Danfoss PCV-VFG 21 Manual de usuario

Installation Guide

District Energy VI.JA.L1.02 DEN-SMT/SI

Assembly kit PCV-VFG 21 DN 100-125

◯

A+◯

◯

A+◯

❶❷

①

②

❸➍

min 300 min 300

②

Throttling element

①

◯

Cu pipe

Ø 6 × 1 × 1500 mm

Cu pipe

Ø 10 × 1 × 3000 mm

Pilot controller

AVP DN 25

Assembly kit valve unit

PCV-VFG 21 DN 100-125

Cu Ø 10 × 1

❺

❻

Cu Ø 10 × 1

②

①

③

Installation Guide Assembly kit PCV-VFG 21 DN 100-125

DEN-SMT/SI VI.JA.L1.02 District Energy

Cu Ø10 × 1

Cu Ø6 × 1

➐

PCVD

Main controller

Pilot controller

Trottling

element ◯

PCVSD

Main controller

Pilot controller

Trottling

element ◯

PCVA

Main controller

Pilot controller

Trottling

element

◯

PCVSA

Main controller

Pilot controller

Trottling

element

◯

PCVQ

Main controller

Pilot controller

Trottling

element

◯

PCVP

Pilot controller

Trottling

element

Main controller

◯

Installation in the supplay pipe

◯

A◯

Main controller

Trottling

element

Installation in the return pipe

Pilot controller

PCVP

Installation Guide Assembly kit PCV-VFG 21 DN 100-125

District Energy VI.JA.L1.02 DEN-SMT/SI

Safety Note

To avoid injury and damage to persons

and devices, it is absolutely necessary

these instructions are carefully read and

observed prior to assembly and commissioning.

Necessary assembly, start-up, and maintenance

work must be performed only by qualiﬁed,

trained and authorised personnel.

Prior to assembly and maintenance work on the

controller, the system must be:

- depressurized

- cooled down

- emptied

- cleaned

Please comply with the instructions of the

system manufacturer or system operator.

Disposal instruction

This product should be

dismantled and its components

sorted, if possible, in various

groups before recycling or

disposal.

Always follow the local disposal regulations.

Deﬁnition of Application

The controller is used for diﬀerential

pressure control of water and water glycol

mixtures for heating, district heating and

cooling systems.

The technical data on the rating plates

determine the use.

Scope of Delivery

Assembly kit PCV-VFG21:

main valve, throttling element, impulse

tube (throttle to main actuator)

To order additionally:

pilot valve, impulse tube set and thread tail

pieces for pilot valve.

Not included:

bypass pipes

Bypass pre-assembly ❶

Remove ﬂat gaskets from tailpieces before

welding.

Welding: tailpiece to bypass pipe 2x, tail piece

to tailpiece 1x. Make a joint (A) ﬁrst and then do

welding (B).

Return ﬂat gaskets to tailpieces.

Bypass assembly ❷

Connect a throttling element to the pilot

valve ①using welded tailpieces: align

ﬂow direction – throttle in front of the pilot

valve. Align valve actuator and throttle

impulse connection as on drawing.

Connect bypass pipes ②: align pipes and

valve as on drawing.

Holes for Bypass ❸

Mark connection points on a main pipe

and drill holes for bypass ﬂow.

Connect bypass ❹

Make a join ①. Align main and bypass

media ﬂow direction. Remove main valve

and weld bypass pipe to main pipe.

Return main valve ❺, check ﬂow

orientation. Connect impulse tube from

throttling element to main valve pressure

actuator.

Impulse Tube mounting ❻

Put the steel ring into copper impulse tube ①,

press it completely in②. Immerse the end into

connection screw ③and tighten with a key ④.

Connect pilot valve impulse tubes for

controllers ➐

ENGLISH

Installation Guide Assembly kit PCV-VFG 21 DN 100-125

VI.JA.L1.02 Produced by Danfoss A/S © 10/2013

Otros manuales de Unidad de control de Danfoss

Danfoss

Danfoss MCV111B Series Manual de usuario

Danfoss

Danfoss iC7 Series Manual de usuario

Danfoss

Danfoss OPTYMA Manual de usuario

Danfoss

Danfoss VX Solo II Series Manual de usuario

Danfoss

Danfoss PVE 3 Series Manual de usuario

Danfoss

Danfoss EVR 2 Manual de usuario

Danfoss

Danfoss VLT series Manual de usuario

Danfoss

Danfoss SVA-S SS 15 Manual de usuario

Danfoss

Danfoss MSV-C Manual de usuario

Danfoss

Danfoss VLT AutomationDrive FC 360 Manual de usuario

Danfoss

Danfoss EV250B NC Manual de instrucciones de instalación

Danfoss

Danfoss PVG 100 Instrucciones de construcción

Danfoss

Danfoss ICV PM 25 Manual de usuario

Danfoss

Danfoss OPTYMA Manual de instrucciones

Danfoss

Danfoss VLT 380-500 V Guía

Danfoss

Danfoss VHX-DUO Manual de instrucciones de instalación

Danfoss

Danfoss ICM Instrucciones de funcionamiento

Danfoss

Danfoss RLV Manual de usuario

Danfoss

Danfoss PVG 120 Manual

Danfoss

Danfoss PVG 120 Manual

Danfoss

Danfoss SVA-S 15-200 Series Manual de usuario

Danfoss

Danfoss ECL Comfort 210 Manual de usuario

Danfoss

Danfoss CHV-X 15-125 Manual de usuario

Danfoss

Danfoss TEA 20 Manual de usuario

Manuales populares de Unidad de control de otras marcas

Festo

Festo Compact Performance CP-FB6-E Manual de lista de piezas

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Manual de usuario

JS Automation

JS Automation MPC3034A Manual de usuario

JAUDT

JAUDT SW GII 6406 Series Guía rápida

Spektrum

Spektrum Air Module System Manual de usuario

BOC Edwards

BOC Edwards Q Series Manual de usuario

KHADAS

KHADAS BT Magic Manual de usuario

Etherma

Etherma eNEXHO-IL Manual de usuario

PMFoundations

PMFoundations Attenuverter Manual de usuario

GEA

GEA VARIVENT Manual de usuario

Walther Systemtechnik

Walther Systemtechnik VMS-05 Manual de usuario

Altronix

Altronix LINQ8PD Instrucciones de montaje

Eaton

Eaton Powerware Series Manual de usuario

WAGO

WAGO 750-407/040-000 Manual de usuario

Sony

Sony CCU-590 Manual de usuario

Graco

Graco 25D614 Manual de usuario

Task Force Tips

Task Force Tips YE-RF-900 Manual de programación

Shini

Shini SPV-U Series Manual de usuario