KING CANOPY HERCULES EXPRESS Manual de usuario

10’X20’ HERCULES EXPRESS 8 LEG

ITEM #: C281020PTCLT

Dimensions:

10ft. 8in. Wide x 20ft. Deep x 6ft. 8in. Side Height / 9ft. 9in. Center Height

WARNING:

Keep all ame and heat sources

away from this tent fabric. Meets

the ammability requirements of

CPAI-84 Sec. 6 & NFPA 701 It is

not re proof The fabric will burn

if left in continuous contact with

any ame source.

Distributed by: PIC America, LTD.

8009 Purfoy Road • Fuquay-Varina, NC 27526

1-800-800-6296 • www.kingcanopy.com

www.northlineexpress.com

1-877-734-2458

6X6PC 9 pc 78” Powder Coated Pipe

6X6-2PC 8 pc 78” - 2” Powder Coated Pipe

5X8PC 8 pc 68” Powder Coated Pipe

3WPC 6 pc 3-way Connectors

4WPC 6 pc 4-way Connectors

BALL50W 50 pc Elastic Ball Straps

PFOOT2 8 pc 2” Plastic Foot Pads

PTCL1020TW 1 pc Tan & White Fitted Cover

PTCL1020VS 4 pc Valance Straps

PSLEEVE 8 pc Plastic Sleeve Inserts for Legs

6X6PC

5X8PC

3WPC

4WPC

PFOOT2

PSLEEVE

PTCL1020TW

BALLW

PARTS

6X6-2PC

PTCL1020VS

Packed inside the

6X6-2PC Pipe

Packed inside the

6X6-2PC Pipe

www.northlineexpress.com

1-877-734-2458

FRAME ASSEMBLY

Start by laying out all of the parts and pieces to your King Canopy. Please refer to the

parts list to ensure that your kit is complete. When all the parts have been accounted

for, begin to layout the perimeter of your frame according to the photo above (6X6PC &

5X8PC). Each 3-way tting (3WPC) should be placed at all four corners and two end peaks.

The 4-Way ttings (4WPC) are placed at the center leg and roof sections. The 6X6-2PC Pipes

are used for the legs.

5X8PC 5X8PC

3WPC 3WPC

3WPC 3WPC 3WPC

6X6-2PC 4WPC

2) Now that all the pipe and ttings are

laid out as displayed in the photo, begin

to connect the center pipe and ttings.

Start assembly by working from one end

to the other, connecting the center ridge

pipe into the 3-Way (3WPC) and 4-Way

(4WPC) ttings.

3) Once the center frame work is fully

connected start assembling the left and

right sections of the frame. Starting at

one end, begin to connect the 5X8PC

pipe to the assembled center ridge. Next

connect thecorner3-Way&4-Wayttings

to the perimeter 6X6PC pipe.

6X6PC

3WPC

6X6PC

6X6-2PC

6X6-2PC 6X6-2PC

6X6PC

5X8PC 5X8PC

4WPC

6X6PC

4WPC

www.northlineexpress.com

1-877-734-2458

4) Once one side is complete, move to

the opposite side of the unassembled

frame lifting the frame and connecting

the remaining 5X8PC pipe. Continue

previous steps until all pipe and ttings

are connected.

5) Now that the roof frame work is

complete, you can begin to attach the

tted cover. Start by laying out the cover

to determine which way it is folded, the

length or width or the frame.

6) Grab each end and drape the cover

over the frame centering the cover to

the roof frame work.

7) Starting at opposite corners, attach

the cover with the elastic ball straps by

inserting the elastic cord of the ball strap

underneath the cover and through the

grommet. Then pull taught until the ball

stops.

FRAME & ATTACHING COVER

Width

Length

www.northlineexpress.com

1-877-734-2458

8) Wrap the cord around the pole and

secure around the ball.

9) Be sure all four corners are attached

before attaching the remaining ball

straps.

10) Continue attaching straps from left

to right in a zig zag pattern starting at

the two center peaks.

11) Next continue attaching the straps

down each side and end. Make sure the

cover stays centered on the frame.

ATTACHING COVER

www.northlineexpress.com

1-877-734-2458

12) Now that all the ball straps are

attached. Insert the 6X6-2PC leg pipe

into each plastic foot pad and then insert

a plastic sleeve into the other end of the

leg pipe.

13) Begin to attach the legs to the frame.

Place each leg next to the three and four

way ttings. Starting with the two outside

legs grab the base of the 3-way corner

tting. Lift the frame and insert the open

3-Way tting into the leg. Next insert the

center legs.

15) Repeat step on other side until the

entire unit is standing upright.

15) Pull down and attach the leg skirt

straps to the foot pads at each corner.

Next attach the valance straps by clipping

the plastic hook to the open grommet

hole located on the cover’s valance

(4 total). Hook the plastic ring around the

foot pad and tighten.

LEG ASSEMBLY

Insert First

Insert Second

www.northlineexpress.com

1-877-734-2458

COVER ADJUSTMENT

16) Secure the hook and loop straps

on the cover at all 4 corners around the

corner 3-way ttings.

17) Lastly, secure the hook and loop

straps on the corner leg skirts around the

legs.

attach

hook

& loop

at all 4

corners

This canopy is designed for use as a temporary structure. After assembly, the canopy

MUSTBE securely anchored tothe ground to preventdamagefrom winds. Your canopy

will act like a kite in the wind if not properly and securely anchored to the ground. Severe

winds will cause the frame to twist and unanchored legs will fall, thereby collapsing the

canopy. If severe winds are expected, you must remove the cover from the frame to

prevent damage. Please follow the anchoring instructions found in the optional anchor

kit available for purchase separately.

www.northlineexpress.com

1-877-734-2458

We are condent that you will be completely satised with your King Canopy unit. Please take a moment

to read the very important information below, and call us with any questions you may have.

King Canopy/PIC America, LTD. has no control over wind, snow, ice, rain or any other weather condition and

we are in no way responsible for any damage caused by the canopy or to the canopy. We suggest you contact

your insurance carrier just as you would for any other outside structure.

OTHER PRECAUTIONS WHICH MUST BE FOLLOWED:

Keep all ame and heat sources away from this tent fabric. The tent fabric will burn if left in continuous

contact with any ame source.

DO NOT cook underneath or near canopy.

DO NOT store or use ammable liquids underneath or near canopy.

DO NOT ignite or store reworks underneath or near canopy.

DO NOT use bleach to clean cover.

DO NOT dry clean cover.

DO NOT wash cover in washing machine or dry in dryer. Hand wash with mild soap and water only.

DO NOT allow rain water, snow or ice to accumulate on top of cover.

DO NOT hang or suspend anything from the frame, grommets, truss system or ball straps of the unit.

REMOVE canopy cover before a storm, or disassemble entire canopy unit if possible.

REMOVE rain water, snow and ice from canopy cover.

This is a temporary structure and is not recommended for use as a permanent structure.

IMPORTANT NOTICE: PLEASE READ CAREFULLY

www.northlineexpress.com

1-877-734-2458

WARRANTY INFORMATION

Defective Parts

We try our best to eliminate any defective parts that are shipped with our products. If, however, you should nd

a defective part, we will replace – free of charge – any part which is defective. You will need to provide proof

of purchase showing date of purchase and provide us with detailed description of the defective component.

Your replacement will be shipped by ground shipping, freight prepaid. Next day or express shipping will

require freight collect and paid for by you, the consumer. Damages from improper anchoring, strong winds,

snow, ice or rain are not considered defects.

Improper Anchoring, Strong Winds, Rain Snow, or Ice

King Canopy/PIC America, LTD. does not guarantee these canopies under strong weather conditions. These

canopies are designed to protect against damages caused by sun, rain, tree sap, birds, etc. They are not designed

to hold roof loads that accompany snow, ice or heavy rains. If your canopy is not anchored securely, it can be

lifted by the wind and will y away. If your canopy takes ight, we are not responsible for any replacement. If

you know strong weather is predicted, remove the cover or take down the canopy unit completely. The cover

is designed to be quickly and easily removed.

Warranty

All components of this canopy feature a 1-year limited warranty and are warranted to be free from defects in

material and workmanship for a period of 1-year. You must complete and return the enclosed warranty card

promptly after purchase. Please retain your proof of purchase receipt; you will be asked to provide this receipt

in order to obtain warranty service.

Non-Warranty Replacement Parts

If after expiration of the warranty period, you require replacement parts please contact us at 1-800-800-6296.

We stock replacement parts and make them available to you at discounted prices. Our customer service

department will be pleased to assist you in any way possible.

Certain regions of the country are extremely hard on covers of any kind. Normal wear and tear is not covered

under the warranty, and should be expected.

In order to receive a discounted or free replacement part, you may be asked to return the part, freight prepaid,

to our warehouse for inspection before we will send a replacement. You must, in all cases, provide a copy of

your receipt showing the date of purchase, model number and price.

www.northlineexpress.com

1-877-734-2458

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Carpa de KING CANOPY

KING CANOPY

KING CANOPY Atlas AT1227S Manual de usuario

KING CANOPY

KING CANOPY GP1010 Manual de usuario

KING CANOPY

KING CANOPY Universal 10ft X 13ft Manual de usuario

KING CANOPY

KING CANOPY GC1020BK-CB Manual de usuario

KING CANOPY

KING CANOPY Enclosed Universal BJ2PC Manual de usuario

KING CANOPY

KING CANOPY StorGuardII SG1327S-GV Manual de usuario

KING CANOPY

KING CANOPY Sunshield C81220PC3W Manual de usuario

KING CANOPY

KING CANOPY Garden Party 10ft X 10ft Manual de usuario

KING CANOPY

KING CANOPY Hercules HC1027PC Manual de usuario

KING CANOPY

KING CANOPY GOLIATH Manual

KING CANOPY

KING CANOPY StorGuardII SG1324S-GV Manual de usuario

KING CANOPY

KING CANOPY Hercules HC1827PC Manual de usuario

KING CANOPY

KING CANOPY CSR1020BK Manual de usuario

KING CANOPY

KING CANOPY Hercules HC1820PC Manual de usuario

KING CANOPY

KING CANOPY Hercules HC1020PCSL Manual de usuario

KING CANOPY

KING CANOPY G0712 Manual de usuario

KING CANOPY

KING CANOPY Universal C61020PC Manual de usuario

KING CANOPY

KING CANOPY G10208 Manual de usuario

KING CANOPY

KING CANOPY Universal C81220PC Manual de usuario

KING CANOPY

KING CANOPY Event Tent 20ft x 20ft Manual de usuario

KING CANOPY

KING CANOPY Garden Party 13ft X 13ft Manual de usuario

KING CANOPY

KING CANOPY Universal 10ft X 27ft Manual de usuario

KING CANOPY

KING CANOPY GP1010 Manual de usuario

KING CANOPY

KING CANOPY Universal 12ft X 20ft Manual de usuario

Manuales populares de Carpa de otras marcas

OZTENT

OZTENT JV SIGNATURE EDITION Manual de usuario

GigaTent

GigaTent Summer Chalet Mini Tent Manual de usuario

Coleman

Coleman 2000007827 Manual

ShelterLogic

ShelterLogic 107153 Manual de usuario

Outsunny

Outsunny 84C-230 Manual de usuario

Napier

Napier SPORTZ COVE 61 Series Manual de usuario

EuroTrail

EuroTrail ATLANTIS PRO Manual de usuario

Reimo

Reimo Marina Manual de usuario

TiiTENT

TiiTENT TB300 Manual de usuario

Coleman

Coleman 2000033134 Guía de instalación

Ozark Trail

Ozark Trail W784.1 Guía de inicio rápido

SlingFin

SlingFin CrossBow 2 Manual de usuario

Coleman

Coleman 9600-141 Manual de usuario

Palram

Palram Arizona 5000 Wave - WINGS Manual de usuario

COVERPRO

COVERPRO 56184 Instrucciones de montaje

Vango

Vango Zenith 100 Manual de usuario

Costway

Costway PATIOJOY OP70818 Manual de usuario

Clarke

Clarke PUC 88 Manual de usuario