Prince Castle 428-BX Manual de usuario
355 East Kehoe Blvd. zCarol Stream, IL 60188
Tel: (630) 462-8800 zFax: (630) 462-1460
Toll Free: 1-800-PCASTLE (1-800-722-7853)
428-BX 428-513 Printed in the USA 0101 2002
TABLE OF CONTENTS PAGE
Installation............................................................................................. 2
Electrical Specifications .................................................................... 2
Product Identification.......................................................................... 2
Operation .............................................................................................. 3
Preventive Maintenance .................................................................... 4
Cleaning ................................................................................................. 4
Troubleshooting Chart ........................................................................ 5
Exploded View ..................................................................................... 6
Parts List ............................................................................................... 6
Wiring Diagram ..................................................................................... 7
LIMITED WARRANTY
This product is warranted to be free from defects in material and/
or workmanship for a period of two (2) years from date of original
installation. On-location service for failure within 1 year of
installation, proof of purchase will be required.
Any component which proves to be faulty in material and/or
workmanship will be replaced or repaired (at the option of Prince
Castle, Inc.) without cost to the customer for parts or labor.
This warranty is subject to the following exceptions/conditions:
zUse of any non-genuine Prince Castle parts voids this
warranty.
zAll labor shall be performed during regular work hours. Overtime
premium will be charged to the buyer.
zDamage caused by carelessness, neglect, and/or abuse
(e.g., dropping, tampering or altering parts), equipment
damaged in shipment, by fire, flood or an act of God is not
covered under this warranty.
zMotors that fail due to the lack of monthly lubrication will not
necessarily be covered under warranty.
zThis toaster must be serviced by a Prince Castle Authorized
Service Center or a Prince Castle Service Technician. Failure
to do so can void this warranty.
Conveyor Toaster
Model No. 428-BX
Operation
Manual
2
ELECTRICAL INFORMATION
Model VoltsWatts Amps Hz Plug
428-BX 208 2600 12.5 50/60 6-2OP
Conveyor Toaster
Model No. 428-BX
INSTALLATION
1. After you have removed the toaster from the carton, inspect the unit for signs of damage. If there is damage to the
unit:
zNotify carrier within 24 hours after delivery.
zSave carton and packing materials for inspection purposes.
zContact your local dealer or, if purchased directly, the Prince Castle Customer Sales Department at 1-630-462-8800 to
arrange for a replacement to be sent.
2. Verify that all parts have been received. Remove Protective Coating.
3. Adjust legs so toaster is level.
4. Remove packaging from bun slide and install bun slide in toaster by hooking it into the two pins in the rear of the
chamber.
5. The toaster fan located on the bottom of the toaster in the rear draws in cool room air and circulates it through the
toaster sides and tops. To insure adequate heat dissipation do not position the toaster where the fan would draw in
hot discharge from another appliance.
INTENDED USE
This toaster is designed to toast breads bagels or English
muffins. Do not attempt to toast croissants. Their butter
content will cause them to stick to the conveyor. Do not
attempt to toast products that have been buttered or spread
with jam or other coating Do not attempt to bake in the
toaster.
PRODUCT IDENTIFICATION
Lower Heater
Control Switch
Upper Heater
Control Switch
Speed
Control
Switch
Power
Switch
Extended
Conveyor
Assembly
Bun Ramp
428-BX 428-513 Printed in the USA 0101 2002
OPERATION
Plug unit into the proper voltage receptacle.
Set Power switch to “l” for On.
Turn upper and lower heater controls to
maximum.
Conveyor Toaster
Model No. 428-BX
1
2
Allow 20 minutes for toaster to warm up.
Lay Bread, Bagel or Muffin, cut side up
on the extended conveyor and push into
toaster until it slides on to the conveyor
chain. To control toast color, vary the
conveyor speed or the heater settings.
3
428-BX 428-513 Printed in the USA 0101 2002
3
4
The motors used on the Prince Castle Bun
Toasters, require monthly lubrication, 2-3 drops
of 3 in 1 oil. Motors that fail due to the lack of
monthly lubrication will not necessarily be
covered under warranty. We would like to have
field service technicians stress this mainte-
nance requirement whenever failures occur on
these toasters.
Oil Hole
The conveyor chain should not touch the top
surface of the crumb tray holder. If the chain does
touch, retention it by unplugging the unit, remove
both side covers, loosen the front bearing mount-
ing screws and pivot the bearing until the chain
no longer touches. Retighten bearing screws and
replace side covers
Conveyor Toaster
Model No. 428-BX
428-BX 428-513 Printed in the USA 0101 2002
PREVENTATIVE MAINTENANCE
WARNING: Turn off power switch,
unplug toaster from wall outlet, and
let toaster cool down before doing
any repairs. All repairs should be
done by a qualified service techni-
cian.
WARNING: This unit is not water tight.
Do not clean with a water jet or jet
spray. Do not immerse the unit in
water
1. Set the POWER switch to OFF. Allow
toaster to cool for 30 minutes.
2. Unplug toaster.
3. Remove crumb tray and clean toaster and
parts by wiping with damp cloth.
Note: Some units come with a Teflon coated
return chute. Do not use an abrasive cleaning
agent or scrub brush on the Teflon.
CLEANING
Conveyor Toaster
Model No. 428-BX
5
PROBLEM CAUSE SOLUTION
High limit tripped. Toaster overheating due to Clean any debris from the fan guard
blockage of airflow. that might be blocking the flow.
Airflow fan inoperable. Replace fan .
No power. Circuit breaker tripped. Reset circuit breaker.
Power switch inoperable. Replace power switch.
Broken wire in power cord. Replace power cord.
Toaster conveyor not Conveyor motor inoperable. Lubricate and/or Replace motor.
turning. Conveyor switch inoperable. Replace speed switch.
Motor chain is loose Retension motor chain.
Conveyor bearings worn Replace bearings
Conveyor chain binds Sprockets worn. Replace sprockets.
up in operation. Excessive slack in conveyor Remove a chain link.
chain.
Toaster overheating. Airflow blockage. Clean any debris from fan guard
Airflow fan inoperable Replace fan motor.
Upper and lower heat Heater switch inoperable. Replace heater switch.
tubes not heating. Heater inoperable. Replace heater .
Bread product burning. Conveyor speed too slow. Adjust to proper settings
Bread product too light. Conveyor speed too fast. Adjust to proper settings
Lower heaters heating High Limit Switch Tripped See High Limit Tripped section
but top heaters are not.
428-BX 428-513 Printed in the USA 0101 2002
TROUBLESHOOTING CHART
6
PARTS LIST
Conveyor Toaster
Model No. 428-BX
428-BX 428-513 Printed in the USA 0101 2002
PN Qty Description
428-108 1 COVER,REAR GM2
428-126 2 COVER,SIDE
428-307 1 IDLER SHAFT ASSY
421-087 1 DRIVE SHAFT ASSY
421-286 2 BEARING,TEFLON REAR
421-287 1 BRACKET,CONVEYOR SHAFT STOP
428-080 1 TRAY,CRUMB
421-071 1 SPROCKET,DRIVE
428-144 1 CHAIN,DRIVE ANSI 25 75 LINKS
428-081 1 CHUTE,BUN SLIDE BX
428-311 1 CHAIN,CONVEYOR,76 LINKS
421-072 1 SPROCKET,IDLER
428-305 1 CONVEYOR,EXTENSION RH
428-306 1 CONVEYOR,EXTENSION LH
428-304 2 BEARING,TEFLON FRONT
428-362 1 GUARD,FRONT PLASTIC
86-312 4 SPACER
86-255 4 LEG,1"HI,1/4-20 MTG STUD,PLAST
70-043 1 KNOB,SPEED CONTROL
428-143 1 LINK,SPRING CLIP CONN. ANSI 25
86-271 1 GUARD,4"TUBEAXIAL FAN
421-090 3 CLIP,SPLICING CONVEYOR
78-173S 2 SWITCH,HEAT CONTROL,240V
70-042 2 KNOB,HEAT CONTROL
78-228S 1 SWITCH,ROCKER DPST ARCO C6053
87-018S 1 MOTOR,GEAR
428-142 1 FAN,4" TUBEAXIAL W/TAPPED HLS
72-159S 1 LINE CORD ASSY
421-274 1 INSULATOR,HIGH LIMIT
428-170S 6 HEATER,550W 69V 12.5"
65-048-10S 1 RELAY,DPDT,30A,220/240 50/60HZ
428-247 1 HEAT SHIELD,428’S
Conveyor Toaster
Model No. 428-BX
7
428-BX 428-513 Printed in the USA 0101 2002
WIRING DIAGRAM
8
Tabla de contenidos
Otros manuales de Tostadora de Prince Castle
Prince Castle
Prince Castle DCFT-MCD Series Manual de usuario
Prince Castle
Prince Castle 297-T12 Manual de usuario
Prince Castle
Prince Castle CTD Manual de usuario
Prince Castle
Prince Castle 247-ACC Manual de usuario
Prince Castle
Prince Castle IRT-SB-NA-1PS Manual de usuario
Prince Castle
Prince Castle 464-B Manual de usuario
Prince Castle
Prince Castle DCFT-BKCE Manual de usuario
Prince Castle
Prince Castle DCFT-MCD Manual de usuario
Prince Castle
Prince Castle Excalibur 411-SL Series Manual de usuario
Prince Castle
Prince Castle DCFT-MCD Series Manual de usuario
Prince Castle
Prince Castle CTD Manual de usuario
Prince Castle
Prince Castle TX-208BK Manual de usuario
Prince Castle
Prince Castle 428-3B Manual de usuario
Prince Castle
Prince Castle CBT-SB-NA-1PS Manual de usuario
Prince Castle
Prince Castle 454-B Manual de usuario
Prince Castle
Prince Castle DCFT-BKCE Guía de configuración
Prince Castle
Prince Castle TX-208 Manual de usuario
Prince Castle
Prince Castle DCFT-BKM Manual de usuario
Prince Castle
Prince Castle DCFT-BK Manual de usuario
Prince Castle
Prince Castle 247 Series Manual de usuario
