JABSCO 23920-9503 Manual de usuario

RUN DRY

UTILITY PUPPIES

MODELS:

23920-9403 / 9503 12 / 24V RUN DRY UTILITY PUPPY

23920-9213 / 9313 12 / 24V RUN DRY UTILITY PUPPY

FEATURES:

Continuous rated, heavy duty, dry running pumps for

bilge, deckwash and general purpose use.

lMeets USCG Regulation 183.410 and ISO 8846

MARINE (Ignition protection).

lISO 8849 MARINE (Bilge pump standard).

lBilge debris present no problem to these

bronze bodied, flexible impeller pumps.

lSimple design means fewer wearing

parts.

Run Dry Utility Puppy 23920-9403 / 9503

l390 gph output.

lTwenty minutes dry running (after initial prime).

lSelf priming to 4 ft.

Run Dry Utility Puppy 23920-9212 / 9313

l612 gph output.

lTen minutes dry running (after initial prime).

lSelf priming to 8 ft.

lLong life mechanical seal.

INSTALLATION INSTRUCTIONS:

Jabsco Utility Puppies can be mounted on any flat surface.

Fit the pump in a dry, well ventilated position where there

is full access for service. If installed in a vertical position

the motor must be above the pump head. Use the rubber

grommets provided to minimise vibration, do not

overtighten the mounting screws.

¾” NPT threaded fittings should be used to connect 1” i.d.

suction and discharge hoses. Secure the hose to the

fittings with stainless steel hose clamps. Use spiral

reinforced hose (with a smooth internal bore) that will not

collapse under suction, or rigid or semi rigid pipework

systems. The pipework must be compatible with the liquid

being pumped. Pipe runs should be kept as straight and

short as possible, avoiding rising and dipping over

obstructions. Fit an inlet strainer on the inlet hose to

prevent blockage.

WIRING INSTRUCTIONS

Make all electrical connections in dry locations,

connections in humid environments should be sealed to

prevent corrosion. Protect the circuit with a correctly sized

fuse or circuit breaker in the positive (+) lead as close as

possible to the power source. Select the correct cable size

from the chart below. Inadequate voltage at the motor

terminals when the pump is running (not less than 10%

below rated voltage at full load) due to partially discharged

batteries or insufficient cable size may result in blowing

fuses, failure to start or poor pump performance.

Connect the black motor wire to the negative (-) battery

terminal. The red wire should run via a suitably rated

switch or circuit breaker to the positive (+) battery terminal.

WARNING: If the fuse fails repeatedly do not

fit a heavier fuse or bridge the fuse terminals

with silver paper or metal wire. Failure to

observe this instruction may result in a fire

hazard due to overheating of cables.

WARNING: All marine pumps discharging

overboard must be installed with the over-

board discharge well above both static and

heeled waterlines.

gpm

9.6

9.3

6.6

ftH²O

gpm

RUN DRY UTILITY PUPPY PERFORMANCE

Approximate performance for new pump,

pumping water at 20°c, with fully charged battery

Total Manomateric

Head

23920-9213

23920-9313

23920-9403

23920-9503

3.5

13.2

12.6

10.8

6.6

Model No. Voltage Amp Draw

Max.

Fuse Size

Min. Wire

Size AWG

Max. Length of wire between

(+) & (-) battery terminals

23920-9213 12V 21 amp 25 amp

up to 20ft

over 20 ft

23920-9313 24V 11 amp 15 amp

up to 20ft

over 20 ft

23920-9403 12V 13 amp 15 amp 14 15ft

23920-9503 24V 7.5 amp 10 amp 14 15ft

ELECTRICAL WIRING INFORMATION

QTY PART NUMBER QTY PART NUMBER

1 End Cover Screws 4 X3001-147F 4 X3001-147F

2 End Cover 1 23825-0000 1 23825-0000

3 End Cover Seal 1 X4020-257A 1 X4020-257A

4 Impeller - Nitrile 1 7273-0003 1 6303-0003

5 Cam 1 53023-0000 1 53023-0100

6 Cam Screw 1 X3002-147F 1 X3002-147F

6a Cam Screw Seal 1 X4020-105A 1 X4020-105A

7 Pump Body 1 53024-9000 1 53024-9100

8 Slinger 1 6342 1 6342

9 Motor 1 1

Standard Impeller 12V SP8012-0261 SP8012-0165

Standard Impeller 24V SP8012-0262 SP8012-0166

Mechanical Water Seal 1 SP8012-0301B

Lip Type Water Seal 1 SP2701-52

11 Pump Motor Screws 2X3001-147F 2X3001-147F

DESCRIPTION

KEY

RUN DRY UTILITY PUPPY PARTS

23920-9213 / -9313

23920-9403 / -9503

EXPLODED VIEW & PARTS LIST

Weight: 23920-9403 / 9503 7lb

23920-9213 / 9313 10lb

Warranty: All products of the company are sold and all services of the company are offered subject to the company’s warranty and terms and conditions of sale, copies of which will be furnished upon request.

Jabsco

ITT Industries

Jabsco, 20 Icon, Foothill Ranch, CA 92610

Tel : +1 949 609 5106 Fax : +1 949 859 1153

Jabsco, Bingley Road, Hoddesdon, Hertfordshire, EN11 0BU

Tel : +44 (0) 1992 450 145 Fax : +44 (0) 1992 467 132

Fluid Products Canada,55 Royal Road, Guelph, Ontario N1H 1T1

Tel : +1 519 821 1900 Fax : +1 519 821 5316

NHK Jabsco Co Ltd,3-21-10, Shin - Yokohama, Kohoku-ku, Yokohama 222

Tel : +81 (0) 45 475 8906 Fax : +81 (0) 45 475 8908

Jabsco GmbH,Oststraße 28, 22844 Norderstedt

Tel : +49 (0) 40 53 53 73 0 Fax : +49 (0) 40 53 53 73 11

USA

CANADA

JAPAN

GERMANY

www.jabsco.com

Este manual sirve para los siguientes modelos

Otros manuales de Bomba de agua de JABSCO

JABSCO

JABSCO 18690-0000 Manual de usuario

JABSCO

JABSCO 30560-0 Series Manual de usuario

JABSCO

JABSCO 29200-0120 Manual de usuario

JABSCO

JABSCO 18400-0050 Manual de usuario

JABSCO

JABSCO 37202-Series Manual de usuario

JABSCO

JABSCO 18490-0000 Manual de operación

JABSCO

JABSCO 30580 Series Manual de usuario

JABSCO

JABSCO 11860 Series Manual de usuario

JABSCO

JABSCO 52520-1000 Manual de usuario

JABSCO

JABSCO 5850-0001 Manual de usuario

JABSCO

JABSCO 30520-4 Series Manual de usuario

JABSCO

JABSCO 12490 Series Manual de usuario

JABSCO

JABSCO CENTRI PUPPY 18510-000 Series Manual de usuario

JABSCO

JABSCO 22060-7125-C Manual de usuario

JABSCO

JABSCO 59510-Series Manual de usuario

JABSCO

JABSCO 30510-3 Series Manual de usuario

JABSCO

JABSCO 50840 Series Manual de usuario

JABSCO

JABSCO 30580-0 Series Manual de usuario

JABSCO

JABSCO VR050-2022 Manual de usuario

JABSCO

JABSCO 31295 Series Manual de usuario

JABSCO

JABSCO HD Series Manual de usuario

JABSCO

JABSCO 30510-0 Series Manual de usuario

JABSCO

JABSCO 37202-2 Manual de usuario

JABSCO

JABSCO 5850-0001 Manual de usuario

Manuales populares de Bomba de agua de otras marcas

Neptun

Neptun NPHW 5500 Manual de usuario

Sensidyne

Sensidyne Gilian BDX-II Instrucciones de instalación y funcionamiento

Draper

Draper 47808 Manual de usuario

Trolla

Trolla 12820 Manual de usuario

Sunfab

Sunfab SVH Series Manual de usuario

WilTec

WilTec 50740 Manual de usuario

Fieldmann

Fieldmann FVC 5015 EK Manual de usuario

Everbilt

Everbilt EFSUB5-122HD Manual de usuario

Graco

Graco Husky 3300e Manual de usuario

esotec

esotec 101018 Manual de usuario

moyno

moyno 2000 CC Manual de usuario

Becker

Becker BASIC VASF 2.80/1-0.AC230 Manual de usuario

Sykes AmeriPumps

Sykes AmeriPumps GP100M Guía de solución de problemas

DUROMAX

DUROMAX XP WX Series Manual de usuario

BRINKMANN PUMPS

BRINKMANN PUMPS SBF550 Manual de usuario

Franklin Electric

Franklin Electric IPS Manual de usuario

Xylem

Xylem e-1532 Series Manual de usuario

Milton Roy

Milton Roy PRIMEROYAL Manual de usuario