Xtreme XP-707 Manual de usuario

Page

XP-707

Electric Pocket Bike

Owner’s Manual

Revised 10/10/09

PLEASE BE SAFE WHEN RIDING

ALWAYS WEAR A HELMET AND OBEY ALL LAWS!

X-Treme TM Electric Scooters

Page

BATTERY MAINTENANCE and

CHARGING INSTRUCTIONS

1. You MUST charge completely prior to initial use. (Follow

charging instructions in your Product Handbook)

2. Charge immediately after each use.

3. Charge before storage. You must charge every 30 days if not

in use.

4. Charge the unit for 6-8 hours after the light on the charger turns

green.

5. DO NOT allow this unit to deep discharge the battery.

6. For safety purposes, DO NOT charge for over 24 hours.

7. Turn the unit OFF when not in use.

This PRODUCT IS NOT INTENDED FOR EXTREME or

OFF-ROAD Use! Please take care of your XP-707!

DO NOT JUMP or ABUSE THIS PRODUCT!

DO NOT RIDE IN WET/ICY CONDITIONS!

Failure to follow these instructions will

VOID YOUR WARRANTY!

IMPORTANT

Failure to follow these INSTRUCTIONS will

VOID YOUR WARRANTY!

Page

WARNING

This product does not conform to Federal Motor Vehicle Standards and is not

intended for operation on public streets, roads or highways. Serious injury can

result from the unsafe operations of this product. Operator can minimize these

risks by using certain safety equipment such as: safety helmet, goggles, gloves,

elbow and kneepads and appropriate footwear.

DO NOT operate this product in traffic, on wet, frozen, oily or unpaved surfaces or

under the influence of drugs and/or alcohol. Avoid uneven surfaces, potholes,

surface cracks and obstacles.

DO NOT use a water hose to clean this product. See Product Handbook for more

information.

This product is recommended for riders 14 YEARS OF AGE and older.

SAFETY

Persons without excellent vision, balance, coordination, reflex, muscle and

bone strength and good decision-making capabilities should not use this

product.

Minors without adult supervision should not use this product.

Persons unwilling or unable to take responsibility for their own actions should

not use this product.

The user of this product assumes ALL risks associated with its use. To

minimize these RISKS, the user must wear safety helmet, goggles, gloves,

elbow and kneepads and appropriate footwear.

This product is ELECTRIC! DO NOT ride this product in wet conditions,

puddles or rainy weather.

IMPORTANT

PLEASE READ THIS BEFORE USING THIS PRODUCT

READ THIS FIRST!

Page

SAFETY GUIDE

The recommended age for riding this scooter is 14 years old.

To avoid damage to the motor and footplate, do not overload the scooter.

Never ride with more than one person.

Inspect your scooter thoroughly before each use for loose or missing parts.

Avoid unintentional starts by turning the scooter off while not in use.

To avoid the risk of a short circuit in the electrical parts, do not use your

X-Treme Electric scooter in the rain and never spray or wash off your scooter

with water.

Do not place the battery near fire or heat.

To avoid damage to the battery, do not use the charger if it has been damaged

in any way.

Keep hands, face, feet and hair away from all moving parts.

Do not touch the motor or wheels while they are rotating.

Brakes are designed to control speed as well as stop the scooter. Practice

braking for proper slowing down and smooth stops.

Maintain your X-Treme XP-707 as recommended in this Product Handbook.

Use only quality replacement parts as recommended by the manufacturer.

Inspect the entire scooter prior to each use. Replace any part that is cracked,

chipped or damaged before use.

*NEVER ALLOW CHILDREN TO OPERATE THE SCOOTER WITHOUT ADULT

SUPERVISION.

*NEVER ATTEMPT TO OPERATE THE SCOOTER WHILE UNDER THE

INFLUENCE OF ALCOHOL.

If a situation arises that is not covered in the manual,

proceed with caution and use good judgment.

Contact your dealer or X-Treme (www.x-tremescooters.com/support/)

if you need further assistance

QUICK

REFERENCE

SAFETY GUIDE

Page

TABLE OF CONTENTS

IMPORTANT NFORMATION…………………………………….………………2-3

QUICK REFERENCE……………………………………………………………….4

TABLE OF CONTENTS……………………………….…………….………………5

GETTING TO KNOW YOUR X-TREME XP-707……………………..…………..6

PACKAGE CONTENTS…………………………………………………………….7

GETTING STARTED/ASSEMBLY....……………………………..………………..7

CHARGING…………….…………………………………………………………….8

RIDING…………………….……….………………………..……………………….8

STOPPING AND BRAKING. …………………………………….…………………9

BRAKING SYSTEM…………..…………………………………….…………….…9

ADJUSTING THE BRAKES……….…………….………………………..…….…9

TIRES……………………………………………………….………………………10

BATTERIES…………………..……………………………………...……………..10

MAINTENANCE…….….…………………………………………………………..10

ADJUSTING THE CHAIN………………………...……………………………10-11

MAINTENANCE SCHEDULE…………………………………………………….11

OTHER QUESTIONS…………………………………………………………...…11

GENERAL INFORMATION/TECH SUPPORT………………………………….12

Page

GETTING TO KNOW YOUR X-TREME XP-707

Page

PACKAGE CONTENTS

Your X-Treme XP-707 comes with the following items in the box. Please locate

all of the following:

1. The X-Treme XP-707 Scooter

2. 36V Battery Charger

3. Tool Kit

4. Product Handbook

5. Smoked Windshield

6. Left & Right Foot Pegs

7. Seat Pad

8. Various Nuts/Bolts

GETTING STARTED

Please read and understand these instructions and the OPERATING

PROCEDURES section, prior to starting or riding your XP-707

Fig. 1

Fig. 2

Fig. 3

Assembly

1. Carefully remove the XP-707 from the box.

2. Unfold the left and right handlebars and

secure them at the desired comfortable

position, depending on rider by tightening

the bolts. Fig. 1

3. Adjust the hand brakes to the desired

position and secure them in place by

tightening the bolt. Fig. 2

4. Attach the smoked windshield to the front

fairing using the attached 4

nuts/bolts.

Fig. 3

5. Attach the seat/tank fairing to the frame

using the 4 enclosed nuts.

6. Finally, attach the 2 foot pegs to the frame

and adjust to the desired position. Tighten

into place.

Fig. 4

Page

Charging

Your scooter comes charged out of the carton. We still recommend charging the unit for

8-10 hours prior to it’s first use. We also recommend charging your scooter after each

use and prior to storage.

WARNING: Do not allow your scooter to go into deep discharge, as this will damage the

batteries.

Fig. 5

Fig. 10

Fig. 6

**Your scooter has a variable speed hand throttle. You can control the speed of your

scooter by the amount of pressure you use when rotating the hand throttle. The more

you rotate, the faster you will go.

1. Make sure unit is turned off.

2. Open the charging socket cover

located on the left side of the

seat/tank fairing. Fig. 6)

3. Locate your Battery Charger.

(Fig. 5) Find the charger socket

end plug it into the scooter.

4. Next, plug the AC plug into a wall

outlet.

When first plugged in, the charger has

two red lights that will illuminate at the

same time, indicating that the charging

process has started. Once the light on

the charger turns green, you may remove

the charger and close the safety cap.

RIDING

1. Make sure that all of the exposed bolts and screws

are tightened.

2. Raise the kickstand to its upright position.

3. Turn the scooter on using the key switch located on

the right side of the seat/tank fairing.

4. Gently rotate the THROTTLE GRIP, on the right

side of the handlebars. The XP-707 will begin to

move on its own power.

Page

STOPPING & BRAKING

To brake, release the THROTTLE GRIP and depress the BRAKE LEVERS (on the

left/right side of the handlebars. Depressing the brake will disengage power to the motor.

When the unit feels like it is loosing power or not accelerating to full speed, the scooter is

ready to be re-charged.

BRAKING SYSTEM

The XP-707 uses a front and rear caliper braking system. A hand brake lever on the left

and right side of the handlebar activates them both. Squeezing the hand brake lever with

your left hand activates the rear brake. Squeezing the hand brake lever with your right

hand activates the front brake. Make sure to release the HAND THROTTLE GRIP when

engaging the brakes. Practice braking on a smooth, dry surface to get used to the feel of

the braking system. Braking distance is affected by wet conditions and loose and

uneven riding surfaces.

ADJUSTING THE BRAKES

The Brakes on the XP-707 should come fully adjusted from the factory.

However, it may be necessary to adjust the brakes from time to time.

Fig. 7

Fig. 8

To adjust the brakes:

For brakes that are adjusted too tight:

1. Loosen the tension screw on the

left right hand brake lever by

rotating it counter-clockwise until

the wheel spins freely. (Fig. 7

For brakes that are adjusted too loose:

2. Tighten the tension screw on the

left hand brake lever by rotating it

clockwise until the wheel has a

slight drag. (Fig. 7)

For further adjustment, locate the

caliper mounted at the front and rear

wheels and perform the following

procedure:

1. With one hand, depress the brake

caliper using your thumb and

forefinger (Fig.8).

2. With the other hand, adjust the

tension screw on the brake line until

the desired tensions is obtained.

Page

TIRES

The XP-707 comes standard with racing style tires, otherwise known as racing

slicks. This particular style of tire is not recommended for wet surfaces and

should be avoided. Tire wear will differ based on rider weight, riding

conditions and care. Replacement tires can be obtained at your local X-Treme

dealer, through motorcycle shops, or from the X-Treme website at

www.x-tremescooters.com

Batteries

The XP-707 is a 36V system. The batteries are located under the seat/tank

of the scooter. Should you need to service the batteries, simply unscrew the

four bolts to remove the seat/tank. Be careful of the wires connecting the

ignition and charger socket.

MAINTENANCE

RECOMMENDED TOOLS

To adjust and service the X-Treme XP-707 you will need the following tools:

Allen Wrenches: 3/4/5/6 mm

Wrenches: 10/13/13 mm Open end wrench

Large Adjustable Crescent Wrench

Philips Head Screwdrivers

Oil, Grease or Lubricant

ADJUSTING THE CHAIN

The chain will come adjusted from the factory. However, it may be necessary

to adjust the chain from time to time. The chain must be well aligned onto the

sprockets in order to avoid uneven wear. This will result in shortened chain

life.

How tight should the chain be?

If the chain is skipping or jumping on the sprockets, this is too

loose and may be harmful.

If the chain is making a humming sound when the wheel is

turning, this is too tight and may cause the chain to snap.

The correct tension is achieved by adjusting the chain from its

loose position to when it becomes lightly tense.

Tabla de contenidos

Otros manuales de Scooter de Xtreme

Xtreme

Xtreme X-010 Manual de usuario

Xtreme

Xtreme X-360 Manual de usuario

Xtreme

Xtreme XG-470 Manual de usuario

Xtreme

Xtreme X-140 Manual de usuario

Xtreme

Xtreme X-160 Manual de usuario

Xtreme

Xtreme XG-505 Manual de usuario

Xtreme

Xtreme X-140 Manual de usuario

Xtreme

Xtreme XM-3000 Guía de solución de problemas

Xtreme

Xtreme X-360 Manual de usuario

Xtreme

Xtreme X-600 Manual de usuario

Xtreme

Xtreme XM-4000Li Guía de solución de problemas

Xtreme

Xtreme XB-420M Manual de usuario

Xtreme

Xtreme X-360 Manual de usuario

Xtreme

Xtreme X-600 Manual de usuario

Xtreme

Xtreme XMB-400 Manual de usuario

Xtreme

Xtreme XT300 Manual de usuario

Xtreme

Xtreme XR-302 Manual de usuario

Xtreme

Xtreme XA-750 Manual de usuario

Xtreme

Xtreme XM-5000Li Guía de solución de problemas

Xtreme

Xtreme XMB-320 Manual de usuario

Xtreme

Xtreme X-300 Manual de usuario

Xtreme

Xtreme XG-550 Manual de usuario

Xtreme

Xtreme XB-500 Manual de usuario

Xtreme

Xtreme X-250 Manual de usuario

Manuales populares de Scooter de otras marcas

TEKTRO

TEKTRO CHEETAH Manual de usuario

Douglas

Douglas Vespa Sprint Guía de instalación

PLAYTIVE

PLAYTIVE AS-2448 Manual de usuario

Ebinger

Ebinger DONKEY XL Manual de usuario

Flyer

Flyer Mountain Guía del usuario

BackCountry eBikes

BackCountry eBikes Storm Manual de usuario

equipmed

equipmed FreeRoam II Manual de usuario

Yoto

Yoto Lion Manual de usuario

WESTHILL BIKES

WESTHILL BIKES LINK Manual de usuario

BAnff

BAnff eProdigy series Manual de usuario

Winther

Winther 475 Manual de usuario

Jetson

Jetson JBZL17 Manual de usuario

First Choice Mobility

First Choice Mobility Roma Medical Corella S741 Manual de usuario

Carrera

Carrera impel Manual de usuario

Afikim

Afikim Superlight SL-3 Manual de usuario

CareCo

CareCo ZOOM Manual de usuario

Douglas

Douglas Vespa G.S. Manual de usuario

Gazelle

Gazelle with BOSCH System Manual de usuario