Theben Timeguard BoostMaster DS3HD Manual

IP65 Time

Delay Switch

Model: DS3HD - White

Installation & Operating Instructions

WARNING: Isolate from supply before

removing this cover

DS3HD

IP65 Time Delay Switch

Press to Start

L - MAINS LIVE IN (right hand position of

connector)

SL - MAINS LIVE OUT (TO EXTERNAL LOAD)

(second from right hand position of connector)

EARTH – Connect any Earth wires to this pin

N– NEUTRAL (IN) (fourth from right hand position

of connector)

N– NEUTRAL (OUT) (ﬁfth from right hand position

of connector)

• NOTE: Ensure that all screws on the mains

connector are tightened adequately.

• Adequatelytightenthenutsonthecableentry

 pointsontheoutsideofthebox.

• Selecttherequiredtimedelaybyusingthetime

 delayselectorasshownbelow.

• Screwthefrontpanelbackon.Ensuretighttting

for IP compliance

• Switchonmainssupply.Theunitisnowreadyfor

operation.

4. Internal Delay Selection Switches

FourinternalDILswitchesareavailabletoselect8

timedelaysettingsasshownbelow.

Please Note: On the DIL switch, switch 1 is not in use

Time (minutes) Switch 4 Switch 3 Switch 2

2 L L L

5 L L R

10 L R L

30 L R R

60 R L L

90 R L R

120 R R L

 180 R R R

Left = ON Right = OFF

ON ON ON ON ON ON ON ON

2 mins 5 mins 10 mins 30 mins 60 mins 90 mins 120 mins 180 mins

Drainholespositionsareshownbelow.Thedrain

holesmustbedrilledoutusinga5mmdrill.Opening

the drain hole will reduce the IP rating of the

product.

Four xing holes

Four

drain

holes

Knock outs for cable conduit entry

3 Year Guarantee

Intheunlikelyeventofthisproductbecomingfaultydue

to defective material or manufacture within 3 years of the

date of purchase, please return it to your supplier in the first

yearwithproofofpurchaseanditwillbereplacedfreeof

charge. For years 2 and 3 or any difficulty in the first year

telephone the helpline on 020 8450 0515.

1. Technical Specications

ConformstoDirectives: 73/23/EEC&89/336/EEC

Operating Voltage: 230V 50Hz

Switching Capacity: Incandescent: 16A

Fluorescent: 16A

Resistive: 16A

Motor: 1hp

Operating temperature: -10°C to +40°C

Timingrange: 2minuteto180minutes

   in8steps

Timing accuracy: +/- 2%

Enclosure: Flame-resistant

   polycarbonatematerial.

IP rating: IP 65

Dimensions:  94mmx94mmx57mm

Terminals:  Suitablefor1.5mm2to

4mm2

1. General

The DS3HD is a time delay switch designed to

switchonanexternallyconnectedloadtomains

supplywhenthepushbuttonispressed.Itwill

then automatically switch off the load after a time

delayhaselapsed.Thetimedelaycanbeselected

bythreeinternalDILswitchestogive8different

timedelays.Thetimedelaycanbecancelledatany

timebypressingthepushbuttonagaininwhich

casetheblueLEDwillashandtheloadwillbe

disconnected after one minute.

DS3HD IP65 Time Delay Switch

Figure 1 - Front Panel of DS3HD

Illuminated push button

WARNING: Isolate from supply before

removing this cover

DS3HD

IP65 Time Delay Switch

Press to Start

2. Functional Description

ThereisasingleblueLEDilluminatedpushbutton

switch on the front panel. When pressed, the

DS3HD will function as follows:

• TheblueLEDwillturnoff.

• Anexternallyconnectedloadwillbeswitchedon

for the selected time delay.

• Oneminutebeforetheendofthetimedelay,the

 blueLEDwillash.

• Attheendofthetimedelay,theexternally

 connectedloadwillbeswitchedofffrommains

supply.

• TheblueLEDwillswitchpermanentlyonuntilthe

 pushbuttonispressedagain.

• Ifthepushbuttonispressedwhenthetimedelay

 isstillrunning,thedelaywillbeterminatedafter

1 minute.

• Ifthepushbuttonispressedinthelastminuteof

 thetimedelay(whenthebluelightisashing)

 thecountdownwillberesetandthetimerwill

restart the time delay.

3. Mounting and Installation

Warning: Switch off mains electricity

before proceeding with installation.

IMPORTANT NOTICE:

• Thisproductshouldbeinstalledinaccordance

with the current IEE and Wiring Regulations.

• Ifindoubtconsultaqualiedelectrician.

• Donotusethemainssupplyconnectorforwiring

 continuity.Mainsinputmustbesuppliedfromits

own 16 Amp MCB.

Figure 2 - Internal of DS3HD

Four PCB mounting screws

Knock outs for cable glands

Four xing

holes

Push

button

switch

connector

Time

delay

selector

Four xing

holes

Mains

supply

input and

output

connector

• Removefrontpanelbyunscrewingthefour

 xingscrews.

• Ifnecessary,carefullyremovetheprintedcircuit

 board(PCB)byundoingthefourPCBmounting

screws.

• Removeknockoutsat(preferably)thebottomof

 thebox.

• UseappropriateIP65ratedentryconduitstot

M20knockouts.EnsuretightttingforIPcompliance.

• Fixsurfacemountboxrigidlytoasecuresurface

 byusingappropriatescrewsthroughthefour.

 xingholes.

• RetthePCBbackontothesurfacemountbox

 byprogressivelytighteningeachofthefourPCB

mounting screws in turn. Do not over tighten

the screws

• Ensuringthatthemainswiresareadequate

 fortherequiredloadcutthecabletailstothe

appropriate lengths.

• Insertmainswiringthroughcableconduits.

• Connectthemainswirestothemains

connector as follows:

Figure 3 - Mains supply connector

Neutral Neutral in Earth Live out Live in

Designed in the U.K. 67-058-381

Timeguard Limited.

Victory Park, 400 Edgware Road,

London NW2 6ND

Sales Ofce: 020 8452 1112

or email csc@timeguard.com

or email helpline@timeguard.com

Designed in the U.K. 67-058-381

Timeguard Limited.

Victory Park, 400 Edgware Road,

London NW2 6ND

Sales Of ce: 020 8452 1112

or email csc@timeguard.com

For a product brochure please contact:

Zerofour – September 2010

or email helpline@timeguard.com

HELPLINE

020 8450 0515

Tabla de contenidos

Otros manuales de Minutero de Theben

Theben

Theben TR 608 top2 S Manual de usuario

Theben

Theben TR top2 Series Manual de usuario

Theben

Theben TR 644 S Manual de usuario

Theben

Theben TR 652 S Manual de usuario

Theben

Theben SELEKTA 070 top3 UP Manual de usuario

Theben

Theben SELEKTA 171 top2 RC 24 V Manual de usuario

Theben

Theben LUNA 111 top3 AL Manual de usuario

Theben

Theben SYN 161 d Manual de usuario

Theben

Theben SELEKTA 171 top2 RC 24 V Manual de usuario

Theben

Theben SELEKTA 175 top2 Manual de usuario

Theben

Theben SYN 161 h Manual de usuario

Theben

Theben SIMPLEXA 601 top Manual de usuario

Theben

Theben TC 649 C Manual de usuario

Theben

Theben TR 611 top3 Manual de usuario

Theben

Theben LUNA 121 top2 RC Manual de usuario

Theben

Theben SIMPLEXA 601 Manual de usuario

Theben

Theben TIME GUARD TGBT4 Manual

Theben

Theben Timeguard NTT05 Manual

Theben

Theben TR 611 top3 Manual de usuario

Theben

Theben termina tr 611 top2 Manual de usuario

Theben

Theben SELEKTA 171 top2 RC 24 V Manual de usuario

Theben

Theben TR 611 top2 RC 24 V Manual de usuario

Theben

Theben eltimo 020 Astro top3 Manual de usuario

Theben

Theben SELEKTA 171 Top3 RC Manual de usuario

Manuales populares de Minutero de otras marcas

Intermatic

Intermatic P1131 Manual de usuario

Learning Resources

Learning Resources Time Tracker mini Manual de usuario

CEBEK

CEBEK I-215 Manual de usuario

Somogyi

Somogyi home TS MD 5 Manual de usuario

Profile

Profile 010200280 Manual de usuario

Gizmo

Gizmo T4 Manual de usuario

Tekmar

Tekmar Timer 031 Manual de usuario

Daikin

Daikin DST301B61 Manual de usuario

sisel

sisel ENDA ETM2432 Manual de usuario

B&Q

B&Q TE103 Manual de operación y mantenimiento

Hozelock

Hozelock AC Plus 2700 Manual de usuario

GIC

GIC Eliro V7DDSS3Eliro V7DFTS3 Manual de usuario

Tork

Tork TU40 Manual de usuario

Emos

Emos EMT400F Manual de usuario

FarmTek

FarmTek Polaris Manual de usuario

Maximum

Maximum CRONUS Manual de usuario

Uberhaus

Uberhaus TD133B Manual de usuario

Clas Ohlson

Clas Ohlson 31-3766 Manual de usuario