Ipf electronic OTQ80576 Manual de usuario

MANUAL •Subject to alteration! Version: November 2019

ipf electronic gmbh

•Rosmarter Allee 14 •58762 Altena

│

Tel +49 2351 9365-0 •Fax +49 2351 9365-19

│

[email protected] •www.ipf-electronic.com 1

OTQ80576

Optical sensors

Diffuse reflection sensor with background suppression

Iplastic housing

Isetting via teach-in

Istatus LED as alignment aid

IM8-connecor 4-pin

TECHNICAL DATA

function

diffuse reflection sensor, background suppression

sensing range

3 … 132mm

sensing distance

20 … 120mm

voltage supply +Vs

10 … 30V DC

current consumption (w/o load)

40mA

voltage drop (max. load)

output current (max. load)

50mA

output signal

Push-pull, no/nc

short-circuit protection

reverse polarity protection

response / delay time (high-speed-mode)

≥0.25ms

sampling frequency (high-speed-mode)

≤ 2kHz

transmitting element (pulsed)

LED, red light, punctiform

wave length

644nm

display (operation)

LED green

display (signal / alignment)

LED yellow

switchpoint setting

teach-in and IO-Link

suppression of reciprocal influence

housing material

plastic (ASA, PMMA)

front screen material

PMMA

degree of protection (EN 60529)

IP 67

operating temperature

-25 … +60°C

connection

M8 cable connector, 4-pin, L=200mm

connection accessories

e.g.VK200375

accessories (universal-holder)

AY000116

Connection Dimensional drawing

small light spot thanks to PIN-Point-LED

IO-Link interface

MANUAL •Subject to alteration! Version: November 2019

ipf electronic gmbh

•Rosmarter Allee 14 •58762 Altena

│

Tel +49 2351 9365-0 •Fax +49 2351 9365-19

│

[email protected] •www.ipf-electronic.com 2

Beam path Mounting

Description of the LED-display:

LED-indication Legend operating mode

LED on

LED flashing 1Hz

LED flashing 2Hz

LED flashing 8Hz

Description Teach-In Level 1 & 2:

Level 1 = 1-point teach: sets the switchpoint at the position of the object + 10%*

Level 2 = 2-point teach: sets the switchpoint in the middle of position A & B

* This value is adjustable by IO-Link. Please check the IO-Link manual.

The direct reflection from glossy or

reflective objects must not impinge

on the receiver. This can be avoided

by slightly tilting the sensor.

It is recommended that the object

to be detected approaches the

active area of the sensor from the

side, which avoids malfunctions

caused by deflection of the light

beam at edges.

LED-indicators

green

yellow

power on

short-circuit

output 1 active

output 1 signal close to

threshold

teach-in mode

see teach-in instruction

MANUAL •Subject to alteration! Version: November 2019

ipf electronic gmbh

•Rosmarter Allee 14 •58762 Altena

│

Tel +49 2351 9365-0 •Fax +49 2351 9365-19

│

[email protected] •www.ipf-electronic.com 3

Optional teach-in methods, configurable via IO-Link:

Window-mode: Level 1 / 1-point teach: set a window of ± 10% around the position of the object.

Level 2 / 2-point teach: set a window within the object is being detected.

Dynamic Teach-In: Available also for window mode. Enter teach level 1 to start the data acquisition and TAP to stop

the data acquisition (duration 2 … 15s). The switchpoint or window is defined by the detected

min & max value.

Teach-in instruction

SAFETY WARNINGS:

Before initial operation, please make sure to follow all safety instructions that may be provided in the product

information!

Never use these articles in applications where the safety of a person depends on their functionality.

Enter teach level

-Place a ferromagnetic tool as

shown right or connect teach-in

wire +Vs.

-Green and yellow LED light up, if

tool / teach-in is recognized

properly.

-Remove tool after n seconds for

desired level

A TAP is a short touch of the tool

as shown right.

General information

-5min after power up the teach with tool

will be locked.

-In teach mode the output changes to

0V.

-During operation the teach wire should

be connected to 0V.

-For external teach-in connect the teach

wire to +Vs.

-External teach-in is always possible (no

locking)

-Place tool > 2sec: Leave teach-in

without changes.

Otros manuales de Accesorios de ipf electronic

ipf electronic

ipf electronic PRQ80376 Manual de usuario

ipf electronic

ipf electronic OT330571 Manual de usuario

ipf electronic

ipf electronic PY740020 Manual de usuario

ipf electronic

ipf electronic UT139570 Manual de usuario

ipf electronic

ipf electronic IV56E205-S Manual de usuario

ipf electronic

ipf electronic PT65 Series Manual de usuario

ipf electronic

ipf electronic ON330571 Manual de usuario

ipf electronic

ipf electronic OTQ90170 Manual de usuario

ipf electronic

ipf electronic DW34312 Series Manual de usuario

ipf electronic

ipf electronic OTR49170 Manual de usuario

ipf electronic

ipf electronic OTR49175 Manual de usuario

ipf electronic

ipf electronic OT059170 Manual de usuario

ipf electronic

ipf electronic ON430570 Manual de usuario

ipf electronic

ipf electronic OT0591A4 Manual de usuario

ipf electronic

ipf electronic UT309023 Manual de usuario

ipf electronic

ipf electronic UT30C310 Manual de usuario

ipf electronic

ipf electronic UT36002B Manual de usuario

ipf electronic

ipf electronic UT189023 Manual de usuario

ipf electronic

ipf electronic UT990934 Manual de usuario

ipf electronic

ipf electronic OT05E244 Manual de usuario

ipf electronic

ipf electronic OR150400 Manual de usuario

ipf electronic

ipf electronic DW35312 Series Manual de usuario

ipf electronic

ipf electronic OTR49176 Manual de usuario

ipf electronic

ipf electronic UT139073 Manual de usuario

Manuales populares de Accesorios de otras marcas

Hillco

Hillco 2810 Manual de usuario

Siemens

Siemens QSA2700D Manual del operador

Contours

Contours ZY024 Manual de usuario

Saivod

Saivod VS621 Manual de usuario

Virtuox

Virtuox VirtuCLEAN 2.0 Manual de usuario

SCE

SCE ENVIRO-THERM SCE-TE170B24VSS Manual de usuario

Z-Wave

Z-Wave HSD-200Z Manual de usuario

turck

turck FMX-IM-2UPLI63FX Manual de usuario

Decagon Devices

Decagon Devices 10HS Manual de usuario

UPPAbaby

UPPAbaby Cup Holder Manual de usuario

Elko

Elko SmartSensor Leakage Wireless Manual de usuario

Grizzly

Grizzly H8371 Manual de usuario

Panasonic

Panasonic HG-T Series Manual de usuario

IFM Electronic

IFM Electronic Efector 250 Series Guía de referencia

DigiDesign

DigiDesign 888/24 I/O Manual de usuario

PROZIS

PROZIS QUAY Manual de usuario

patagonia

patagonia PSI Vest Manual de usuario

SFC Energy

SFC Energy EFOY GO! Manual de usuario

ipf electronic OTQ80576 Manual de usuario

Manuales populares de Accesorios de otras marcas