Cobra 602-2704 Manual de usuario

23801 E. La Palma Ave., Yorba Linda, CA 92887 Ph. 714.692.8180 Fax. 714.692.5016

www.cobrausa-vtwin.com

01/20

*Cobra®recommends you always wear a helmet while riding. Please never operate your motorcycle while under

the influence of alcohol and/or drugs. Enjoy the new look of your motorcycle and please ride safely.

Items Supplied >

1 –DETACHABLE 2-UP TOUR PACK MOUNT

4 –WASHER, FLAT ¼”

4 –NUT, FLANGED HEX NYLOCK ¼” ZINC

Application(s) >

HARLEY:

DRESSER 2014 - 2020

Instruction Manual >

Read all instructions, including the instructions for the Tour Pack to be installed, carefully and

completely before installing your new Tour Pack!

NOTE: You must install either a COBRA Mounting Kit (602-2100/602-2101) or a Harley Davidson 4

point Mounting Kit before installing this rack.

Initial installation of Tour Pack to Tour Pack mount:

1. Empty the Tour Pack to be installed of all of its contents.

Use FIGURE 1 and TABLE 1 for steps #2-5

NOTE: We recommend having someone assist you with the next steps, to prevent scratching the Tour Pack, mount,

or motorcycle.

2. Insert the four threaded studs of the Tour Pack through the holes of the Tour Pack mount (1).

3. Install a ¼” I.D. washer (2) and a ¼”-20 nylon locknut (3) onto each of the studs of the Tour Pack underneath the

Tour Pack mount (1), but DO NOT TIGHTEN at this time.

4. In the slots of the Tour Pack mount (1), slide the Tour Pack forwards or backwards to the desired position.

5. TORQUE TO 120 in-lbs or 13.5 Nm the four ¼”-20 nylon locknuts(3) installed in step #3.

6. Consult the instructions for the Tour Pack, check to make sure that all the hardware of the Tour Pack is torqued

to their specified values.

Tour Pack mount attachment to mounting kit procedure:

7. Once the Tour Pack and mount have been assembled you can attach the Tour Pack to the mounting kit on the

motorcycle. Do so by inserting the front portions of the mount brackets over the front mounting bosses of the

mounting kit. See FIGURE 2. Make sure to insert the mount all the way onto the bosses.

8. Slowly rotate the mount downward so the rear portion of the brackets slips over the rear mounting kit bushings.

See FIGURE 2.

9. If you are using a Harley Mounting Kit, you may need to adjust the width of the mounting kit bushings with

spacers in order for them to align with the width of the Tour Pack mount brackets. Please see the instructions

that come with the mounting kit for more details.

10. Also, some Harley Mounting Kits come with oval shaped mounting bushings. These mounting bushings may

need to be rotated around the center axis of the bushing to allow for a secure fit of the detachable latch pin.

Please see the instructions of the mounting kit for more details.

11. Pull backward on both detachable latch knobs and then push downward on the Tour Pack to allow the mount to

sit completely on the mounting kit bushings. Then release the detachable latch knob to fully engage the latch pin

underneath the mounting kit bushing. See FIGURE 2.

602-2704 / 602-2704B

Page 1 of 2

DOCUMENT NO. 0017 REV. A

CONTINUED ON PAGE 2

23801 E. La Palma Ave., Yorba Linda, CA 92887 Ph. 714.692.8180 Fax. 714.692.5016

www.cobrausa-vtwin.com

01/20

Instruction Manual >

602-2704 / 602-2704B

Page 2 of 2

11. Always check to make sure both detachable latch pins

are fully engaged on the bottom of the mounting kit

bushing.

12. Remove the saddle bags per the instructions in the

Owner’s Manual, and make any adjustments to the

mounting kit bushings until the detachable rack goes

on and off easily and securely.

13. Once all the adjustments have been made, verify all

hardware has been tightened and reinstall the saddle

bags.

14. Before each ride, check to make sure the detachable

latch pins are fully engaged underneath the mounting

bushings.

15. Check the tightness of all the screws after the first ride

and after the first 500 miles.

DOCUMENT NO. 0018 REV. A

ITEM

DESCRIPTION

QUANTITY

TOUR PACK MOUNT

1/4" I.D. WASHER

1/4-20 FLANGED NYLOCK NUT

TABLE 1, HARDWARE REFERENCE

FIGURE 2, TOUR PACK MOUNT INSTALLED

*** DO NOT *** EXCEED THE MAXIMUM WEIGHT CAPACITY OF THE TOUR PACK MOUNT,

MAX. WEIGHT CAPACITY INCLUDES TOUR PACK AND CONTENTS = 25 POUNDS.

MAKE SURE

LATCH PIN IS

FULLY ENGAGED

UNDER BUSHING

FRONT

MOUNTING

BUSHING

SOLO TOUR

PACK MOUNT

(TOUR PACK

REMOVED FOR

VISIBILITY)

DETACHABLE

LATCH KNOB

REAR

MOUNTING

BUSHING

FIGURE 1, HARDWARE INSTALLATION

ARROWS LEADING TO TOUR PACK STUDS

(OMITTED FOR VISIBILITY)

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Accesorios para motocicletas de Cobra

Cobra

Cobra 602-2500 Manual de usuario

Cobra

Cobra 602-3000 Manual de usuario

Cobra

Cobra P259643 Manual de usuario

Cobra

Cobra 6468B Manual de usuario

Cobra

Cobra Fi2000 Manual de usuario

Cobra

Cobra 602-2612B Manual de usuario

Cobra

Cobra 6057 Manual de usuario

Cobra

Cobra Fi2000 Manual de usuario

Cobra

Cobra Fi2000 PowrPro Black Manual de usuario

Cobra

Cobra 02-6468 Manual de usuario

Cobra

Cobra Ride Loud Manual de usuario

Cobra

Cobra Classic LT Manual de usuario

Cobra

Cobra Anything's Possible 601-2101B Manual de usuario

Cobra

Cobra 602-2601 Manual de usuario

Cobra

Cobra 602-2046 Manual de usuario

Cobra

Cobra 6255RB Manual de usuario

Cobra

Cobra 06-0225-02B Manual de usuario

Cobra

Cobra 602-2702 Manual de usuario

Cobra

Cobra Fi2000 Manual de usuario

Cobra

Cobra POWRFLO Manual de usuario

Cobra

Cobra 06-0225-01B Manual de usuario

Cobra

Cobra 602-2611 Manual de usuario

Cobra

Cobra 602-2000 Manual de usuario

Cobra

Cobra 05-9349 Manual de usuario

Manuales populares de Accesorios para motocicletas de otras marcas

SRC

SRC B-TRK502-01-01-SL Manual de usuario

3M Speedglas 9100 MP Manual de usuario

hepco & becker

hepco & becker 6307520 00 01 Manual de usuario

HOMCOM

HOMCOM AA0-077 Manual de usuario

hepco & becker

hepco & becker 6307558 00 01 Manual de usuario

Wunderkind Custom

Wunderkind Custom 106503-F15 Guía del usuario

Dräger

Dräger HPS 3500 Manual de usuario

M-WAVE

M-WAVE SKI Manual de usuario

Kuryakyn

Kuryakyn 6212 Manual de usuario

hepco & becker

hepco & becker 6507504 00 01 Manual de usuario

Tool it

Tool it PROMAX LCD 9.13G Manual de usuario

Custom Dynamics

Custom Dynamics TruWrapz Manual de usuario

Roof

Roof RO200 CARBON Manual de usuario

Kabuto

Kabuto Japan IBUKI Manual de usuario

PUIG

PUIG 5051 Manual de usuario

rizoma

rizoma ZTH050 Manual de usuario

Joubert

Joubert 10001711 Manual de usuario

Sperian

Sperian Optrel p420 Manual de usuario