Whalen WSF42OW23W Manual de usuario

THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY INFORMATION.

PLEASE READ AND KEEP FOR FUTURE REFERENCE.

Date 2016-05-27 Rev. 0001-A Factory: DOCHDI

Leland 42" Fireplace Console

Model # WSF42OW23W

ADULT ASSEMBLY REQUIRED

If you have any questions regarding assembly or if parts are missing, DO NOT return this item to the

store where it was purchased. Please call our toll-free customer service number and have your

instructions and parts list ready to provide the model name, part name or factory number:

1-866-942-5362

Pacific Standard Time: 8:30 a.m. - 4:30 p.m., Monday - Friday

Or visit our website www.whalenfurniture.com

Or e-mail your request to:

[email protected]

LOT NUMBER:

DATE PURCHASE

MANUFACTURER: Whalen Furniture Manufacturing

CATALOG: Leland 42" Fireplace Console (WSF42OW23W)

MADE IN CHINA

Important

Before you begin: Open, identify and count all parts prior to assembly. Lay out parts on a flat and non-abrasive

surface. You will need the parts identified on pages 3 and 4 of this instruction manual.

NOTE: IT IS VERY IMPORTANT TO USE GLUE WITH THE DOWELS. EXCESS GLUE CAN BE

WIPED OFF WITH A DAMP CLOTH.

Insert Dowel at least half way by tapping lightly with a rubber mallet (not included), IF NECESSARY.

MAXIMUM RECOMMENDED WEIGHT LOADS

THIS UNIT IS NOT INTENDED FOR USE WITH CRT TVS. USE ONLY WITH FLAT

PANEL TVS AND AUDIO/VIDEO EQUIPMENT MEETING RECOMMENDED SIZE AND WEIGHT

LIMITS. NEVER USE WITH LARGER/HEAVIER THAN RECOMMENDED FLAT PANEL TVS OR

EQUIPMENT. TO AVOID INSTABILITY, PLACE FLAT PANEL TV IN THE CENTER OF THE UNIT; THE

BASE OF THE TELEVISION MUST BE ABLE TO REST ON THE SUPPORTING SURFACE OF THE

UNIT WITHOUT OVER-HANGING THE EDGES. IMPROPERLY POSITIONED FLAT PANEL TVS, OR

FLAT PANEL TVS INCLUDING OTHER EQUIPMENT THAT EXCEED RECOMMENDED SIZE AND

EIGHT LIMITS COULD FALL OFF OR BREAK THE UNIT, CAUSING POSSIBLE SERIOUS INJURY.

PLACE TV BEHIND THE STOPPER

MAXIMUM LOAD 22.7 kg / 50 lb.

FITS UP TO MOST 50” FLAT PANEL TVs

MAXIMUM LOAD 61.2 kg / 135 lb.

FINAL

1 2 43

Parts and Hardware List

Please read completely through the instructions and verify that all listed parts and hardware are present

before beginning assembly.

A- Top Panel (Qty. 1) B- Top Corner Extension (Qty. 1) C- Upper Left Side Frame (Qty. 1)

D- Upper Right Side Frame (Qty. 1) E- Center Shelf (Qty. 1) F- Lower Side Panel (Qty. 2)

G- Left Front Panel (Qty. 1) H- Right Front Panel (Qty. 1) I- Center Crossbar (Qty. 1)

J- Base (Qty. 1) K- Corner Support (Qty. 1) L- Barrister Door (Qty. 1)

M- Glass Door Panel (Qty. 1) N- Speaker Grill (Qty. 1) O- Wood Door Panel (Qty. 1)

(Pre-attached)

Parts and Hardware List

Please read completely through the instructions and verify that all listed parts and hardware are present

before beginning assembly.

P- Back Panel (Qty. 1)

Fireplace Insert (Qty. 1) Remote Control with Battery (Qty. 1)

(1) Ø1/4” x 5/8” Bolt (2) Ø1/4” x 1-1/4” Bolt (3) Lock Washer

(Qty. 10+1 extra) (Qty. 26+1 extra) (Qty. 26+1 extra)

(4) Flat Washer

(5) M8 x 30 mm Wood Dowel

(6) Ø3.5 x 12 mm Screw

(Qty. 26+1 extra) (Qty. 42+2 extra) (Qty. 8+1 extra)

(7) Ø3.5 x 15 mm Washer Head Screw (8) Knob (9) Small Metal Bracket

(Qty. 20+1 extra) (Qty. 1) (Qty. 2)

(10) Knob Bolt (Qty. 1) (11) Acrylic Stopper (Qty. 1) (12) Hook (Qty. 2)

(13) Large Metal Bracket (Qty. 2) (14) Connector (Qty. 5) Allen Wrench (Qty. 1)

Glue (Qty. 1) Touch-up Pen (Qty. 1) Tipping Restraint Hardware Kit (Qty. 2)

(Included in plastic bag)

Tools required: Allen wrench (provided), Phillips screwdriver and hammer (not provided).

Assembly Instructions

1. Unpack the unit and confirm that you have all the hardware and required parts. Assembly the unit on a

carpeted floor or the empty carton to avoid any scratch.

2. Glue two Wood Dowels (5) into the inner holes on one Lower Side Panel (F) and attach it to the Left

Front Panel (G) with two 1-1/4” Bolts (2) and two Washers (3 and 4).

3. Repeat the same procedure to combine the other Lower Side Panel (F) with the Right Front Panel (H)

together.

4. Using the pilot holes as a guide, attach two Small Metal Brackets (9) to the Center Crossbar (I) with two

12 mm Screws (6) as shown.

234

Assembly Instructions

5. Glue four Wood Dowels (5) into the drilled holes on the Center Crossbar (I) at both ends and attach it

between the Left and Right Front Panels (G and H) as shown. Insert two 12 mm Screws (6) through the

Small Metal Brackets (9) and screw into the Front Panels (G and H).

6. Glue ten Wood Dowels (5) into the top holes of the previous assembly.

7. Position the Center Shelf (E) onto the inserted Wood Dowels (5) and fasten in place with eight 1-1/4”

Bolts (2) and eight Washers (3 and 4).

Assembly Instructions

8. Glue eight Wood Dowels (5) into the non-threaded holes on the Base (J).

9. Position the previous assembly onto the inserted Wood Dowels (5) on the Base (J) and attach in place

with six 1-1/4” Bolts (2) and six Washers (3 and 4).

10. Glue six Wood Dowels (5) into the non-threaded holes on the Center Shelf (E).

11. Position the Upper Side Frames (C and D) onto the inserted Wood Dowels (5) and attach them to the

Fixed Shelf (E) with four 1-1/4” Bolts (2) and four Washers (3 and 4).

Assembly Instructions

12. Using the pilot holes as a guide, fasten two Hooks (12) to the upper corners of the Barrister Door (L)

with four 12 mm Screws (6) as shown.

13. Attach one Knob (8) to the front side of the Barrister Door (L) with one Knob Bolt (10).

NOTE: The Barrister Door is shipped with the Speaker Grill (N). You can keep the door as it is or

interchange with Glass Door Insert (M) or Wood Door Insert (O) depending on your configuration.

14. To change the configuration, loosen the screws on the inside of the Barrister Door (L) and rotate the

clips to remove the panel. Replace with the desired panel, then rotate clips to secure the panel within the

door frame and tighten screws.

Assembly Instructions

15. Hook the Barrister Door (L) onto the pre-attached plastic slides on the Upper Side Frames (C and D).

16. Glue six Wood Dowels (5) into the top holes on the Upper Side Frames (C and D).

17. Position the Top Panel (A) onto the inserted Wood Dowels (5) and fasten in place with four 1-1/4”

Bolts (2) and four Washers (3 and 4).

C/D

Assembly Instructions

18. Now, go back and securely tighten all the Cam Locks and the Screws. Make sure that all the parts are

tight and there are no gaps between the parts. This will help keep the unit square.

19. Pick up the Back Panel (H) and align the pre-drilled holes against the upper long edge with the pilot

holes on the back stretcher of the Top Panel (A). Attach the Back Panel (H) in place with the provided

Washer Head Screws (7).

20. Lift the fireplace insert carefully into the back of the assembled mantel and center it in the opening. DO

NOT drag the insert across the Base (J) as it may scratch the unit.

Tabla de contenidos

Otros manuales de Chimenea de interior de Whalen

Whalen

Whalen Bookcase Media Fireplace Manual de usuario

Whalen

Whalen Shelby WSF72SY26C Manual de usuario

Whalen

Whalen WMFP60EC-7 Manual de usuario

Whalen

Whalen GRANTVILLE WS03061433 Manual de usuario

Whalen

Whalen SF122-23A Manual de usuario

Whalen

Whalen SUMCMF-23 Manual de usuario

Whalen

Whalen Menards Barston WS03060726 Manual de usuario

Whalen

Whalen WSF36SH23C Manual de usuario

Whalen

Whalen Barston Laminated Fireplace Manual

Whalen

Whalen MNFP54LW23 Manual del propietario

Whalen

Whalen WSF54OW30W Manual de usuario

Whalen

Whalen WS3060926FP Manual de usuario

Whalen

Whalen SUMCMF-23 Manual de usuario

Whalen

Whalen Linwood MNFP48LW23IO Manual de usuario

Whalen

Whalen WSLWFP54-6 Manual de usuario

Whalen

Whalen Millstead WSF60MS26GAO Manual de usuario

Whalen

Whalen Middleton WSF72WV26-DB Manual de usuario

Whalen

Whalen Ashton MNFP54AS-18 Manual de usuario

Whalen

Whalen Evanston MNFP48ES23GA Manual de usuario

Whalen

Whalen WH100-23C2D-RD Manual de usuario

Whalen

Whalen FP32EC23I-1BC Manual de usuario

Whalen

Whalen WMFP60FH-14 Manual de usuario

Whalen

Whalen MNFP60PV26WT Manual de usuario

Whalen

Whalen WSF54AL30R-AG Manual de usuario

Manuales populares de Chimenea de interior de otras marcas

Brigantia

Brigantia 35-DVRS31N-2 Manual del propietario

Nordpeis

Nordpeis Bergen Manual de usuario

Superior

Superior BCT2536TMN Manual de usuario

Quadra-Fire

Quadra-Fire 5100I-GD-B Manual de usuario

Renaissance

Renaissance RUMFORD 1000 Manual de usuario

Lacunza

Lacunza IV-800 Manual de usuario

Baxi

Baxi 940 Instrucciones de uso

Dru

Dru Maestro 60/2 Tall RCH Manual de usuario

Diamond Fireglass

Diamond Fireglass SS-O22 Manual de usuario

HearthStone

HearthStone Windsor Bay 8830 Manual de programación

Napoleon

Napoleon ASCENT B42 Manual de usuario

Enviro

Enviro E33GI Manual de usuario

Smeg

Smeg L30 FABE Instrucciones de montaje

KEDDY

KEDDY K700 Manual de usuario

Godin

Godin 3451 Manual de usuario

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Manual de usuario

Austro Flamm

Austro Flamm Heidi Back 2.0 945048 Manual de usuario

Desa

Desa CCFPDFT Manual de operación