JABSCO 23230-2012 Manual de usuario

MODELS:

23230-2012 12 Volts DC

23230-2024 24 Volts DC

GEAR PUPPY

FEATURES:

Medium duty pumps for general purpose

use.

lISO 8846 MARINE (Ignition protection)

lMaximum viscosity 150Cs

lInlet filter included

lSimple design means fewer wearing

parts

l24.5 lpm (6.5 US gpm) output @ 5m (16.4ft)

head

lSelf priming to 1.0m (3 ft)

lIdeal for water, oil and diesel transfer

INSTALLATION INSTRUCTIONS:

Jabsco Gear Puppy can be mounted on any flat

surface. Fit the pump in a dry, well ventilated

position. If installed in a vertical position the motor

must be above the pump head. Use the rubber

grommets provided to minimise vibration, do not

overtighten the mounting screws.

Secure 16mm (5/8”) id hose direct to the discharge

ports using stainless steel hose clamps. Use spiral

reinforced hose (with a smooth internal bore) that will

not collapse under suction, or rigid or semi rigid

pipework systems. The pipework must be compatible

with the liquid being pumped. Pipe runs should be

kept as straight and short as possible, avoiding rising

and dipping over obstructions. Fit a filter on the inlet

to prevent debris from entering the pump.

WIRING INSTRUCTIONS

Make all electrical connections in dry locations,

connections in humid environments should be sealed

to prevent corrosion. Protect the circuit with a

correctly rated fuse or circuit breaker in the red

positive (+) lead as close as possible to the power

source. Connect the black motor wire to the negative

(-) battery terminal. Inadequate voltage at the motor

terminals when the pump is running (not less than

10% below rated voltage at full load) due to partially

discharged batteries or insufficient cable size may

result in blowing fuses, failure to start or poor pump

performance.

WARNING: If the fuse fails

repeatedly do not fit a heavier fuse or

bridge the fuse terminals with silver

paper or metal wire. Failure to observe

this instruction may result in a fire

hazard due to overheating of cables.

WARNING: All marine pumps

discharging overboard must be

installed with the overboard discharge

well above both static and heeled

waterlines.

m ft lpm US gpm

0 0 26 6.9

5 16.4 24.5 6.5

10 33 22.5 6.0

15 49 20 5.3

20 65 17 4.5

GEAR PUPPY PERFORMANCE

Approximate performance for new pump,

running water at 20°C with fully charged battery

TOTAL HEAD

GEAR PUPPY

WARNING: Do not use any Jabsco

pump for petrol, petroleum products or

any products with a flash point below

37°C (98°F), explosion or death may

occur.

PART

NUMBERS

VOLTAGE

MAXIMUM

AMP

DRAW

MAXIMUM

FUSE

SIZE

MINIMUM WIRE

SIZE

MAXIMUM LENGTH

BETWEEN (+) & (-)

BATTERY TERMINALS

23230-2012 12 volt 12 amp 15 amp

30 / 0.25mm

(1.5mm²)

4.5m (15ft) *

23230-2024 24 volt 5 amp 7.5 amp

32 / 0.2mm

(1.0mm²)

4.5m (15ft) *

Electrical Wiring Information

DIMENSIONAL DRAWING

WEIGHT: Gear Puppy - 2.2kg (4.8lb)

Warranty: All products of the company are sold and all services of the company are offered subject to the company’s warranty and terms and conditions of sale, copies of which will be furnished upon request.

Jabsco

ITT Industries

Jabsco, 1 Kondelin Road, Cape Ann Industrial Park, Gloucester, MA 01930

Tel : +1 978 281 0440 Fax : +1 978 283 2619

Jabsco, Bingley Road, Hoddesdon, Hertfordshire, EN11 0BU

Tel : +44 (0) 1992 450 145 Fax : +44 (0) 1992 467 132

Fluid Products Canada,55 Royal Road, Guelph, Ontario N1H 1T1

Tel : +1 519 821 1900 Fax : +1 519 821 5316

NHK Jabsco Co Ltd,3-21-10, Shin - Yokohama, Kohoku-ku, Yokohama 222

Tel : +81 (0) 45 475 8906 Fax : +81 (0) 45 475 8908

Jabsco GmbH,Oststraße 28, 22844 Norderstedt

Tel : +49 (0) 40 53 53 73 0 Fax : +49 (0) 40 53 53 73 11

USA

CANADA

JAPAN

GERMANY

Discover Jabsco at www.jabsco.com

* For longer installations, fit thicker cables

All dimensions are in mm

Rev 10/03 43000-0796

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Bomba de agua de JABSCO

JABSCO

JABSCO 777 Series Manual de usuario

JABSCO

JABSCO 30520-0001 Manual de usuario

JABSCO

JABSCO HD Series Manual de usuario

JABSCO

JABSCO 2620 Series Manual de usuario

JABSCO

JABSCO Puppy 12560-0001 Manual de usuario

JABSCO

JABSCO 1285O SERIES Manual de usuario

JABSCO

JABSCO 12490 Series Manual de usuario

JABSCO

JABSCO 30510-0 Series Manual de usuario

JABSCO

JABSCO 1673-Series Manual de usuario

JABSCO

JABSCO 59510-Series Manual de usuario

JABSCO

JABSCO 30910-0000 Manual de usuario

JABSCO

JABSCO 50840 Series Manual de usuario

JABSCO

JABSCO 28 Series Manual de usuario

JABSCO

JABSCO 30510-1003 Manual de usuario

JABSCO

JABSCO 30520-1001 Manual de usuario

JABSCO

JABSCO 50270 Series Instrucciones de funcionamiento

JABSCO

JABSCO 30570-0 Series Manual de usuario

JABSCO

JABSCO 37202-Series Manual de usuario

JABSCO

JABSCO 36680-2 Series Manual de usuario

JABSCO

JABSCO 17860 Series Manual de usuario

JABSCO

JABSCO 37202-2 Manual de usuario

JABSCO

JABSCO 30550-0 Series Manual de usuario

JABSCO

JABSCO 30520-5 Series Manual de usuario

JABSCO

JABSCO 32605 Series Manual de usuario

Manuales populares de Bomba de agua de otras marcas

Neptun

Neptun NPHW 5500 Manual de usuario

Sensidyne

Sensidyne Gilian BDX-II Instrucciones de instalación y funcionamiento

Draper

Draper 47808 Manual de usuario

Trolla

Trolla 12820 Manual de usuario

Sunfab

Sunfab SVH Series Manual de usuario

WilTec

WilTec 50740 Manual de usuario

Fieldmann

Fieldmann FVC 5015 EK Manual de usuario

Everbilt

Everbilt EFSUB5-122HD Manual de usuario

Graco

Graco Husky 3300e Manual de usuario

esotec

esotec 101018 Manual de usuario

moyno

moyno 2000 CC Manual de usuario

Becker

Becker BASIC VASF 2.80/1-0.AC230 Manual de usuario

Sykes AmeriPumps

Sykes AmeriPumps GP100M Guía de solución de problemas

DUROMAX

DUROMAX XP WX Series Manual de usuario

BRINKMANN PUMPS

BRINKMANN PUMPS SBF550 Manual de usuario

Franklin Electric

Franklin Electric IPS Manual de usuario

Xylem

Xylem e-1532 Series Manual de usuario

Milton Roy

Milton Roy PRIMEROYAL Manual de usuario