Webasto Thermo Top E Manual de usuario

Water Heater

Installation instructions

Ident. No.: 1314869C_EN Fee Euro 10.00 © Webasto AG

Hyundai i20

Petrol

from Model Year 2009

Left-hand drive vehicle

Feel the drive

WARNING!

Hazard warning:

Incorrect installation or repair of Webasto heating systems may cause a fire or result in the

emission of carbon monoxide, which can be fatal. Serious or fatal injuries can be caused as

a result.

Specialist company training, technical documentation, specialised tools and equipment are

required to install and repair Webasto heating and cooling systems.

Only original Webasto parts must be used. For this, also see the catalog of air and water heat-

er accessories from Webasto.

NEVER attempt to install or repair Webasto heating or cooling systems if you have not

successfully completed the company training and thereby acquired the required tech-

nical skills, or if you do not have access to the required technical documentation, tools

and equipment needed to carry out correct installation and repairs.

ALWAYS follow all Webasto installation and repair instructions and observe all warnings.

Webasto does not accept any liability for defects and damage that are attributable to installa-

tion by untrained staff.

Thermo Top E Parking heater

00 0003

Thermo Top C Parking heater

00 0002

Thermo Top P Parking heater

00 0104

Hyundai i20

1314869C_EN 2

Table of Contents

Validity

Vehicle and engine types, equipment variants and national specifications not listed in these installation

instructionshavenotbeentested.However, installationaccordingtotheseinstallationinstructions may

be possible.

The installation location of a digital timer and summer/winter switch should be confirmed with the end

customer before installation.

Manufacturer Model Type EG-BE No./ABE

Hyundai i20 P/C e11 * 2001/116 * 0333 * ...

Engine type Engine model Output in kW Displacement in cm³

G4LA Petrol 57 1248

G4FA Petrol 74 1396

Validity 2

Heater/Installation Kit 3

Foreword 3

General Instructions 3

Special Tools 3

Explanatory Notes on Document 4

Preliminary Work 5

Heater installation location 5

Preparing electrical system 6

Electrical system 7

Fan controller for manual air conditioning 8

Automatic air-conditioning fan controller 9

Remote option (Telestart) 11

Preparing installation location 12

Installing heater 15

Coolant circuit 16

Fuel 22

Exhaust gas 25

Combustion air 26

Final Work 27

Template for Fuel Standpipe 29

Operating Instructions for End Customer 30

Hyundai i20

1314869C_EN 3

Heater/Installation Kit

To be ordered additionally for vehicles with automatic air-conditioning:

Heater recommended for the respective vehicle class:

The selection of the heater is based on the passenger compartment size of the vehicle and the level of

comfort required by the customer!

Foreword

Theseinstallationinstructionsapplyto Hyundai i20Petrolvehicles- for validity, seepage2 - frommodel

year 2009 and later, assuming technical modifications to the vehicle do not affect installation, any lia-

bility claims excluded. Depending on the vehicle version and equipment, modifications may be neces-

sary during installation with respect to these installation instructions.

However, the stipulations in the"installationinstructions" and "operatingandmaintenanceinstructions"

for the Thermo Top C/P/E must always be observed.

The corresponding rules of technology and any information from the vehicle manufacturer should be

observed during the installation work.

General Instructions

Installation should be carried out according to the general, standard rules of technology. Unless spec-

ified otherwise, fasten hoses, lines and wiring harnesses to original vehicle lines and wiring harnesses

using cable ties.

Sharp edges should be fitted with edge protectors (split-open plastic hose).

Spray unfinished body areas, e.g. drilled holes, with anti-corrosion wax (Tectyl 100K, Order No. 111329).

Special Tools

- Torque wrench for 2.0 - 10 Nm

- Hose clamping pliers

- Metric thread-setter kit

Quantity Description Order No.:

1 Retail accessories Thermo Top E / C / P See price list

1 Installation kit for Hyundai i20 Petrol 1314868A

1 Heater control See price list

Quantity Description Order No.:

1 Additional Kit for Automatic Air Conditioning on Hyundai i20 1314875A

Vehicle Heater

Compact car Thermo Top E

Mid-size car, station wagon Thermo Top C

Full-size car, van, offroader Thermo Top P

Hyundai i20

1314869C_EN 4

Special features are highlighted using the following symbols:

The arrow in the vehicle icon indicates the position on

the vehicle and the viewing angle.

Specific risk of injury or fatal accidents.

Specific risk of damage to components.

Specific risk of fire or explosion.

Referencetogeneralinstallationinstructions of Webas-

tocomponentsortothemanufacturer'svehicle-specific

documents.

Reference to a special technical feature.

All dimensions are in mm!

Tightening torque of hose clamps = 2.0 + 0.5 Nm!

Tightening torque of Ejot screws, Ejot studs = 10 Nm!

Mechanical system

Electrical system

Coolant circuit

Fuel

Exhaust gas

Combustion air

Software

Explanatory Notes on Document

To provide you with a quick overview of the individual working steps, you will find an identification mark

on the outside top right corner of the page in question.

Hyundai i20

1314869C_EN 5

Preliminary Work

WARNING!

- Open the fuel tank cap, ventilate the tank.

- Close the tank cap again.

- Disconnect the battery "earth" or "ground" connection.

-Depressurizethe cooling system!

- Copy the factory number from the original type label to the duplicate type label.

- Remove years that do not apply from the duplicate label.

- Attach the duplicate label (type label) in the appropriate place.

- Remove the battery.

- Remove the air filter together with the intake hose.

- Disconnect the fuse and relay box in the engine compartment and lay aside.

- Detach the wheel well trim on the left

- Remove the bumper

- Open the fuel sender service lid.

- Remove fuel-tank sending unit in accordance with manufacturer's instructions.

- Remove the A/C control panel (only with automatic air-conditioning).

- Remove the instrument panel trim on the driver's side (only with Telestart).

Remove page 30 "Operating Instructions for End Customer" and add to the vehicle operating instruc-

tions.

Heater installation location

1Heater

Installa-

tion loca-

tion

Hyundai i20

1314869C_EN 6

Preparing electrical system

Bending

perforated

bracket

Only with automatic air-conditioning

Cutting

wires to

length

Install wire section 2in protective sleeving

provided.

Premount-

ing F4

90°

250

2sw

O,75²

85 30

87a87

1 2

Hyundai i20

1314869C_EN 7

Electrical system

Fuse holder, relay K3

1M5x16 bolt, washers, retaining plate for fuse

holder, K3 relay, flanged nut

2Perforated bracket

3M6x20 bolt, spring lockwasher, existing

threaded hole

Digital timer and summer/winter switch op-

tion

1Digital timer

2Summer/winter switch, drilled hole 12 mm dia.

Wiring har-

ness in-

stallation

diagram

Earth connection

1Original vehicle earth support point

2Brown (br) earth wire

Wiring harness pass through

1Protective rubber plug

2Wiring harness of digital timer, wiring harness

of fan controller (only with automatic A/C)

2 31

Donot install the metering pump

cableharnessuntillatertogether

with fuel pipe along the original

vehicle fuel lines on the under-

body

1 2

Hyundai i20

1314869C_EN 8

Fan controller for manual air conditioning

Wiring dia-

gram

Webasto components Vehicle components Colours and symbols

Legend

HG Heater TT-C/E GM Fan motor rt red

X1 6-pin heater connector GRs Fan relay pk pink

F3 Replace 25 A with 5 A

fuse. WG Resistor group sw black

GS Fan switch

K3 Fan relay F2 IGN 15A fuse

F Blower 40 A fan fuse

XCutting point

Wiring colours may vary.

Connection to fuse and relay box 5in engine

compartment. Replace 25 A fuse F3 with 5 A

fuse.Produceconnectionsasshowninwiring

diagram.

1Pink (pk) wire of fan relay, Pin 4

2Black (sw) wire from K3/30

3Red (rt) wire from K3/87a

4Pink (pk) wire of fuse F2

Connect-

ing fan-mo-

tor

Webasto

Hyundai

85 30

87a87

X1 4

5GRs

Blower

-GM

3GS

4 1 5 6

3124

4²

0,5²

Hyundai i20

1314869C_EN 9

Automatic air-conditioning fan controller

Wiring dia-

gram

Webasto components Vehicle components Colours and symbols

Legend

HG Heater TT-C/E GM Fan motor rt red

X1 6-pin heater connector GRs Fan relay pk pink

F4 5A fuse GRr Fan controller sw black

F3 Replace 25 A fuse with

15 A fuse KB A/C control panel or orange

M04-A 26-pin connector KB

K3 Fan relay F2 IGN 15A fuse

F Blower 40 A fan fuse Insulate wire ends and

tie back

XCutting point

Wiring colours may vary.

Webasto

Hyundai

85 30

87a87

X1 4

5GRs

Blower

-GM

4²

0,5²

0,75²

M04-A 14 15 16 17 25

GRr

M16 1 2 4 3

1 2

0,5² or

0,5²

Hyundai i20

1314869C_EN 10

Connection to fuse and relay box 4in engine

compartment.Replace fuse F3 25 Awith 15A

fuse. Insulate pink (pk) wire 1from fuse F2

IGN and tie back.

Produce connections as shown in wiring dia-

gram.

2Additional black (sw) wire of K3/30

3Pink (pk) wire of fan relay, Pin 4

Connect-

ing fan re-

lay

Connection on 26-pin connector M04-A 4of

A/C control panel.

Produce connections as shown in wiring dia-

gram.

1Red (rt) wire from K3/87a

2Black (sw) wire from K3/30

3Orange (or) wire [2x] of connector M04-A,

Pin 14 and 15

5Orange (or) wire [2x] of fuse F2 IGN

Connect-

ing A/C

control

panel

Otros manuales para Thermo Top E

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Calentador de agua de Webasto

Webasto

Webasto thermo top evo Manual del operador

Webasto

Webasto Ford Focus Manual de usuario

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto DBW 46 Manual de usuario

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto Thermo Top C Manual de usuario

Webasto

Webasto Thermo 90 Manual de usuario

Webasto

Webasto Thermo Top E - B Manual de usuario

Webasto

Webasto thermo top evo Manual del operador

Webasto

Webasto thermo top evo Manual del operador

Webasto

Webasto Thermo Top C Manual de usuario

Webasto

Webasto thermo top evo Manual del operador

Webasto

Webasto Dodge Journey (JC) Manual de usuario

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto Thermo Pro 50 Eco Manual de usuario

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto Thermo Top Evo - B Manual de usuario

Webasto

Webasto Thermo Top E Manual del operador

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto Mazda 6 Manual de usuario

Webasto

Webasto Suzuki Grand Vitara Manual de usuario

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto D5W Z Manual de usuario

Manuales populares de Calentador de agua de otras marcas

Kenmore

Kenmore 153.582400 Manual de usuario

Applimo

Applimo Edel AIR Manual de usuario

STIEBEL ELTRON

STIEBEL ELTRON Eltronom SHU 5 S Manual de usuario

clage

clage E-Mini Series Manual de usuario

Toyotomi

Toyotomi Oil Miser OM-180 Manual de usuario

Bradford White

Bradford White EF Series Manual de usuario

Eccotemp

Eccotemp 40-H Manual de usuario

Dimplex

Dimplex ECSd125-580 Guía

Dux

Dux 32FCR6N Manual de usuario

Toyotomi

Toyotomi Oil Miser OM-148 (Type D) Guía de solución de problemas

Noritz

Noritz N-132M Manual de instrucciones

TESY

TESY GCV7/4S 10047 Hoja de especificaciones

A.O. Smith

A.O. Smith Gphe 50 Manual de usuario

Koryo

Koryo KWHZF15Y Manual de usuario

Pentair

Pentair PSC-14-4-02 Manual de usuario

GE 40M06AAG Instrucciones de montaje

Thermor

Thermor AEROMAX SPLIT 2 Manual de usuario

American Hometec

American Hometec AHQ-B03X Manual de usuario