Webasto Thermo Top E Manual del operador
Water Heater
Installation documentation
Ident. No.: 1314421C_EN Fee Euro 10.00 © Webasto AG
VW Golf VI, Golf Plus, Golf Variant
1.2 and 1.4 TSI
from Model Year 2008
Left-hand drive vehicle
Feel the drive
WARNING!
Hazard warning:
Incorrect installation or repair of Webasto heating systems may cause a fire or result in the
emission of carbon monoxide, which can be fatal. Serious or fatal injuries can be caused as
a result.
Specialist company training, technical documentation, specialised tools and equipment are
required to install and repair Webasto heating and cooling systems.
Only original Webasto parts must be used. For this, also see the catalog of air and water heat-
er accessories from Webasto.
NEVER attempt to install or repair Webasto heating or cooling systems if you have not
successfully completed the company training and thereby acquired the required tech-
nical skills, or if you do not have access to the required technical documentation, tools
and equipment needed to carry out correct installation and repairs.
ALWAYS follow all Webasto installation and repair instructions and observe all warnings.
Webasto does not accept any liability for defects and damage that are attributable to installa-
tion by untrained staff.
Thermo Top E Parking Heater
e1
00 0003
Thermo Top C Parking Heater
e1
00 0002
Thermo Top P Parking Heater
e1
00 0104
VW Golf VI, Golf Plus, Golf Variant
1314421C_EN 2
Table of Contents
Validity
Vehicle and engine types, equipment variants and national specifications not listed in this installation
documentationhavenot beentested. However,installationaccordingtothis installationdocumentation
may be possible.
The installation location of a digital timer and summer/winter switch should be confirmed with the end
customer before installation.
Manufacturer Model Type EG-BE No./ABE
VW Golf VI 1K e1 * 2001/116 * 0242 * ...
VW Golf Plus 1KP e1 * 2001/116 * 0304 * ...
VW Golf Variant 1KM e1 * 2001 / 116 * 0328 * ...
Engine type Engine model Output in kW Displacement in cm³
CBZA Petrol/TSI 63 1197
CBZB Petrol/TSI 77 1197
CAXA Petrol/TSI 90 1390
CAVD Petrol/TSI 118 1390
Validity 2
Heater/Installation Kit 3
Foreword 3
General Instructions 3
Special Tools 3
Explanatory Notes on Document 4
Preliminary Work 5
Heater installation location 5
Electrical system 6
Fuse holder and K3 relay 7
Climatic fan control 8
Climatronic fan control 10
Digital timer, summer/winter switch option 13
Remote option (Telestart) 13
Premounting heater 15
Preparing exhaust system 16
Installing heater 17
Fuel 18
Coolant circuit 21
1.2 Manual transmission 22
1.4 90kW manual transmission 24
1.4 90kW DSG 27
1.4 118 kW manual transmission 31
All vehicles 35
Exhaust gas 36
Final Work 37
Reduce sensitivity of passenger compartment
monitoring 37
Operating Instructions for End Customer 38
VW Golf VI, Golf Plus, Golf Variant
1314421C_EN 3
Heater/Installation Kit
Also required with Climatronic:
Heater recommended for the respective vehicle class:
The selection of the heater is based on the passenger compartment size of the vehicle and the level of
comfort required by the customer.
Foreword
This installation documentation applies to the vehicles VW Golf VI, Golf Plus, Golf Variant 1.2 and 1.4
TSI - for validity, see page 2 - from model year 2008 and later, assuming technical modifications to the
vehicle do not affect installation, any liability claims excluded. Depending on the vehicle version and
equipment, modifications may be necessary during installation with respect to this installation docu-
mentation.
However, the stipulations in the "installation documentation", the "operating instructions" and the "in-
stallation instructions" for the Thermo Top C/P/E must always be observed.
The corresponding rules of technology and any information from the vehicle manufacturer should be
observed during the installation work.
General Instructions
Installation should be carried out according to the general, standard rules of technology. Unless spec-
ified otherwise, fasten hoses, lines and wiring harnesses to original vehicle lines and wiring harnesses
using cable ties.
Sharp edges should be fitted with rub protection (split-open plastic hose).
Spray unfinished body areas, e.g. drilled holes, with anti-corrosion wax (Tectyl 100K, Order No.
111329).
When installing an IPCU, check or adjust the corresponding settings before installation.
Special Tools
- Torque wrench for 2.0 - 10 Nm
- Hose clamping pliers
- Metric thread-setter kit
Quantity Description Order No.:
1 Retail accessories Thermo Top E / C / P See price list
1 Installation kit for VW Golf VI, Golf Plus, Golf Variant 1.2 and
1.4 TSI 1314420B
1 Heater control See Price list
Quantity Description Order No.:
1 IPCU Kit for Climatronic 9013645A
Vehicle Heater
Compact car Thermo Top E
Mid-size car, station wagon Thermo Top C
Full-size car, van, offroader Thermo Top P
VW Golf VI, Golf Plus, Golf Variant
1314421C_EN 4
Special features are highlighted using the following symbols:
The arrow in the vehicle icon indicates the position on
the vehicle and the viewing angle.
Specific risk of injury or fatal accidents.
Specific risk of damage to components.
Specific risk of fire or explosion.
Referenceto generalinstallationinstructions ofWebas-
tocomponentsortothemanufacturer'svehicle-specific
documents.
Reference to a special technical feature.
All dimensions are in mm!
Tightening torque of hose clamps = 2.0 + 0.5 Nm!
Tightening torque of Ejot screws, Ejot studs = 10 Nm!
Mechanical system
Electrical system
Coolant circuit
Fuel
Exhaust gas
Combustion air
Explanatory Notes on Document
You will find an identification mark on the outside top right corner of the page in question to provide you
with a quick overview of the individual working steps.
VW Golf VI, Golf Plus, Golf Variant
1314421C_EN 5
Preliminary Work
WARNING!
- Open the fuel tank cap, ventilate the tank.
- Close the fuel tank cap again.
- Depressurise the cooling system.
- Copy the factory number from the original type label to the duplicate type label.
- Remove years that do not apply from the duplicate label.
- Attach the duplicate label (type label) in the appropriate place.
- Disconnect the battery "earth" or "ground" connection.
- Completely remove the battery with the battery carrier.
- Remove the engine cover.
- Detach the coolant reservoir cap.
- Remove the left front wheel.
- Remove the front section of the left front wheel well trim.
- Remove the left-hand front fog light or, on vehicles without front fog lights, the left-hand cover.
- Remove the underride protection
- Remove the right-hand underbody trim.
- Remove the rear bench seat.
- Open the right-hand tank-fitting service lid.
- Remove the footwell trim on the driver's side
- Remove the lower instrument panel trim on the driver's side
- Only vehicles with Climatronic: Remove the footwell trim on the front passenger side
Remove page 38 "Operating Instructions for End Customer" and add to the vehicle operating instruc-
tions.
Heater installation location
1Heater
Installa-
tion loca-
tion
1
1
VW Golf VI, Golf Plus, Golf Variant
1314421C_EN 6
Electrical system
Wiring harness routing
Route excess lengths from wiring harness 1in
cable duct 2below battery and secure with cable
ties.
Wiring harness pass through
1Original vehicle wiring harness pass through
Wiring har-
ness rout-
ing
diagram
Fuse holder, K3 relay
Description of installation for K3 relay 1and fuse
carrier 2on Page 7
Wiring harness pass through
1Original vehicle wiring harness pass through
2
1
22
3
1
Do not install the metering pump
wiring harness until later togeth-
er with fuel pipe along the origi-
nal vehicle fuel line on the
underbody
4
2
1
5
1
VW Golf VI, Golf Plus, Golf Variant
1314421C_EN 7
Fuse holder and K3 relay
Countersink holes 3from behind for M5 coun-
tersunk head screws.
1Cover of fuse/relay carrier in engine com-
partment
2Cut away bar in shaded area
35 mm dia. hole [2x]
Holes in
cover
1M5x12 countersunk head screw [2x]
Installing
fuseholder
and relay
K3
On vehicles with Climatronic, replace 25 A
fuse F3 7with 3 A fuse provided.
1M5 flanged nut
2Large diameter washer (between cover
and retaining plate)
3Retaining plate
4M5 flanged nut
5Relay K3
6Fuse holder
Installing
fuseholder
and relay
K3
Route brown (br)earthwireto original vehicle
earth support point below headlight and con-
nect.
1Fuse/relay carrier
2Original main vehicle fuse
3Red (rt) positive wire Connect-
ing posi-
tive and
earth wire
1
6
3
2
3
20
40
9
9
7
11
6
2
3
8
74
5
1
21
3
9
VW Golf VI, Golf Plus, Golf Variant
1314421C_EN 8
Climatic fan control
Climatic
wiring dia-
gram
Webasto components Vehicle components Colours and symbols
Legend
HG Heater TT-C/P/E GM Fan motor rt red
X1 6-pin heater connector F1*Fuse 40A (depending on respec-
tive fuse assignment)
Golf VI = SC22 or SC40
Golf Plus = SC33
ge yellow
F3 25 A fuse sw black
K3 Fan relay ** Wire depends on
the respective vehi-
cle equipment
Golf VI = red/yellow
(rt/ge)
Golf Plus = red yel-
low (rt/ge) or
black/yellow (sw/ge)
J301 Control unit of air conditioning
T5 5-pin connector J301
N24 Resistor group
T4f 4-pin connector N24
T10k Connector
XCutting point
Wiring colours may vary.
sw
Webasto
31
30
15
VW
rt
HG
4
X1 F3 F1
86
85 30
87a87
K3
4²
4²
3241 T4f
N24
J301
5T5
3214 T5
1
2V2
M
br
rt/sw
rt/
sw
ge rt/
ge sw/
ws
rt/
sw
4²
rt/ws
rt/ge 4² T10k
2
**
*SC22/SC40
(SC33)
(sw/ge) 4²
VW Golf VI, Golf Plus, Golf Variant
1314421C_EN 9
Golf VI and Variant
Connection on fuse carrier 2(instrument pan-
el at upper left). Remove red/yellow (rt/ge) 4²
wire 1on fuse output SC 22 or SC40 (de-
pending on respective vehicle equipment). Connec-
tion to fuse
carrier
Red (rt) wire 4from K3/87a with crimped-on
standard power timer interlocked in fuse out-
put SC 22 or SC40.
Produce connections as shown in wiring dia-
gram.
1Red/yellow (rt/ge) wire of fuse SC22 or
SC40
2AMP housing
3Black (sw) wire to K3/30
Connect-
ing wires
Golf Plus
Connection on fuse carrier 1(instrument pan-
elatbottomleft).Removered/yellow(rt/ge)4²
wire 2on fuse output SC33 (depending on re-
spective vehicle equipment). Connec-
tion to fuse
carrier
Red (rt) wire 1from K3/87a with crimped-on
standard power timer interlocked in fuse out-
put SC33.
Produce connections as shown in wiring dia-
gram.
2AMP connector
3Red/yellow (rt/ge) wire from fuse S33
4Black (sw) wire to K3/30
Connect-
ing wires
10
2
1
11
1
2
4
3
1
12
2
13
1
3
2
4
VW Golf VI, Golf Plus, Golf Variant
1314421C_EN 10
Climatronic fan control
Climatron-
ic wiring
diagram
Webasto components Vehicle components Colours and symbols
Legend
HG Heater TT-C/P/E F1*Fuse 40A (depending on re-
spective fuse assignment) of
SC22 or SC56
rt red
X1 6-pinheater connector ws white
K3 Fan relay sw black
F3 Replace 25 A fuse
with 3 A fuse T10k Plug connections br brown
J255 Climatronic control unit gn green
IPCU Pulse width modulator T16d 16-pin connector J255 ge yellow
J126 Fan controller
IPCU adjustment values: V2 Fan motor bl blue
Duty cycle: 30% T6t 6-pin connector J126 Insulate wire ends and
tie back
Frequency: 400Hz
Voltage: 8V XCutting point
Function: High side Wiring colours may vary.
Webasto
31
30
15
VW
F3
86
85 30
87a87
K3
HG
X1 4
!
rt
4²
J126
M
T6t
3412
V2
br
J255
T16d
1516
sw/
ws bl/
ws
0,35² 0,35²
86 85
A
E
IPCU
sw
4²
gn/ws
br
2T10k
F1
sw/
ws
0,35²
rt
sw/ws
rt/ws
4²
rt/
ge
4²
rt
0,75²
0,75²
SC22/
SC56
*
Otros manuales para Thermo Top E
42
Este manual sirve para los siguientes modelos
2
Tabla de contenidos
Otros manuales de Calentador de agua de Webasto
Webasto
Webasto Thermo Top V Manual de instrucciones
Webasto
Webasto Thermo Top E Manual de usuario
Webasto
Webasto Thermo 90 S Manual de usuario
Webasto
Webasto Thermo 90 Manual de usuario
Webasto
Webasto Thermo Top E Manual de usuario
Webasto
Webasto Thermo Top C Manual de usuario
Webasto
Webasto D5W Z Manual de usuario
Webasto
Webasto Thermo 50 Manual de usuario
Webasto
Webasto Mercedes-Benz E-Class CLS BR 219 Manual de usuario
Webasto
Webasto Thermo Top E Parking Manual del operador
Webasto
Webasto Thermo 90 ST Manual de usuario
Webasto
Webasto thermotop C Manual de usuario
Webasto
Webasto thermo top evo Manual del operador
Webasto
Webasto BBW 46 Manual de usuario
Webasto
Webasto Thermo Top C Manual de usuario
Webasto
Webasto Thermo Top E Manual de usuario
Webasto
Webasto Thermo Top C Manual de usuario
Webasto
Webasto Thermo 90 Manual de instrucciones
Webasto
Webasto thermo top evo Manual del operador
Webasto
Webasto thermo top evo Manual del operador
