ShelterLogic 27273 Manual de usuario

Description Qty. Part #

(Top Bend, shallow bend)

(Side Bend, sharp bend)

24'x 40' ULTRA MAX PEAK CANOPY

#27273

Please read instructions completely before assembly

PAGE 1

05-27273-0A 01/10/07

800091

3-Way Frame Connectors

800093

4-Way Frame Connectors

800092

3-Way Frame Connectors

800094

4-Way Frame Connectors

800235

4800216

24 800095

14 800096

Support Tube 72 3/8"

Common Tube 72 3/8"

Oblique Tube 72 3/8"

18 800098

Cross Rail 77 1/8"

12 800230

Pocket Pipe 77 3/8"

All-Weather Cover

4-Way Cover Rail Clamp 800221

3-Way Cover Rail Clamp 800220

Temporay 15 ”Auger Anchor s 18 10014

Wind Brace (Swedged Ends)

Wind Brace (Flat Ends)

8001047

8001037

Ropes 10437

5/16"x 2 1/4" Bolts

Nuts 5/16" 137

11130

00690

Ratchet 10040

800217

5/16" x 2" Round Head Bolts

800218

5/16" x 3" Round Head Bolts

Base Feet 800105

56 10431

Anchor

"S" Hook

White Rope

Rope bead

800225

800233

10465

Model : 24'x40'

1-800-524-9970

CONSUMER SUPPORT

FOR MISSING,

REPLACEMENT PARTS

QUESTIONS

PLEASE CONTACT

WARNING!

Use CAUTION when assembl-

ing this unit. Be aware of poles

over your head during assembly

that may not be secured, and

could fall and cause injury.

Frame Assembly Overview

PAGE 2

PAGE 3

Basic Frame Assembly

STEP 1

STEP 2

STEP 3

STEP 4

Assemble the wind brace set as shown in the

illustrations.

Step 2A

Fit together the end rib using the following parts

(1) #800091 3-Way Top Connectors

(2) #800096 Rafter Poles

(2) #800095 Common Tubes

(2) #800092 3-Way Side Connectors

(1) Wind Brace set

Step 2B

Fit together the middle rib using the following parts

(1) #800093 4-Way Top Connectors

(2) #800096 Rafter Poles

(2) #800095 Common Tubes

(2) #800094 4-Way Side Connectors

(1) Wind Brace set

Using (6) #800218 (5/16" x3" Bolts) and (6) Nuts securely

fasten these tubes. Lay these ribs on the ground at the rear

of your shelters designated location.

Fig. 4BFig. 4A

NOTE: Be sure that all of the heads of the bolts are

facing toward the outside of the rib.

Repeat step 2A/2B for all the other ribs.

Using #800098 Cross Rails, #800217

(5/16" x 2" Bolts) and Nuts to connect

these ribs.

800098

800216

800095

Assemble (2) #800216 Corner Support Tubes and (4) # 800095 middle support tube as shown in Fig. 4A and set aside.

Assemble other side Support Tubes as shown in Fig. 4B and connect the middle support tubes with #800218 (5/16" x 3"

Bolts) and nuts. Repeat this step at opposite side.

Note: #800218 Bolts are required for middle support tube connections. Bolts are not inserted to the corner legs

(#800216) at this step.

#800217

#00690

#800103

#800104

Fig. 2A

Fig. 1

Fig. 2B

2 End Ribs

800095

800092

Wind brace

800096 800091

Middle Ribs

800095

800094

Wind brace

800096

800093

#800218(5/16"x3"Bolt)

STEP 7

STEP 6

Depending on the model you have purchased, your

base feet will either fit onto the outside of the leg poles,

or slide inside the leg poles. After installing Base Feet

Plates onto bottom of Support leg Poles, be sure to

line up the predrilled hole in the leg with the predrilled

hole in the base foot. Insert 5/16" x 3" bolts all the way

through leg and foot to other side, secure with nuts.

Note: Don't insert the bolt to the corner legs at this step.

Fig. 5A

Fig. 5B

Locate a suitable location to place 4 anchors as shown

in the illustration into each of the base feet until

the round end of the anchor touches the base feet.

STEP 5

Position the cover on the side of the frame with the side with the grommets parallel to the frame and facing down.

Go to the opposite side of the frame and throw at least three ropes over the frame (evenly spaced along the length

of the frame). Tie the ropes to the grommets on the cover and use the rope to pull the cover over the frame (the

more people and ropes you have to pull the cover over the easier it is to do). Position the cover so that the valance

is even front to back and side to side.

corner

clamps

11130

690

800220

Fig.7B

middle

clamps

11130

800221

690

Fig.7A

Fig.7

Pocket Pipe

Fig.6 Fig.6A

Fig.6B

Rope

PAGE 4

Slide the pocket pipes into the cover pockets between the cutouts. Attach the pocket pipes to the frame using the

3 & 4 way clamps (800220 & 800221) and the 5/16 X 2 #11130 bolts and nuts. Check that the pocket pipes are

evenly spaced on both sides of the top pipe. Slide the pocket pipe down the length of the rafters to tighten the top

section of the cover. When the cover is pulled tight secure the bolts and nuts in the sliding clamps to hold them in

place.

Tie a loop into the end of the

rope. Feed the loop over the

top of the rafter pole and feed

the other end of the rope through

the loop and run the rope down

the leg at least 12" and wrap

the rope around the leg and

feed the loose end over the

rope (Fig.6A).

Take the loose end of the robe

and secure it to the auger an-

chor already secured in the ground

(Fig.6B).Repeat these steps for the

remaining legs on the canopy.

STEP 8

PAGE 5

Fig.8A Fig.8B

Slide the rope through the grommets and around

the side extention tubes at both sides shown

in Fig.7C, Fig.7D & Fig.7E. Insert the 'S' hook to the

corner leg tube, then 'twist' the leg to tight the rope.

After tighting the rope, secure the (4) corner leg tubes

#800216 to the corner connectors and feet plates with

#800218 (5/16" x 3" Bolts) and nuts.

Use the (4) Ratchets as shown in Fig.8A.

Adjust the cover so there is equal overhang

on the front and rear. With the webbing and

ratchets pull the cover snug but not tight.

When all of the half clamps and rope are

secured tight finish tightening the (4) Ratchets

to make final adjustment to the cover.

Fig.7C

Fig.7E

Fig.7D

Otros manuales de Carpa de ShelterLogic

ShelterLogic

ShelterLogic 10' x 8' x 8' Peak Style Shelter Manual de usuario

ShelterLogic

ShelterLogic Max AP 25757 Manual de usuario

ShelterLogic

ShelterLogic SuperMax 26767 Manual de usuario

ShelterLogic

ShelterLogic Pop-Up 22538 Manual de usuario

ShelterLogic

ShelterLogic 62697 Manual de usuario

ShelterLogic

ShelterLogic 22561 Manual de usuario

ShelterLogic

ShelterLogic 22966 Manual de usuario

ShelterLogic

ShelterLogic 25730 Manual de usuario

ShelterLogic

ShelterLogic ShelterCoat Round Manual de usuario

ShelterLogic

ShelterLogic ShadeLogic 14550 Manual de usuario

ShelterLogic

ShelterLogic 22568 Manual de usuario

ShelterLogic

ShelterLogic Shed-in-a-Box CT 06795 Manual de usuario

ShelterLogic

ShelterLogic 12'W x10'H Peak Style Manual de usuario

ShelterLogic

ShelterLogic MaxAP 3-in-1 Manual de usuario

ShelterLogic

ShelterLogic Pop-Up 22533 Manual de usuario

ShelterLogic

ShelterLogic SuperMax 26767 Manual de usuario

ShelterLogic

ShelterLogic Shed-in-a-Box 30333 Manual de usuario

ShelterLogic

ShelterLogic Shed-in-a-Box 70411 Manual del propietario

ShelterLogic

ShelterLogic Garage-in-a-Box SUV/Truck 62696 Manual de usuario

ShelterLogic

ShelterLogic Shed-in-a-Box RoundTop Manual de usuario

ShelterLogic

ShelterLogic 23521 Manual de usuario

ShelterLogic

ShelterLogic Garage-in-a-Box RoundTop 62780 Manual de usuario

ShelterLogic

ShelterLogic Greenhouse-in-a-Box Easy Flow Manual de usuario

ShelterLogic

ShelterLogic ShelterTech 4,6 x 4,3 m Manual de usuario

Manuales populares de Carpa de otras marcas

OZTENT

OZTENT JV SIGNATURE EDITION Manual de usuario

GigaTent

GigaTent Summer Chalet Mini Tent Manual de usuario

Coleman

Coleman 2000007827 Manual

Outsunny

Outsunny 84C-230 Manual de usuario

Napier

Napier SPORTZ COVE 61 Series Manual de usuario

EuroTrail

EuroTrail ATLANTIS PRO Manual de usuario

Reimo

Reimo Marina Manual de usuario

TiiTENT

TiiTENT TB300 Manual de usuario

Coleman

Coleman 2000033134 Guía de instalación

Ozark Trail

Ozark Trail W784.1 Guía de inicio rápido

SlingFin

SlingFin CrossBow 2 Manual de usuario

Coleman

Coleman 9600-141 Manual de usuario

Palram

Palram Arizona 5000 Wave - WINGS Manual de usuario

COVERPRO

COVERPRO 56184 Instrucciones de montaje

Vango

Vango Zenith 100 Manual de usuario

Costway

Costway PATIOJOY OP70818 Manual de usuario

Clarke

Clarke PUC 88 Manual de usuario

Snow Peak

Snow Peak Alpha Breeze Manual de usuario