Norac UC4.5 Manual de usuario

Generic Unit

Fixed (Non-VG) Boom with Slant Control

Installation Manual

GN2

Printed in Canada

Reorder P/N: UC4.5-BC-GN2-INST Rev B (Generic Unit – Fixed (Non-VG) Boom with Slant

Control)

NOTICE: NORAC Systems International Inc. reserves the right to improve products and their specifications without notice and

without the requirement to update products sold previously. Every effort has been made to ensure the accuracy of the information

contained in this manual. The technical information in this manual was reviewed at the time of approval for publication.

Contents

1Introduction................................................................................................................. 1

2General UC4.5 System Layout.................................................................................. 2

3Kit Parts ....................................................................................................................... 3

4Ultrasonic Sensor Installation ................................................................................... 5

5Electrical Installation .................................................................................................. 9

6Software Setup..........................................................................................................12

7Calibrating the Slant Valve ......................................................................................13

8Cable Drawings .........................................................................................................16

1Introduction

Congratulations on your purchase of the NORAC UC4.5 Spray Height Control System. This

system is manufactured with top quality components and is engineered using the latest

technology to provide operating reliability unmatched for years to come.

When properly used the system can provide protection from sprayer boom damage, improve

sprayer efficiency, and ensure chemicals are applied correctly.

Please take the time to read this manual completely before attempting to install the system. A

thorough understanding of this manual will ensure that you receive the maximum benefit from

the system.

Your input can help make us better! If you find issues or have suggestions regarding the parts

list or the installation procedure, please don’t hesitate to contact us.

Every effort has been made to ensure the accuracy of the information contained in

this manual. All parts supplied are selected to specially fit the sprayer to facilitate

a complete installation. However, NORAC cannot guarantee all parts fit as

intended due to the variations of the sprayer by the manufacturer.

Please read this manual in its entirety before attempting installation.

2General UC4.5 System Layout

Figure 1 and Figure 2 illustrate the general layout of the UC4.5 system components:

Figure 1: General UC4.5 System Layout (Self Propel Type)

Figure 2: General UC4.5 System Layout (Pull Type)

3Kit Parts

The following diagrams illustrate the GN2 kit specific parts of the NORAC UC4.5 system.

Interface and power cables are shown in this manual and may not be included. Cables are

available separately from NORAC. Please refer to the UC4.5 Generic Cable Ordering Guide

(P/N: UC4.5-BC-CABLE-GUIDE), for cable ordering information (available at www.norac.ca).

3.1 Kit Overview

Figure 3: GN2 System Parts

NOTE: Parts shown in blue are NOT included in this kit and must be ordered

separately.

3.2 List of Parts

Item Part Number Name Quantity

B05 44706-01 KIT CABLE TIE BLACK 10 PCS 21 IN 150 PCS 7.5 IN 1

B20 44971 SENSOR MOUNTING BRACKET LOW PROFILE 16GA 2

C05 43210-20 CABLE UC5 NETWORK 18 AWG 20M 2

E01 45100 UC4.5 BOOM CONTROL PANEL 1

E05 43750 UC5 ULTRASONIC SENSOR 2

E10 43760 UC5 NETWORK COUPLER 3-WAY 1

E20 43764T UC5 NETWORK COUPLER 2-WAY WITH TERMINATOR 2

M01

UC4.5-BC-MANUAL-

OPERATOR

OPERATOR MANUAL UC4.5 SPRAY HEIGHT CONTROL 1

M02 UC4.5-BC-GN2-INST MANUAL INSTALLATION UC4.5 GENERIC FIXED BOOM 1

M03

UC4.5-BC-GN2-INSTE

MANUAL INSTALLATION UC4.5 END USER GENERIC FIXED BOOM 1

M06

45015

ANTI-SEIZE LUBRICANT KIT 1

The use of dielectric grease is not recommended on any NORAC electrical

connections.

To ensure all stainless steel hardware does not gall or seize apply a light coating of

the supplied Permatex Anti-seize grease (M06) to all threaded parts upon

installation. Permatex Anti-seize lubricant is preferred, but other similar anti-seize

products may be used.

4Ultrasonic Sensor Installation

4.1 Ultrasonic Sensor Serial Number Arrangement

When installing the UC5 sensors, start with the smallest serial number on the left-hand side,

and proceed to the largest serial number on the right hand side. Each UC5 sensor has a serial

number stamped on the sensor housing.

Apply a light coating of the supplied Permatex Anti-seize grease (M06) to all

threaded parts upon installation.

Figure 4: Sensor Serial Number Arrangement

4.2 Ultrasonic Sensor Mounting Guidelines

The following guidelines will ensure optimal sensor performance and prevent sensor

measurement error. These rules should be followed for both the wing sensors and the main

lift (middle) sensor.

1. In its lowest position, the sensor must be 9 inches (23 cm) or more from the ground.

2. Ensure that there are no obstructions within a 12-inch diameter circle projected directly

below the center of the sensor.

3. The sensor should be approximately vertical at normal operating heights.

Figure 5: Sensor Mounting Guidelines

4.3 Low Profile Bracket Mounting Guidelines

1. Minimize the distance between the bolts to prevent bending the bracket and prevent the

bracket from loosening over time.

2. Ensure the bracket is mounted tight against the bottom of the boom, minimizing the

distance between the boom structure and the angled flange.

Figure 6: Bracket Mounting Guidelines

A problem can arise if a sensor is not mounted correctly. It is possible for the

sensor to read off of the boom instead of the ground. This may only become

apparent once the control system is switched from soil to crop mode.

Also be careful that the sensor bracket does not collide with any other part of the

boom when the boom is folded to transport position. If possible, mount the sensor

brackets while the booms are folded to ensure they will not cause interference.

Otros manuales para UC4.5

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Sistema de control de Norac

Norac

Norac UC4.5 Manual de usuario

Norac

Norac UC4+ Manual de usuario

Norac

Norac UC4+ Apache 2010+ Manual de usuario

Norac

Norac UC5 Topcon X30 Manual de usuario

Norac

Norac UC5 Topcon X30 Manual de usuario

Norac

Norac UC4.5 Manual de usuario

Norac

Norac Rogator 700 Series Manual de usuario

Norac

Norac UC4.5 Manual de usuario

Norac

Norac UC7 Manual de usuario

Norac

Norac UC7 Manual de usuario

Norac

Norac UC5 Topcon X30 Manual de usuario

Norac

Norac UC5 Active Roll Control Manual de usuario

Norac

Norac Case AFS Pro 300 Manual de usuario

Norac

Norac UC5 HD12 Manual de usuario

Norac

Norac UC4.5 Manual de usuario

Norac

Norac UC5 Topcon X30 Manual de usuario

Norac

Norac UC4 Plus Rogator 64 Series Manual de usuario

Norac

Norac UC5 Topcon X30 Manual de usuario

Norac

Norac UC5 Topcon X30 Manual de usuario

Norac

Norac UC4+ Manual de usuario

Norac

Norac UC4 Total Control Manual de usuario

Norac

Norac UC4 Total Control Manual de usuario

Norac

Norac UC5 Topcon X30 Manual de usuario

Norac

Norac UC4+ Manual de usuario

Manuales populares de Sistema de control de otras marcas

Pentair Pool Products

Pentair Pool Products Compool Manual de usuario

ComfortNET

ComfortNET CTK04 Manual de usuario

Fireye

Fireye InSight II 95DSS3 Manual de usuario

CAME

CAME G3000 Manual de usuario

Idemia

Idemia MorphoAccess VP MD Manual de usuario

Axis

Axis P1445-LE-3 Manual de usuario

HEIDENHAIN

HEIDENHAIN TNC 150 B Manual de usuario

CNC-Step

CNC-Step High-Z T-Series Manual de usuario

Doosan

Doosan DVF Series Manual de usuario

Honeywell

Honeywell KAP 140 Manual de usuario

Honeywell

Honeywell vk41 series Manual de usuario

AirBench

AirBench FPW Guía de instalación

Cypress

Cypress HHR-3160 Manual de usuario

CAME

CAME GLT40AOS Manual de usuario

Zonex

Zonex GEN II -VVT Guía del usuario

Altronics

Altronics K 9650 Manual de usuario

micro-trak

micro-trak RoadMaster Manual de usuario

micro-trak

micro-trak Calc-An-Acre II Manual de usuario