THE WORLD MODELS Extra 300 EP Manual de usuario

THE WORLD MODELS

MANUFACTURING CO., LTD.

FACTORY PRE-FABRICATED

ALMOST-READY-TO-FLY (ARF) SERIES

MADE IN CHINA

www.theworldmodels.com

Warning! This model is not a toy.

It is designed for maximum performance. Please seek advice if one is not familiar with this kind

of electric powered precision model. Operating this model without prior preparation may cause

injuries. Remember, safety is the most important thing. Always keep this instruction manual at

hand for quick reference.

Wing Span

Wing Area

Flying Weight

Fuselage Length

40.5 in / 1030 mm

288 sq in / 18.6 sq dm

26.5 oz / 750 g

34.5 in / 880 mm

Specifications

*Specifications are subject to change without notice.*

INSTRUCTION MANUAL

Requires : 4-channel radio w/ 4 micro servos,

Outrunner Motor w/ Propeller Adaptor

20A Brushless ESC, 3 cells 11.1V

2100mAh Li - Po battery & charger.

P.1

INDEX

BEFORE YOU BEGIN

PARTS LIST

ASSEMBLY

SAFETY PRECAUTIONS

P.1

P.2

P.3-P.10

P.10

Check all parts. If you find any defective or missing parts contact your local dealer. Please

DRY FIT and check for defects for all parts that will require CA or Epoxy for final assembly.

Any parts you find to be defective after the gluing process may be difficult to remove for

warranty replacement. The manufacturer will replace any defective parts, but will not extend

to the parts that are good before gluing to defective parts during assembly. Warranty will

not cover any parts modified by customer.

Symbols used throughout this instruction manual comprise of the following :-

Read through the manual before you begin, so you will have an overall idea of what to do.

Cut off shaded portion.

Ensure smooth non-binding

movement while assembling.

Apply instant glue

(C.A.glue, super glue.)

Assemble left and right

sides the same way.

Peel off shaded portion

covering film.

Pay close attention here!

Apply epoxy glue.

Must be purchased separately !

Drill holes with the specified

diameter (here: 3mm).

Pierce the shaded portion

covering film.

3mm

Do not overlook this symbol !

Warning!

Apply thread locker

Parts List

COVERING:

LIGHTEX SGX252000

LIGHTEX SGX100 WHITE

LIGHTEX SGX540 PEARL GREEN

TOUGHLON STL412G CHECKER FERRARI RED/ GOLD

P.2

1. MAIN WING -- 1 pair

2. SCREW PM2x14mm -- 4 pcs

SCREW PA1.7x8mm -- 8 pcs

STRAPER -- 2 pcs

FUEL TUBE d2xD4x4mm -- 4 pcs

CLEVIS -- 2 pcs

HORN -- 2 sets

PUSHROD Ø1.4x85mm w/ Threads (For Aileron) -- 2 pcs

SERVO MOUNTING PANEL -- 1 pair

3. STABILIZER & ELEVATOR -- 1 set

FUSELAGE -- 1 pc.

4. VERTICAL FIN & RUDDER -- 1 set

5. TAIL LANDING GEAR -- 1 set

TAIL WHEEL Ø23mm -- 1 pc.

PLASTIC COLLAR d1xD5x2mm -- 2 pcs

SCREW PA2x8mm -- 2 pcs

SCREW PM2x8mm -- 1 pc.

M2 NUT -- 1 pc.

ALUMINUM PLATE 0.3mm -- 1 pc.

6. SCREW PM2x10mm -- 4 pcs

CLEVIS -- 2 pcs

FUEL TUBE d2xD4x4mm -- 2 pcs

HORN -- 2 sets

PUSHROD Ø1.4x375mm w/ Threads (For Elevator) -- 2 pcs

7. SCREW PM2x10mm -- 2 pcs

CLEVIS -- 1 pc.

FUEL TUBE d2xD4x4mm -- 1 pc.

HORN -- 1 set

PUSHROD Ø1.4x455mm w/ Threads (For Rudder) -- 1pc.

8. FOLDING PROPELLER SET (10x5) -- 1 set

SCREW PM2x12mm -- 2 pcs

SPINNER Ø45mm -- 1 pc.

SCREW PM3x6mm -- 4 pcs

WASHER d3xD7mm -- 4 pcs

COWLING -- 1 pc.

SCREW PWA2x8mm -- 4 pcs

9. MAIN LANDING GEAR -- 1 set

MAIN WHEEL Ø40mm -- 2 pcs

WHEEL PANTS -- 1 pair

SCREW PA2.6x10mm -- 3 pcs

SCREW PM3x25mm -- 2 pcs

WASHER d3xD7mm -- 2 pcs

M3 NUT -- 2 pcs

COLLAR Ø3.1mm w/ Set Screw -- 2 sets

COPPER TUBE d3.1xD4x5mm -- 2 pcs

ALUMINUM PLATE 0.5mm -- 2 pcs

SCREW PA2x6mm -- 4 pcs

WASHER d2xD5mm -- 4 pcs

10. EYE SCREW PA2.5x10x23mm -- 2 pcs

WING TUBE d9.6x240mm -- 1 pc.

RUBBER BAND D1x30mm -- 2 pcs

11. STRAPER -- 2 pcs

FUEL TUBE d2xD4x4mm -- 2 pcs

BATTERY TIE 200mm -- 1 pc.

SPONGE 10x50x150mm -- 1 pc.

DOUBLE-SIDED TAPE 30x35mm -- 1 pc.

PUSHROD Ø1.4x70mm (For Elevator) -- 1 pc.

PUSHROD CONNECTOR PL4410020 -- 1 set

12. CANOPY -- 1 pc.

SCREW PM2x12mm -- 1 pc.

WASHER d2xD5mm -- 1 pc.

M2 NYLON INSERT LOCK NUT -- 1 pc.

MOUNTING PLATE 5x15mm PL4114050 -- 1 pc.

PILOT PC001050B -- 1 pc.

13. DECALS -- 1 set

P.3

Please choose either 02L & 02R or 03L & 03R or 04L & 04R that suits your servo.

Clevis

Horn

Fuel Tube

d2xD4x4mm

PM2x14mm

Pushrod

Ø1.4x85mm

2mm

Aileron Servo Lead

Ø1mm pilot holes for World

Models tri-horn are pre-drilled.

Please look for pin-hole marks

at under side of control surfaces.

PA1.7x8mm Screw

Straper Fuel Tube

d2xD4x4mm

PA1.7x8mm

Aileron Servo

Main Wing

P.3

PM2x14mm Screw

Bottom View

Apply instant type CA glue

to both sides of each hinge.

02L

03L

04L

02R

03R

04R

4Vertical Fin & Rudder

P.4

Completed

C=C

Apply instant type CA glue to both sides

of each hinge.

1 2

Temporary install the main wing, adjust

leveling of the stabilizer to make it as

parallel to the main wing as possible.

Apply instant type CA glue

to both sides of each hinge.

*Also refer to step 13 Wing Setting

A=A

A A

(Stabilizer)

(Main Wing)

B=B

Stabilizer & Elevator

P.5

6Elevator Pushrod

Ø1mm pilot holes for World Models horn are pre-drilled.

Please look for pin-hole marks at under side of control surfaces.

Ø1mm pilot holes for World Models horn are pre-drilled.

Please look for pin-hole marks at under side of control surfaces.

40mm

125mm

7Rudder Pushrod

PM2x10mm Screw

Bottom View

5Tail Landing Gear

PM2x8mm Screw

PA2x8mm Screw PA2x8mm

M2 Nut

Plastic Collar

PM2x8mm

M2 Nut

Clevis

Fuel Tube

d2xD4x4mm

Horn

PM2x10mm

Pushrod

Ø1.4x375mm

Clevis

Horn

Fuel Tube

d2xD4x4mm

PM2x10mm

Pushrod

Ø1.4x455mm

20mm

60mm

Bottom View

1.5mm

2mm

1.5mm

P.6

9Main Landing Gear

8Outrunner Motor / Cowling

PM2x12mm Screw

PM2x12mm

PM3x6mm Screw

PM3x6mm

d3xD7mm Washer

PA2.6x8mm Screw

PA2.6x8mm

PWA2x8mm Screw

PWA2x8mm

Don’t over-tighten the PM2 screws, let the propeller

blades align themselves when spinning.

Ø40mm Spinner

M5 Nut

Make sure rotating

motor casing is not in

contact with wirings or

anything.

Outrunner Motor 28/ 30

KM0283010

Propeller Adaptor

(d3xD5) HW2340100

Optional Parts

Completed

PA2x6mm

d2xD5mm

Washer

PM3x25mm Screw

PA2.6x10mm Screw

3.1mm Collar

PA2x6mm Screw

d3.1xD4x5mm Copper Tube

M3 Nut

d3xD7mm Washer

d2xD5mm Washer

Bottom View

PA2.6x10mm

d3xD7mm

Washer

Don't over-tighten the

PM3 screws, too much

stress on the screws

could split the firewall.

Copper Tube

d3.1xD4x5mm

PM3x25mm

Plate 0.5mm

d3xD7mm Washer

Wheel

Ø40mm 3mm

Set Screw

3.1mm

Collar

M3 Nut

1.5mm

1mm

P.7

10 Main Wing

Bottom View

Eye Screw

PA2.5x10x23mm

Bottom

Wing Tube

D9.6x240mm

Aileron Servo Lead

Rubber Band

1.5mm

11 Radio Equipment

Canopy

P.8

PM2x8mm Screw

PM2x8mm

Mounting Plate

Install and arrange the servo as shown in the diagram.

Front

Sponge

Battery

Battery Tie

Receiver

Pilot

Rudder Servo

Straper

20A Brushless ESC

Fuel Tube

d2xD4x4mm Double-Sided tape

Elevator Servo

Pushrod Connector

d2xD5mm Washer

d2xD5mm

Washer

M2 Nylon Insert Lock Nut

Completed

J1(Pushrod Ø1.4x70mm)

Elevator Pushrod

Ø1.4x70mm

KA1.7x6mm

J2(Pushrod Ø1.4x375mm)

2mm

P.9

13 Wing Setting

Adjust the wing and fuselage configuration as shown in the diagrams.

A=A' B=B' C=C'

Otros manuales para Extra 300 EP

Tabla de contenidos

Otros manuales de Juguete de THE WORLD MODELS

THE WORLD MODELS

THE WORLD MODELS The Big Wings Manual de usuario

THE WORLD MODELS

THE WORLD MODELS Aure Manual de usuario

THE WORLD MODELS

THE WORLD MODELS ARF PIPER J-3 CUB EP Manual de usuario

THE WORLD MODELS

THE WORLD MODELS Spot on 50 Manual de usuario

THE WORLD MODELS

THE WORLD MODELS Pilatus PC-6 Porter 40 Manual de usuario

THE WORLD MODELS

THE WORLD MODELS Wing Jet EP Manual de usuario

THE WORLD MODELS

THE WORLD MODELS PIPER J-3 CUB 26s Manual de usuario

THE WORLD MODELS

THE WORLD MODELS At-6 Texan EP Manual de usuario

THE WORLD MODELS

THE WORLD MODELS Focke-Wulf 190A Manual de usuario

THE WORLD MODELS

THE WORLD MODELS CAP 232-46S Manual de usuario

THE WORLD MODELS

THE WORLD MODELS EP-Sailor Manual de usuario

THE WORLD MODELS

THE WORLD MODELS Hall Cherokee II Manual de usuario

THE WORLD MODELS

THE WORLD MODELS Super Chipmunk-90 RF Manual de usuario

THE WORLD MODELS

THE WORLD MODELS 1/3 Clipped Wing Cub Manual de usuario

THE WORLD MODELS

THE WORLD MODELS ARF Zen 30 Manual de usuario

THE WORLD MODELS

THE WORLD MODELS Thermal Rider EP Manual de usuario

THE WORLD MODELS

THE WORLD MODELS VOODOO MUSTANG-46 Manual de usuario

THE WORLD MODELS

THE WORLD MODELS P-47D THUNDERBOLT Manual de usuario

THE WORLD MODELS

THE WORLD MODELS 50cc Piper Cub Manual de usuario

THE WORLD MODELS

THE WORLD MODELS Pilatus PC-6 Porter 40 Manual de usuario

THE WORLD MODELS

THE WORLD MODELS ZEN 50 Manual de usuario

THE WORLD MODELS

THE WORLD MODELS SPITFIRE 40 Manual de usuario

THE WORLD MODELS

THE WORLD MODELS Sky Runner Manual de usuario

THE WORLD MODELS

THE WORLD MODELS ARF AT-6 Texan Manual de usuario

Manuales populares de Juguete de otras marcas

marklin

marklin 37321 Manual de usuario

Canon

Canon PAPER CRAFT Manual de usuario

GREAT PLANES

GREAT PLANES Pitts M-12S Manual de usuario

NOCH

NOCH 14261 Manual de usuario

Hausler

Hausler 450 SE V2 Manual de usuario

Dynaflite

Dynaflite Daydream Manual de usuario

MiniacRC

MiniacRC MIGHTY MINI P40 WARHAWK Manual

Kenner

Kenner Batman 63651 Manual de usuario

LEGO

LEGO 8527 Manual de usuario

iKarus

iKarus ECO 8 Manual de usuario

Multiplex

Multiplex EasyStar II Manual de instrucciones

Walkera

Walkera 38 Manual de instrucciones

Hasbro

Hasbro TRANSFORMERS BUMBLEBEE Manual de usuario

MD MXION SWD Manual de usuario

Mattel

Mattel Disney Pixar Cars Cozy Cone Spiral Rampway Manual de usuario

marklin

marklin 39671 Manual de usuario

Meccano

Meccano 15103 Manual de usuario

LEGO

LEGO TECHNIC 8735 Manual de usuario