Vermont Castings VCS5005BI Manual de usuario

VERMONT CASTINGS

INBUILT GAS BARBEQUE GRILL

USER MANUAL VCS5005BI

OWNERS INSTALLATION & OPERATING INSTRUCTIONS.

KEEP THESE INSTRUCTIONS FOR FUTURE REFERENCE.

Congratulations on your purchase of this new Inbuilt Majestic barbeque. The

following information is designed to assist you in the assembly, installation,

operation, maintenance tips and trouble shooting and as well as some very

important safety information. We are sure that you will have many years of

enjoyable outdoor entertainment.

CONTENTS

Part 1: For Your Safety

Part 2: Installation Instructions

•Installation Warnings

•Clearances

•Gas Connections

•Safe Use of LPG Gas

•Safe Use of Natural

•Test for Leaks

Part 3: Operating Instructions

•Control Functions

•Lighting the Main Burners

•Turning Off the Burners

•Flare Ups

•Match Lighting the Main Burners

•Lighting the Rotisserie Burner

Part 4: Care & Maintenance

•Main Burners

•Rotisserie Burners

•Cooking Grids

•Drip Tray

•Stainless Panels

•Porcelain Ceramic Castings

•Burner Adjustments

Part 5: Troubleshooting

Part 6: Warranty

Part 1: For Your Safety

For your safety do not operate this appliance before reading this

instruction book.

WARNING: Improper installation, adjustment, alteration, service or

maintenance can cause injury or property damage. For assistance or

additional information consult with Raypak Australia, your Raypak

distributor, qualified installer or accredited Rheem Australia Service

agency

WHAT TO DO IF YOU SMELL GAS?

DO NOT try to light any gas appliance.

DO NOT touch any electrical switch.

Turn off gas supply at meter.

Immediately call Rheem Service or your gas supplier or licensed gas fitter.

Note: Some gases are heavier than air and it maybe necessary to check for

gas leaks at floor level.

CAUTION!

DO NOT operate this appliance before reading this instruction booklet.

DO NOT place articles or objects on or against the appliance.

DO NOT store chemicals or flammable materials near this appliance.

DO NOT spray aerosols in the vicinity of this appliance whilst it is in

operation.

WARNING

An LP gas cylinder not connected for use shall not be stored in the

vicinity of this or any other appliance.

Always keep this Manual near the grill, for convenient future reference.

WARNING

Barbeques must be used in accordance with the installation requirements of

your local gas supply authority, or the appropriate installation code issued by

the Australian Gas Association and the Australian Liquefied Petroleum Gas

Association.

Barbeques for use with bottled gas are labelled “Propane Gas” Barbeques for

use with natural gas are labelled “Natural Gas” and must be installed by an

authorised person. Check the gas type sticker attached to the barbeque.

Check that the label matches the gas type for the area in which it is to be

installed.

•Read the instructions before using the appliance.

•Accessible parts may be very hot.

•Keep young children away.

•Any modification of this appliance may be dangerous.

•Turn of the gas supply at the gas cylinder (LPG) after use.

•Parts sealed by the manufacture or their agents must not be

manipulated the user.

PREVENTION OF BURNS

Always keep children and pets under close supervision when using the

grill, and never permit them to come near the grill while in use, as the

exterior surfaces will be very hot.

Always wear insulated protective mitts when working at the grill, or

when attempting to close off the gas supply valve after cooking has

been completed, to prevent possible burns. Always use insulated pot

holders when handling containers of hot food.

Always use an insulated mitt when adding a smoking agent to the

smoke box.

Never store or use petrol or other flammable or volatile substances in

the vicinity of this grill or in the vicinity of any other heat generating

appliance.

VCS5005BINAU VCS5005BIPAU

Natural Gas Propane

Gas Consumption 66 MJ/h 80 MJ/h

Test Point Pressure 1 kPa 2.75 kPa

Injector Diameters –

Main Burners 1.50 mm 1.02 mm

Injector Diameters –

Rotisserie Burner 2.10 1.10mm

Main Burner Aeration 4.5mm 6.35mm

Rotisserie Burner

Aeration 16mm 10mm

Number of Injectors 5 x Hot Plate 1 x Rotisserie 5 x Hot Plate 1 x Rotisserie

Weight Kg 90 90

Dimensions mm L 980 x D 620 x H 580 L 980 x D 620 x H 580

COMBUSTION AIR OPENINGS

There are 31 25mm x 7mm oblong combustion air openings

on the underside of the upper front panel and 1 x 26mm

diameter combustion air opening on the right hand lower panel and 1 x 26mm diameter

combustion air opening on the left hand lower panel.

Part 2: Installation Instructions

Installation Warnings

A safe location for use of this outdoor BBQ

DANGER: This appliance shall only be used in an above ground, open air

situation with natural ventilation without stagnant areas, where gas leakage

and products of combustion are rapidly dispersed by wind or natural

convection. This grill has been designed for outdoors only

Never install this grill inside any building, garage, shed or breezeway or inside

any boat, trailer or recreational vehicle to prevent a possible fire and to

prevent the possibility of carbon monoxide poisoning or asphyxiation.

Any enclosure in which this appliance is installed shall comply with one of the

following:

•An enclosure with walls on all sides, but at least one permanent

opening at the ground level and no over head cover.

•Within a partial enclosure that includes an over head cover and no

more than two walls.

•Within a partial enclosure that includes an over head cover and more

than two walls, the following shall apply:

a) at least 25 % of the total wall area is completely open; and

b) at least 30 % of the remaining wall area is open and

unrestricted.

c) In case of balconies, at least 20% of the total of the side,

back and front wall areas shall be remain open and

unrestricted.

CLEARANCES

This appliance must be installed on non combustible materials. This outdoor

Barbeque must be installed in accordance with AS5601.

Safe Use of LPG (Propane) Gas

DANGER:

Never install a propane cylinder that is more than 80 % full, as the

contents may lack the adequate room for expansion when exposed to

heat. Propane vapour may then vent through the pressure relief valve,

which could accumulate in a pool and later cause an explosion or fire.

Never store a spare propane cylinder in or near this grill.

Exposing a disconnected cylinder to heat could result in the venting of

the propane vapour through the pressure relief valve, and the pooled

vapour could result in a violent fire.

Always confirm that all the openings in the cylinder compartment are

free from any obstructions that would restrict the circulation of

ventilation air. Good ventilation will prevent the pooling of leaked

propane vapour, which is heavier than air, and which could explode if

ignited.

WARNINGS:

Always consult the rating label prior to the installation of this barbeque

to confirm which fuel the unit has been configured for and will be

suited for the gas that you have available.

Always check that there are no gas leaks before lighting this grill. Apply

a 50/50 solution of liquid soap and water to the gas supply connections

with a brush or spray bottle, and watch for bubbles.

(tighten connections and check again) Never use a match or naked

flame to test for gas leaks.

Always visually inspect the gas supply line for fraying, cracking or

rodent damage before each use of this grill and if necessary replace

the defective part.

Always store your spare propane cylinder in an outdoor area that is

well ventilated, shady cool and removed from any heat source. Always

store in an upright position. Never store a spare cylinder in the vicinity

of this grill, or in the vicinity of any other heat source.

Safe Use of Natural Gas

DANGER:

Always consult the rating label prior to the installation of this barbeque

to confirm which fuel the unit has been configured for and will be suited

for the gas that you have available.

The size of the gas line to the appliance (ref AS5601) & connection to

the natural gas supply must be carried out by a licensed plumber for

safety and to assure compliance with the applicable codes.

Note: This unit is supplied with a gas regulator, securing bracket and

screws which must be fitted during installation. Fig. 1

Fig. 1

Always promptly shut off the gas supply and immediately extinguish all

flames if you smell gas. Contact your licensed plumber to rectify the gas

leak.

Always check that there are no gas leaks before lighting this grill. Apply a

50 / 50 solution of liquid soap and water to the gas supply connections

with a brush or spray bottle, and watch for bubbles.

Always visually check that there is no damage to the gas connections prior

to being used.

Never permit a gas supply line to come in contact with any heated surface

of this grill.

Test for Leaks

Always promptly shut off the gas supply and immediately extinguish all

flames if you smell gas. Contact your licensed plumber to rectify the gas

leak.

Always check that there are no gas leaks before lighting this grill. Apply a

50 / 50 solution of liquid soap and water to the gas supply connections

with a brush or spray bottle, and watch for bubbles.

Always visually check that there is no damage to the gas connections prior

to being used.

Never permit a gas supply line to come in contact with any heated surface

of this grill

Part 3: Operating Instructions

CONTROL FUNCTIONS

Propane Tank Valve

Tabla de contenidos

Otros manuales de Parrilla de Vermont Castings

Vermont Castings

Vermont Castings Signature VCS4027 Manual de usuario

Vermont Castings

Vermont Castings Signature VCS3006 Manual

Vermont Castings

Vermont Castings CF9030 Manual

Vermont Castings

Vermont Castings VCSeries Manual de usuario

Vermont Castings

Vermont Castings VCS3008B Series, VCS3008BI Series, VCS4008 Series, VCS5008 Series,... Manual

Vermont Castings

Vermont Castings VC0620P, VC0680P, VC0680N Manual de usuario

Vermont Castings

Vermont Castings VANGUARD XE Manual de usuario

Vermont Castings

Vermont Castings VC3505 Manual

Vermont Castings

Vermont Castings VC750PG1 Instrucciones de instalación

Vermont Castings

Vermont Castings VC100 Manual de usuario

Vermont Castings

Vermont Castings Signature VCS4017 Manual de usuario

Vermont Castings

Vermont Castings VCS3506BI Manual de usuario

Vermont Castings

Vermont Castings VC400 Manual

Vermont Castings

Vermont Castings Signature VCS4007 Manual

Vermont Castings

Vermont Castings VANGUARD G54003 Manual de usuario

Vermont Castings

Vermont Castings VCS325 Series Manual de usuario

Vermont Castings

Vermont Castings Vanguard XE G54004 Manual de usuario

Vermont Castings

Vermont Castings VC50 Manual de usuario

Vermont Castings

Vermont Castings VANGUARD Manual de usuario

Vermont Castings

Vermont Castings Vanguard 2-Burner Barbecue Manual de usuario

Vermont Castings

Vermont Castings VCS4000 Manual

Vermont Castings

Vermont Castings VANGUARD XE G54006 Manual de usuario

Vermont Castings

Vermont Castings VCT223SSP Manual

Vermont Castings

Vermont Castings VCS322SSBI Series Manual

Manuales populares de Parrilla de otras marcas

Orbegozo

Orbegozo GR 2300 Manual de usuario

bora

bora PT11 Manual de usuario

Klarstein

Klarstein 10031664 Manual de usuario

Garland

Garland MWE3W Manual de usuario

Char-Broil

Char-Broil 463722714 Manual de usuario

Nexgrill

Nexgrill 720-0830HK Manual de usuario

Kenmore

Kenmore 415.16123800 Manual de usuario

Camp Chef

Camp Chef PG24CLAU Manual de usuario

Tucker Barbecues

Tucker Barbecues GTR Series Instrucciones de montaje

Monogram

Monogram ZGG540NCP1SS Manual de usuario

Equipex

Equipex Sodir Savoy Manual de usuario

Gaggenau

Gaggenau VR 414 610 Manual de usuario

Miele

Miele KM 408-1 Manual de usuario

George Foreman

George Foreman GGR50B Manual de usuario

AOG

AOG T series Manual de usuario

Gorenje

Gorenje TG2000CB Manual de instrucciones

Weber

Weber Genesis Silver-B Permamount NG 051701 Manual de usuario

Glen

Glen SA 3037 Manual de usuario