Xtreme X-600 Manual de usuario

Page1

X-600

Electric Scooter

Owner’s Manual

X-Treme TM Electric Scooters

Page2

PLEASE BE SAFE WHEN RIDING

ALWAYS WEAR A HELMET AND OBEY ALL LAWS!

BATTERY MAINTENANCE and

CHARGING INSTRUCTIONS

1. You MUST charge completely prior to initial use. (Follow

charging instructions in your Product Handbook)

2. Charge immediately after each use.

3. Charge before storage. You must charge every 30 days if not in

use.

4. Charge the unit for 6-8 hours or until the light on the charger turns

red & green.

5. DO NOT allow this unit to deep discharge the battery.

6. For safety purposes, DO NOT charge for over 24 hours.

7. Turn the unit OFF when not in use.

This PRODUCT IS NOT INTENDED FOR EXTREME or

OFF-ROAD Use! Please take care of your X-600!

DO NOT JUMP or ABUSE THIS PRODUCT!

DO NOT RIDE IN WET/ICY CONDITIONS!

Failure to follow these instructions will

VOID YOUR WARRANTY!

IMPORTANT

Failure to follow these INSTRUCTIONS will

VOID YOUR WARRANTY!

Page3

WARNING

This product does not conform to Federal Motor Vehicle Standards and is not

intended for operation on public streets, roads or highways. Serious injury can

result from the unsafe operations of this product. Operator can minimize these

risks by using certain safety equipment such as: safety helmet, goggles, gloves,

elbow and kneepads and appropriate footwear.

DO NOT operate this product in traffic, on wet, frozen, oily or unpaved surfaces or

under the influence of drugs and/or alcohol. Avoid uneven surfaces, potholes,

surface cracks and obstacles.

DO NOT use a water hose to clean this product. See Product Handbook for more

information.

This product is recommended for riders 14 YEARS OFAGE and older.

SAFETY

Persons without excellent vision, balance, coordination, reflex, muscle and

bone strength and good decision-making capabilities should not use this

product.

Minors without adult supervision should not use this product.

Persons unwilling or unable to take responsibility for their own actions should

not use this product.

The user of this product assumes ALL risks associated with its use. To

minimize these RISKS, the user must wear safety helmet, goggles, gloves,

elbow and kneepads and appropriate footwear.

This product is ELECTRIC! DO NOT ride this product in wet conditions,

puddles or rainy weather.

IMPORTANT

PLEASE READ THIS BEFORE USING THIS PRODUCT

READ THIS FIRST!

Page4

SAFETY GUIDE

The recommended minimum age for riding this scooter is 14 years old.

To avoid damage to the motor and footplate, do not overload the scooter.

Never ride with more than one person.

Inspect your scooter thoroughly before each use for loose or missing parts.

Avoid unintentional starts by turning the scooter off while not in use.

To avoid the risk of a short circuit in the electrical parts, do not use your

X-Treme Electric scooter in the rain and never spray or wash off your scooter

with water.

Do not place the battery near fire or heat.

To avoid damage to the battery, do not use the charger if it has been damaged

in any way.

Keep hands, face, feet and hair away from all moving parts.

Do not touch the motor or wheels while they are rotating.

Brakes are designed to control speed as well as stop the scooter. Practice

braking for proper slowing down and smooth stops.

Maintain your X-Treme X-600 A-Blaze Signature Series Scooter as

recommended in this Product Handbook.

Use only quality replacement parts as recommended by the manufacturer.

Inspect the entire scooter prior to each use. Replace any part that is cracked,

chipped or damaged before use.

*NEVER ALLOW CHILDREN TO OPERATE THE SCOOTER WITHOUT ADULT

SUPERVISION.

*NEVER ATTEMPT TO OPERATE THE SCOOTER WHILE UNDER THE

INFLUENCE OF ALCOHOL.

If a situation arises that is not covered in the manual,

proceed with caution and use good judgment.

Contact your dealer or X-Treme (www.x-tremescooters.com/support/)

if you need further assistance

QUICK REFERENCE

SAFETY GUIDE

Page5

TABLE OF CONTENTS

IMPORTANT INFORMATION…………………………………….……………...........................................2-3

QUICK REFERENCE…………………………………………………………………………………………. 4

TABLE OF CONTENTS……………………………….…………….………………………………………… 5-6

GETTING TO KNOW YOUR X-TREME X-600………………….………………………………………….. 8

PACKAGE CONTENTS & GETTING STARTED…………………………………………………………… 9

GETTING STARTED………………..……………………………..….………………………………………..9

ASSEMBLY, FUSE INSTALLATION……………………………….…………….........................................9-10

CHARGING, RIDING & BRAKING..………………………………………………...................................... 11

FOLDING AND STORAGE……….………………………..…………..………………………………………12

BRAKING SYSTEM………….…………………………………….…..……………………………………….12

TIRE PRESSURE……………………………………………………...……………………………………… 13

MAINTENANCE……………………………………………………..…………………………………………. 14-15

TROUBLESHOOTING GUIDE……………………………………..………………………………………… 16

HOW TO GUIDE……………………………………………………………………………………………….. 17-23

How To Start Scooter……………………………………………………………………………………. 17

How To Adjust Chain……………………………………………………………………………………. 17

How To Adjust Disc Brakes………………………………..…………………………………………… 17-18

How To Understand Charger Light Sequence……………………………………………………….. 18

How To Check Charger Output………………………………………………………………………… 18

How To Install Bearings………………………………………………………………………………… 19

How To Remove & Insert Pin Connectors……………………………………………………………. 19

How To Determine Which Controller Version You Have…………………………………………….. 19

How To Replace/Install Controller…………………………………………………………………….. 19-20

How To Test Motor Direct To Battery……………………………………………………………………20

How To Check Battery Wires…………………………………………………………………………… 20-21

How To Change Charger Socket……………………………………………………………………….. 21

How To Check Fuse……………………………………………………………………………………... 21

How To Replace Fuse…………………………………………………………………………………… 22

Page6

How To Remove Rear Wheel……………………………………………………………………………22

How To Install Seat Extension………………………………………………………………………….. 22

How To Replace/Install Throttle………………………………………………………………………… 23

TROUBLESHOOTING GUIDE……………………………………………………………………………….. 24-29

Troubleshooting: No Power…………………………………………………………………………….. 24

Troubleshooting: After Fully Charging, Powers Only For Short Distance Use……………………. 24-25

Troubleshooting: Scooter Takes Off, Will Not Stop…………………………………………………… 25

Troubleshooting: Scooter On, Not Running…………………………………………………………… 26

Troubleshooting: Scooter Will Not Shut Off…………………………………………………………… 26

Troubleshooting: Scooter Won’t Run, Charger Stays Green……………………………………….. 26

Troubleshooting: Scooter Won’t Run, Charger Stays Red & Green……………………………….. 26

Troubleshooting: Scooter Going Slow………………………………………………………………… 27

Troubleshooting: Grinding Noise In Rear……………………………………………………………… 27

Troubleshooting: Scooter Seems Fine Until Sat On, Then Will Not Go Or Pops Fuse…………... 28

Troubleshooting: Tire Problems………………………………………………………………………… 28

Troubleshooting: Scooter Not Showing Full Charge After Charging 8 Hours………………………28

Troubleshooting: Removing & Checking Wire Terminals…………………………………………… 28-29

DIAGRAMS……………………………………………………………………………………………………... 30-31

Battery Wiring Diagram…………………………………………………………………………………. 30

Wiring Diagram……………………………………………………………………………………………31

OTHER QUESTIONS………………………………………………………………………………………….. 32

Page7

DO NOT RETURN TO STORE!

Do not use this vehicle for the first time until you have inflated the tires to the correct PSI

and completely charged the battery. Failure to follow these instructions may damage your

vehicle and void your warranty.

CALL OR GO ONLINE

1-253-777-0690 www.x-tremescooters.com/support/

For General Information or Parts Visit www.x-tremescooters.com

Page8

GETTING TO KNOW YOUR

X-TREME X-600

A-BLAZE SIGNATURE SERIES

(Photo’s may vary)

Page9

PACKAGE CONTENTS

Your X-Treme X-600 A-Blaze Signature Series Scooter comes with the following

items in the box. Please locate all of the following:

1. X-Treme X-600 Aiden Blaze Signature Series Scooter

2. 36V Battery Charger

3. Tool Kit User Manual and 20amp Fuses

4. Seat

5. Seat Post & Clamp

GETTING STARTED

Please read and understand these instructions and the OPERATING

PROCEDURES section, prior to starting or riding your X-600

Assembly

1. Carefully remove the X-600 from the box.

2. To unfold the X-600, begin by pressing

down on the FOLDING HANDLE with one

hand while gently pulling up on the

handlebars with the other.

3. Fully extend the handlebars to their upright

position until you feel the mechanism lock

into place.

4. Attach the handlebars by inserting the

silver handlebar clamp onto the handlebar

post stopping just below the top. Be sure

to orient the bars in the correct riding

position with the throttle on the rider’s right

side. Secure the handlebars to the post

by tightening the bolts on the clamp with

the enclosedAllen wrench as shown.

5. Secure the hand brakes in place by using

the provided Allen Wrench to first loosen

the tension bolts. Adjust the levers to a

comfortable position and tighten the bolts.

*BE CAREFUL NOT TO PULL ON THE

CABLES!

Page10

Assembly –Cont:

6. Insert the 20amp fuse by opening the

footplate cover as shown. Insert the fuse

into the fuse holder then close the footplate

cover.

7. Attach the seat post to the seat post

receiver, then attach the clamp to the top of

the seat post. Pull the upper seat post to

the desired position and tighten the clamp

securely.

8. Attach the seat to the upper seat post and

tighten the seat bolts as shown.

Otros manuales para X-600

Tabla de contenidos

Otros manuales de Scooter de Xtreme

Xtreme

Xtreme X-360 Manual de usuario

Xtreme

Xtreme XG-550 Manual de usuario

Xtreme

Xtreme XM-4000Li Guía de solución de problemas

Xtreme

Xtreme X-250 Manual de usuario

Xtreme

Xtreme XR-302 Manual de usuario

Xtreme

Xtreme XB-420M Manual de usuario

Xtreme

Xtreme Rubicon 48V Manual de usuario

Xtreme

Xtreme XR-101 Manual de usuario

Xtreme

Xtreme X-140 Manual de usuario

Xtreme

Xtreme X-10 Manual de usuario

Xtreme

Xtreme X-500 Manual de usuario

Xtreme

Xtreme XG-499 Manual de usuario

Xtreme

Xtreme X-360 Manual de usuario

Xtreme

Xtreme XMB-320 Manual de usuario

Xtreme

Xtreme XG-565 A-Blaze Signature Series Manual de usuario

Xtreme

Xtreme XG-505 Manual de usuario

Xtreme

Xtreme X-400 Manual de usuario

Xtreme

Xtreme XB-300SLA Manual de usuario

Xtreme

Xtreme XB-300SLA Manual de usuario

Xtreme

Xtreme XM-5000Li Guía de solución de problemas

Xtreme

Xtreme X-370 Manual de usuario

Xtreme

Xtreme X-360 Manual de usuario

Xtreme

Xtreme X-140 Manual de usuario

Xtreme

Xtreme METRO EXPRESS Manual de usuario

Manuales populares de Scooter de otras marcas

TEKTRO

TEKTRO CHEETAH Manual de usuario

Douglas

Douglas Vespa Sprint Guía de instalación

PLAYTIVE

PLAYTIVE AS-2448 Manual de usuario

Ebinger

Ebinger DONKEY XL Manual de usuario

Flyer

Flyer Mountain Guía del usuario

BackCountry eBikes

BackCountry eBikes Storm Manual de usuario

equipmed

equipmed FreeRoam II Manual de usuario

Yoto

Yoto Lion Manual de usuario

WESTHILL BIKES

WESTHILL BIKES LINK Manual de usuario

BAnff

BAnff eProdigy series Manual de usuario

Winther

Winther 475 Manual de usuario

Jetson

Jetson JBZL17 Manual de usuario

First Choice Mobility

First Choice Mobility Roma Medical Corella S741 Manual de usuario

Carrera

Carrera impel Manual de usuario

Afikim

Afikim Superlight SL-3 Manual de usuario

CareCo

CareCo ZOOM Manual de usuario

Douglas

Douglas Vespa G.S. Manual de usuario

Gazelle

Gazelle with BOSCH System Manual de usuario