Webasto Thermo Top E Manual de usuario

WARNING!

Hazard warning:

Incorrect installation or repair of Webasto heating systems may cause a fire or result

in the emission of carbon monoxide, which can be fatal. Serious or fatal injuries can

be caused as a result.

Specialist company training, technical documentation, specialized tools and equip-

ment are required to install and repair Webasto heating and cooling systems.

NEVER attempt to install or repair Webasto heating or cooling systems if you have not

successfully completed the company training and thereby acquired the required tech-

nical skills, or if you do not have access tothe required technical documentation, tools

and equipment needed to carry out correct installation and repairs.

ALWAYS follow all Webasto installation and repair instructions and observe all warn-

ings.

Webasto does not accept any liability for defects and damage that are attributable to

installation by untrained staff.

Feel the drive

SUBARU Impreza 1.5R; 2.0R

Gasoline

Impreza 2.0R from Model Year 2006

Impreza 1.5R from Model Year 2007

For left-hand drive vehicles only

Ident. No.: 1311020B Fee Euro 10.00 © Webasto AG

Water Heater Unit

Thermo Top E Additional Heater

Thermo Top C Additional Heater

Installation Instructions

00 0003

00 0002

SUBARU Impreza 1.5R; 2.0R

Validity

Vehicle and engine types, equipment variants and national specifications not listed in these installation

instructionshave notbeen tested.However, installationaccordingto theseinstallationinstructions may

be possible.

The installation location of a digital timer and summer/winter switch should be confirmed with the end

customer before installation.

Manufacturer Model Type EG-BE No./ABE

SUBARU Impreza GD/GG e1*98/14*0145...

SUBARU Impreza GD/GGS e1*98/14*0163...

Engine type Engine model Output in kW Displacement in cm³

EL15 Gasoline 77 1498

EJ20 Gasoline 118 1994

Validity 2

Heater Unit/Installation Kit 3

Foreword 3

General Instructions 3

Special Tools 3

Explanatory Notes on Document 4

Preliminary Work 5

Heater unit installation location 5

Preparing electrical system 6

Electrical Connections 7

Automatic air-conditioning fan controller 8

Remote option (Telestart) 10

Remote option (Thermo Call) 11

Preparing heater unit 12

Preparing installation location 13

Preassembling heater unit 14

Installing heater unit 15

Coolant connection 17

Combustion air 21

Fuel Connection 22

Exhaust system 26

Final Work 28

Operating Instructions for End Customer 29

Template with Hole Pattern for Spring Strut Dome 30

Template for Bracket 31

Template for Perforated bracket A 32

Template for Perforated bracket B 32

Template for Fuel sender 33

Template for Fuel Standpipe 34

Table of Contents

SUBARU Impreza 1.5R; 2.0R

Heater Unit/Installation Kit

Heater unit recommended for the respective vehicle class:

The selection of the heater unit is based on the passenger compartment size of the vehicle and the

level of comfort required by the customer!

Foreword

These installation instructions apply to SUBARU Impreza 1.5R; 2.0R vehicles with a Gasoline engine

- for validity, see page 2 - from model year 2006 and later, assuming technical modifications to the ve-

hicle do not affect installation, any liability claims excluded. Depending on the vehicle version and

equipment, modifications may be necessary during installation with respect to these installation in-

structions.

However,the stipulations inthe "installationinstructions" and"operatingand maintenanceinstructions"

for the Thermo Top C/P/E must always be observed.

The corresponding rules of technology and any information from the vehicle manufacturer should be

observed during the installation work.

General Instructions

Installation should be carried out according to the general, standard rules of technology. Unless spec-

ified otherwise, fasten hoses, lines and wiring harnesses to original vehicle lines and wiring harnesses

using cable ties.

Sharp edges should be fitted with edge protectors (split open plastic hose).

Spray unfinished body areas, e.g. drilled holes, with anti-corrosion wax (Tectyl 100K, Order No.

111329).

Special Tools

- Torque wrench for 2.0 - 10 Nm

- Hose clamping pliers

- Metric Thread-Setter Kit

Quantity Description Order No.:

1 Retail accessories with desired heater control See price list

1 Installation kit for SUBARU Impreza 1.5R; 2.0R 1310983A

Vehicle Heater unit

Compact car Thermo Top E

Mid-size car, station wagon Thermo Top C

Special features are highlighted using the following symbols:

Mechanical system

Electrical system

Coolant connection

Fuel connection

Exhaust system

Combustion air

The arrow in the vehicle icon indicates the position on

the vehicle and the viewing angle.

SUBARU Impreza 1.5R; 2.0R

Specific risk of injury or fatal accidents.

Specific risk of damage to components.

Specific risk of fire or explosion.

Referenceto generalinstallationinstructions of Webas-

tocomponentsortothemanufacturer'svehicle-specific

documents.

Reference to a special technical feature.

Explanatory Notes on Document

To provide you with a quick overview of the individual working steps, you will find an identification mark

on the outside top right corner of the page in question.

SUBARU Impreza 1.5R; 2.0R

Heater unit installation location

1Heater unit

Installa-

tion loca-

tion

Preliminary Work

WARNING!

- Disconnect the battery "earth" or "ground" connection.

- Depressurize the cooling system.

- Copy the factory number from the original type label to the duplicate type label.

- Remove years that do not apply from the duplicate label.

- Attach the duplicate label (type label) in the appropriate place.

- Copy the vehicle data from the type label on the right-hand spring strut dome to the EC homolo-

gation for the heater unit.

- Remove the air filter together with the intake hose.

- Remove the coolant reservoir cap.

- Remove the A/C control panel.

- Remove the lower instrument panel trim on the driver's side.

- Remove the lower left-hand A-pillar trim and fold back the floor trim above the pedals.

- Remove the left-hand front and rear door sill cover.

- Remove the rear seat cushion.

- Remove the lower luggage compartment cover and take out the Styrofoam molded parts.

- Open the fuel tank cap, ventilate the tank.

- Close the tank cap again.

- Open the right-hand fuel sender service lid

Please remove page 29 of the “Operating instructions for the end customer” and add it to the vehicle

operating instructions.

SUBARU Impreza 1.5R; 2.0R

Preparing electrical system

Installwiresection2intheprotectivesleeving

provided.

Cutting

wires to

length

Make connections as shown in the wiringdia-

gram with the tab receptacles provided.

Preparing

fuse F4

sw 1²

1 2

F4 15A

1sw

85 30

87a87

rt/

br rt

swbr

SUBARU Impreza 1.5R; 2.0R

Electrical Connections

Wiring harness pass through

1Protective rubber sleeve

Digital timer

1Digital timer (match installation location)

Wiring har-

ness in-

stallation

diagram

Fuse holder, K3 relay

See wiring diagram on page 9 !

1Fuse holder retaining plate, self-tapping screw

2Fan relay K3, self-tapping screw

Summer/winter switch option

(match installation location)

1Summer/winter switch, drilled hole 12 mm dia.

br bl

sw rt

Do not install the

metering-pump wir-

ing harness until lat-

er together with the

fuel line along the

original vehicle fuel

lines in the passen-

ger compartment

SUBARU Impreza 1.5R; 2.0R

Automatic air-conditioning fan

controller

Connection to the 2-pin connector 3from the

fan motor.

Make connections as shown in the wiring dia-

gram with the wire connectors provided.

1Red (rt) wire from K3/87a

2Black (sw) wire from K3/30

32-pin connector of B87 fan motor

Connect-

ing fan mo-

tor

Connection to the 16-pin connector 1from

the A/C control panel.

Make connections as shown in the wiring dia-

gram with the tab connectors provided.

116-pin connector of B282, Pin 8

2Blocking diode

3Black (sw) wire from fuse F4

4Green/yellow (gn/ge) wire to connector

5Green/yellow (gn/ge) wire from fuse No.

17(IG) 15 A

Note:

Wire color green/yellow (gn/ge) is shown as

green/orange (gn/or) in workshop manual!

Connect-

ing air-con-

ditioning

control ele-

ment

SUBARU Impreza 1.5R; 2.0R

Automatic

air-condi-

tioning cir-

cuit

diagram

Webasto components Components of SUBARU

Impreza 1.5R; 2.0R Colors and symbols

Legend

HG Heater unit TT-C/E GM Fan motor rt red

X1 6-pin connector GV Fan amplifier ws white

F4 Fuse, 15 A GR Fan relay ge yellow

F3 Fuse, 25 A KB Air-conditioning control

element sw black

K3 Fan relay FB1 Fuse, 15 A br brown

D1 Diode 1 FB2 Fuse, 15 A gn green

FB17 Fuse, 15 A (IG)

XCutting point

Wiring colors may vary.

gn/

rt/ws

Webasto

SUBARU

rt sw/rt

85 30

87a87

4X1

-GM

sw/rt

Webasto

2 4

B282 16 8

11 B283

F4 sw

FB2

gn/ge

FB17

FB1

SUBARU Impreza 1.5R; 2.0R

Remote option (Telestart)

1Receiver, Dual Lock, self-adhesive

Installing

receiver

1Antenna

Installing

antenna

Temperature sensor for HTM100 only

1Temperature sensor, cable tie

Installing

tempera-

ture sensor

Otros manuales para Thermo Top E

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Calentador de agua de Webasto

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto Thermo Top Z Manual de usuario

Webasto

Webasto Thermo Pro 90 HDD Manual de usuario

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto Mazda 6 Manual de usuario

Webasto

Webasto DBW 46 Manual de usuario

Webasto

Webasto Thermo Top Evo - B Manual de usuario

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto Suzuki Grand Vitara Manual de usuario

Webasto

Webasto thermo top evo Manual del operador

Webasto

Webasto Thermo Top E Manual del operador

Webasto

Webasto Thermo Pro 90 Manual de instrucciones

Webasto

Webasto BBW 46 Manual de usuario

Webasto

Webasto thermo top evo Manual de usuario

Webasto

Webasto Thermo Top V Manual de usuario

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto Thermo Top E Manual del operador

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto thermo top evo Manual del operador

Webasto

Webasto Thermo 230 Manual de usuario

Webasto

Webasto Thermo Top C Manual de usuario

Webasto

Webasto Thermo Top P Manual de usuario

Manuales populares de Calentador de agua de otras marcas

Kenmore

Kenmore 153.582400 Manual de usuario

Applimo

Applimo Edel AIR Manual de usuario

STIEBEL ELTRON

STIEBEL ELTRON Eltronom SHU 5 S Manual de usuario

clage

clage E-Mini Series Manual de usuario

Toyotomi

Toyotomi Oil Miser OM-180 Manual de usuario

Bradford White

Bradford White EF Series Manual de usuario

Eccotemp

Eccotemp 40-H Manual de usuario

Dimplex

Dimplex ECSd125-580 Guía

Dux

Dux 32FCR6N Manual de usuario

Toyotomi

Toyotomi Oil Miser OM-148 (Type D) Guía de solución de problemas

Noritz

Noritz N-132M Manual de instrucciones

TESY

TESY GCV7/4S 10047 Hoja de especificaciones

A.O. Smith

A.O. Smith Gphe 50 Manual de usuario

Koryo

Koryo KWHZF15Y Manual de usuario

Pentair

Pentair PSC-14-4-02 Manual de usuario

GE 40M06AAG Instrucciones de montaje

Thermor

Thermor AEROMAX SPLIT 2 Manual de usuario

American Hometec

American Hometec AHQ-B03X Manual de usuario