburetor Cover

10. Foot Deck 22. Muffler

11. Brake Caliper 23. Muffler Cover

12. Rear Disk Brake 24. Spark Plug

PACKAGE CONTENTS

Your X-Treme™ A-Blaze Signature Series XG-575DS Gas Scooter comes with the following

items in the box:

Please locate all of the following:

1. The XG-575DS Gas Scooter

2. Allen Wrench

3. Owner’s Manual

GETTING STARTED

Please read and understand these instructions and the OPERATING PROCEDURES section

prior to starting or riding your XG-575DS!

Unfolding

1.) Carefully remove the XG-575DS from the box.

2.) To unfold the XG-575DS, begin by pressing down on the FOLDING HANDLE with one

hand, (Fig. 1) while gently pulling up on the handlebar post with the other (Fig. 2).

3.) Fully extend the handlebar post to the upright position until

you feel the mechanism lock into place (Fig. 3).

4.) Detach the handlebar from the post and mount the handlebar

on to the post using the 4 bolts provided. Ensure the

handlebars are in the center.

5.) Adjust the Gas and Brake Levers using the provided Allen

Wrench, loosen the tension bolt and adjust the levers to a

comfortable position (Fig. 4 next page).

**BE CAREFUL NOT TO PULL ON THE CABLES!!!

Fueling

This is a 2-stroke engine. Always run the engine using fuel

mixed with 2-cycle engine oil. Not mixing fuel/oil can destroy the

engine.

PLEASE READ OPERATING PROCEDURES BEFORE FUELING!!

6.) Mix fuel (unleaded) and 2-cycle engine oil in separate

container. Use a 32:1 ratio of gasoline to premium synthetic oil or

a synthetic blend of two-cycle oil. Make sure the fuel is well

mixed by shaking the container.

7.) Make sure that the engine is off!

8.) Slowly open the GAS CAP, so that possible over pressure

disappears.

9.) Clean the tank cap area to make sure that it is free from

excess dirt and debris.

10.) Pour pre-mixed Gas/Oil mixture into the GAS TANK. Tank

capacity is 0.9 liters.

**Do not overfill.

11.) After fueling, replace the GAS CAP and tighten.

Starting

Move at least 10 meters away from where you filled the gas tank!

12.) Set the CHOKE LEVER to the CHOKED (UP) position (Fig. 5).

13.) Pull the PULL STARTER briskly, making sure to hold the

handle in your grasp (Fig. 6).

14. Only use the choke system when the engine is cold, make

sure NOT to pull the gas lever when pulling the pull starter.

When starting a warm engine, DO NOT use the choke system, but

gently squeeze the gas lever.

When starting the XG-575DS for the first time, it may be

necessary to pull the starter handle 15-20 times until it

starts. This is because the gas needs to cycle into the engine.

15.) Once the engine has started, quickly move the CHOKE LEVER to the RUN (Down)

position (Fig. 5).

16.) After the engine is started, let it warm up for 2-3 minutes before riding.

IF THE MOTOR KEEPS STALLING AT IDLE SPEED, IT MAY BE NECESSARY TO ADJUST THE

IDLE SPEED ON THE CARBURETOR. Please refer to Carburetor Adjustment in the

Maintenance Section on Page 12 for instructions on how to adjust idle speed.

17.) Make sure that all the exposed bolts and screws are tightened.

18.) Raise the kickstand to its upright position.

19.) Make sure the engine is running.

20.) Put one foot on the deck of the XG-575DS. While pushing off with the other foot, press

the GAS LEVER on the right side of the handlebars. The XG-575DS will begin to move on its

own.

21.) Control your speed by pressing and releasing the gas lever. The harder you squeeze,

the faster you will go.

Changing Gears

22.) As max RPM is achieved, second gear can be selected by

pressing (a). The return to first gear; press (b) (Fig. 7).

Braking

23.) To brake, release the GAS LEVER and gently press either

BRAKE LEVERS (Fig. 8).

FOLDING AND STORAGE

When you are done riding the A-Blaze Signature Series XG-575DS Gas Scooter you can fold

it down for compact storage, carrying and transportation. To fold down the XG-575DS, use

one hand to push down the front folding handle mechanism while gently pushing down on

the handlebars. BE CAREFUL NOT TO HIT YOUR HEAD WITH THE HANDLEBARS!

Push down until you feel the mechanism lock into down position.

Note: If the lever is pulled aggressively, the locking spring may become

stretched and then the steering will not lock into position, it is also advisable to

ensure scooter locks firmly, prior to riding.

You can now carry the XG-575DS Gas Scooter by the handlebar down tube.

OPERATING PROCEDURES

Fuel

WARNING!!

This is a 2-stroke engine. Only run the engine on fuel, which is properly mixed with

2-cycle engine oil.

Provide good ventilation when fueling or handling fuel.

Always use gas with a minimum octane number of 91 unleaded.

Use Active 2-stoke oil only (for warranty purposes). Mix 32:1 gas:oil mixture.

Never use multi-grade (1 OW/30) or waste oil.

Always mix fuel and oil in a separate clean, gas safe container. Always start by

adding half the amount of fuel which is to be used. Then add the whole amount of 2-

cycle oil. Mix (shake) the fuel container. Add the remaining amount of fuel. Mix

(shake) the fuel oil thoroughly before filling the tank.

Fueling

WARNING!

1.) Always shut the engine off before refueling.

2.) Slowly open the fuel tank, so that possible over-pressure disappears.

3.) Before fueling, clean the tank cap area carefully, to insure that no dirt falls into the

tank. Make sure that the fuel is well mixed by shaking the container.

4.) Tighten the fuel cap carefully after fueling.

5.) Always move the unit at least 10 meters from fueling area before starting.

Starting

1.) Set the CHOKE LEVER to the CHOKED (UP) position.

2.) Pull the pull starter handle briskly, making sure to keep the handle in your grasp,

not allowing it to snap back.

3.) One the engine is running, move the CHOKE LEVER to the RUN (Down) position.

NOTE: At this stage, if the engine does not start, repeat the starting procedure.

4.) After starting the engine, allow the engine 2-3 minutes to warm up prior to riding.

Stopping

Gradually decrease the engine speed to an idle speed and press the kill-switch on the

handlebar down tube.

MAINTENANCE

RECOMMENDED TOOLS

To adjust and service the A-Blaze Signature Series XG-575DS Gas Scooter you will need the

following tools:

Allen Keys: 3/4/5/6mm

Wrenches: 10/13/17mm –Open and Ring Combination

Short Reach Spark Plug Socket

Water Pump Pliers

Philips Head Screwdrivers

Oil, Grease or Lubricant

CARBURETOR ADJUSTMENT

WARNING!! Never start the engine without the complete clutch cover assembled!

Otherwise the clutch can come loose and cause personal injuries.

In the carburetor, fuel is mixed with air. When the engine is test run at the factory, the

carburetor is basically adjusted. A further adjustment may be required from time to time,

depending on climate and altitude.

The carburetor has only one possible adjustment (Tanaka Engine Only):

T = idle speed adjustment screw

Idle Speed Adjustment (Fig. 9)

When the idle speed is adjusted properly, the engine will run smoothly, without pressing

the GAS LEVER.

1.) Start the engine.

2.) Using a long Philips head screwdriver gently close

(clockwise) the T-screw (Fig. 9) until the XG-575DS Gas Scooter

starts to move forward.

3.) Then open (counter-clockwise) the screw until the scooter

stops.

4.) You have reached the correct idle speed when the engine runs smoothly below the RPM

when the scooter starts to move.

WARING!! When the engine is idling, under NO CIRCUMSTANCES should your scooter

be moving!!!

Tabla de contenidos

Otros manuales de Scooter de Xtreme

Xtreme

Xtreme XMB-400 Manual de usuario

Xtreme

Xtreme XP-707 Manual de usuario

Xtreme

Xtreme XR-101 Manual de usuario

Xtreme

Xtreme X-370 Manual de usuario

Xtreme

Xtreme X-010 Manual de usuario

Xtreme

Xtreme XM-3500Li Guía de solución de problemas

Xtreme

Xtreme X-300 Manual de usuario

Xtreme

Xtreme XB-300SLA Manual de usuario

Xtreme

Xtreme METRO EXPRESS Manual de usuario

Xtreme

Xtreme XG-565 A-Blaze Signature Series Manual de usuario

Xtreme

Xtreme X-140 Manual de usuario

Xtreme

Xtreme X-360 Manual de usuario

Xtreme

Xtreme XG-550 Manual de usuario

Xtreme

Xtreme X-140 Manual de usuario

Xtreme

Xtreme XA-750 Manual de usuario

Xtreme

Xtreme X-10 Manual de usuario

Xtreme

Xtreme XT300 Manual de usuario

Xtreme

Xtreme XM-3100 Guía de solución de problemas

Xtreme

Xtreme XMB-320 Manual de usuario

Xtreme

Xtreme XG-470 Manual de usuario

Xtreme

Xtreme XM-5000Li Guía de solución de problemas

Xtreme

Xtreme X-140 Manual de usuario

Xtreme

Xtreme XMB-420 Manual de usuario

Xtreme

Xtreme XB-500 Manual de usuario

Manuales populares de Scooter de otras marcas

TEKTRO

TEKTRO CHEETAH Manual de usuario

Douglas

Douglas Vespa Sprint Guía de instalación

PLAYTIVE

PLAYTIVE AS-2448 Manual de usuario

Ebinger

Ebinger DONKEY XL Manual de usuario

Flyer

Flyer Mountain Guía del usuario

BackCountry eBikes

BackCountry eBikes Storm Manual de usuario

equipmed

equipmed FreeRoam II Manual de usuario

Yoto

Yoto Lion Manual de usuario

WESTHILL BIKES

WESTHILL BIKES LINK Manual de usuario

BAnff

BAnff eProdigy series Manual de usuario

Winther

Winther 475 Manual de usuario

Jetson

Jetson JBZL17 Manual de usuario

First Choice Mobility

First Choice Mobility Roma Medical Corella S741 Manual de usuario

Carrera

Carrera impel Manual de usuario

Afikim

Afikim Superlight SL-3 Manual de usuario

CareCo

CareCo ZOOM Manual de usuario

Douglas

Douglas Vespa G.S. Manual de usuario

Gazelle

Gazelle with BOSCH System Manual de usuario