Generac Power Systems MMG35FH Manual de usuario

Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 ww.m-p-llc.com Page 1 of 5

4/12

Mobile Generator – MMG35FH Specifications

ENGINE

John Deere®PE4024TF281 - turbocharged, diesel engine

oPrime - 43 hp @ 1800 rpm

oStandby - 48 hp @ 1800 rpm

o4 cylinder

o2.4 L displacement

oTier IV Interim approved

Steel, single wall fuel tank

o106 gal. capacity

o95 useable gallons

o36.9 hr. run time – full load

oFuel tank built into skid of generator set

Fuel consumption at prime:

o100% - 2.6 gph (9.8 Lph)

o75% - 2.0 gph (7.6 Lph)

o50% - 1.3 gph (4.9 Lph)

Cooling system capable of operating at 120°F ambient

Low coolant shutdown

Radiator and oil drains plumbed to exterior

Rubber vibration dampers isolate engine/generator from frame

Disposable air filter - paper element

Air filter restriction indicator mounted on control panel

60 Hz engine/generator

Electronic isochronous governing

GENERATOR

Marathon Electric®

oBrushless

o4 pole

oClass H insulation

Voltage regulation +/- 1% with Marathon SE350 Voltage Regulator

SYSTEM OUTPUT

3 position selector switch

oSingle phase – 120 / 240V Zig Zag

oThree phase – 120 / 208V Low Wye

oThree phase – 277 / 480V High Wye

26 kW / 26 kVA – standby, single phase

25 kW / 25 kVA – prime, single phase

29 kW / 36 kVA – standby, three phase

26 kW / 33 kVA – prime, three phase

SYSTEM CONTROLS

Microprocessor-based controller

oBacklit, 128x64 pixel resolution display

o-40°F to 185°F operating temperature range

oThermostatically controlled LCD heater

www m-p-llc com

Trailer sold separately

MMG35FH Generac Specifications Continued:

Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 2 of 5

4/12

oSix LED indicators w/ lamp test

Alarm / Fault (Red)

Ready / Manual (Red)

Running (Green)

Warning (Yellow)

Ready / Auto (Green)

Supplying Load (Green)

Push buttons for easy operation

oManual or Auto Start

oEngine Start or Stop

oAlarm Cancel & Fault Reset

oScrolling Arrows for Diagnostic Information

System kW output display

Line output & frequency display

Engine diagnostic display

Oil pressure

Engine temperature

Fuel level

Battery

System hours

Running hours

kW hours

Time to service

oAlarm list – warnings / shutdowns are date & time stamped

Fuel level: warning – 15%; shutdown – 5%

Overspeed protection: shutdown – 115%

Oil pressure: warning – 25 psi; shutdown – 20 psi

Coolant temperature: warning – 220°F; shutdown – 230°F

Battery voltage: over – 15VDC; under – 11VDC

Generator over voltage: warning – 110%; shutdown – 111%

Generator under voltage: warning – 87%; shutdown – 86%

Generator over frequency: warning – 105%; shutdown – 110%

Generator under frequency: warning – 95%; shutdown – 90%

Over current shutdown

ELECTRICAL CONTROLS

Remote start / stop contacts located next to lug box

Lockable control box door with diagnostics window

Lockable lug box with safety switch

oTrips main breaker when lug door is opened

oDisables voltage regulator

Cable entry guides to the lug box

oRestricts access of foreign objects

Output ground connection lug inside lug box

125A main breaker with shunt trip

Convenience receptacles with individual breakers (restricted use in high wye mode)

o(2) 120V 20 Amp GFCI duplex outlets (Nema 5-20R type)

o(2) 125 / 250V 50 Amp, 3 pole, 4 wire twistlock (Non-Nema 6369)

Panel mounted rheostat for voltage adjustment - +/- 10%

720 CCA wet cell battery

MMG35FH Generac Specifications Continued:

Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 3 of 5

4/12

ENCLOSURE

Generac Mobile Power decals

“Flip-Hood” Patented design - aluminum, sound attenuated enclosure

oEasy access for daily maintenance

oCentralized location for all electrical connections/wiring

oUV & fade resistant, high temperature cured, white polyester powder paint

oInsulated and baffled

o68 dB(A) at 23 feet – prime power

Fully lockable enclosure including doors and fuel fill

Stainless steel hinges on doors

Emergency stop switch located on outside of enclosure

Central lifting point

Multi-lingual operating/safety decals

Document holder with operating manual including AC/DC wiring diagrams

TRAILER

“Flip-Tongue” design

DOT approved tail, side, brake, and directional lights

oRecessed rear lights

Transportation tie downs

Safety chains with spring loaded safety hooks

2” ball hitch

3500 lb. axle

3000 lb. tongue jack with footplate

P205/75R15 tubeless tires – 6 ply

WEIGHTS & DIMENSIONS

Skid mounted

Dry weight: 2020 lbs (996 kg)

Operating weight: 2475 lbs (1206 kg)

95 x 35 x 52 in

(2.41 x 0.89 x 1.32 m)

Trailer mounted

Dry weight: 2540 lbs

(1167 kg)

Operating weight: 2990 lbs

(1377 kg)

150 x 57 x 67 in

(3.81 x 1.45 x 1.70 m)

WARRANTY

Engine and generator covered under OEM warranty – consult factory for details.

CERTIFICATIONS

CSA certified

MMG35FH Generac Specifications Continued:

Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 4 of 5

4/12

MMG35FH Options

ENGINE OPTIONS

In-line engine block heater (Kim Hotstart)

Fuel transfer pump

ELECTRICAL CONTROLS OPTIONS

720 CCA gel cell battery

Battery disconnect

Battery charger – 2A trickle

GENERATOR OPTIONS

PMG Generator - critical grade power quality

Super Start Generator - motor starting applications

VOLTAGE OUTPUT OPTIONS

4 position phase switch

Single phase – 120 / 240V Zig Zag

Three phase – 120 / 208V Low Wye

Three phase – 277 / 480V High Wye

Three phase – 120 / 240V Delta

Dedicated voltage configurations

Buck Transformer kit – Provides 120V at GFCI outlets when in 277/480V

Cam locks

SYSTEM CONTROLS OPTIONS

Analog gauges

Auxiliary strobe/audible indication for soft & hard alarm conditions

COOLANT OPTIONS

60/40 Coolant - cold weather applications

ENCLOSURE OPTIONS

Fire extinguisher

Interior cabinet light

Control panel light

FUEL TANK OPTIONS

120% Containment

MMG35FH Generac Specifications Continued:

Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 5 of 5

4/12

TRAILER OPTIONS

Single axle trailer w/ surge brakes

Single axle trailer w/ electric brakes

Tandem axle trailer w/ surge brakes

Tandem axle trailer w/ electric brakes

6 pin or 7 spade electrical connectors

Spare tire/wheel kit

HITCH OPTIONS

3” lunette ring

2 5/16” ball

Adjustable height options:

2” ball

2 5/16” ball

Tabla de contenidos

Otros manuales de Inversor de Generac Power Systems

Generac Power Systems

Generac Power Systems MD1000GEM Guía de instalación

Generac Power Systems

Generac Power Systems MMG480DI4 Manual de usuario

Generac Power Systems

Generac Power Systems 10 kW LP Instrucciones de funcionamiento

Generac Power Systems

Generac Power Systems 15 kW EcoGen Hoja de instrucciones

Generac Power Systems

Generac Power Systems ECOGEN SERIES Hoja de instrucciones

Generac Power Systems

Generac Power Systems SG010 Manual de usuario

Generac Power Systems

Generac Power Systems 005040-0, 005040-1, 005053-0, 005053-1, 005054-0,... Manual de usuario

Generac Power Systems

Generac Power Systems 20 kW Synergy Manual de usuario

Generac Power Systems

Generac Power Systems Guardian 004988-1 Manual de usuario

Generac Power Systems

Generac Power Systems 005342-6 Manual de usuario

Generac Power Systems

Generac Power Systems 37kW NG Manual de usuario

Generac Power Systems

Generac Power Systems 004701-0 Manual de usuario

Generac Power Systems

Generac Power Systems 0661-5 Instrucciones de instalación

Generac Power Systems

Generac Power Systems 004912-0, 004912-1, 004913-0, Manual de usuario

Generac Power Systems

Generac Power Systems 006180-0 Manual de usuario

Generac Power Systems

Generac Power Systems 004702-0, 004703-0, 004704-0, Manual de usuario

Generac Power Systems

Generac Power Systems NP-40G Series Manual de usuario

Generac Power Systems

Generac Power Systems 004702-0, 004703-0, 004704-0, Manual de usuario

Generac Power Systems

Generac Power Systems 004709-0 Manual de usuario

Generac Power Systems

Generac Power Systems 00784-2, 09290-4 Manual de servicio

Generac Power Systems

Generac Power Systems IM Series Manual de usuario

Generac Power Systems

Generac Power Systems PowerPact 7.5 kW Manual de usuario

Generac Power Systems

Generac Power Systems G007144 Manual de usuario

Generac Power Systems

Generac Power Systems Guardian 005324-0 Manual de usuario

Manuales populares de Inversor de otras marcas

Fourgroup

Fourgroup Easy Manual de usuario

Velleman

Velleman PI300M Manual de usuario

Sungrow

Sungrow SG350HX-US Manual de usuario

WilTec

WilTec 61897 Manual de usuario

SMA

SMA SUNNY BOY STORAGE 2.5 Manual de usuario

Simplicity

Simplicity LANDLORD 316 Manual de usuario

Santak

Santak SMAX 3000 Manual de usuario

ATON

ATON RA.Store-3 Manual de usuario

ZIEHL-ABEGG

ZIEHL-ABEGG FXET4AMQ Manual de usuario

Tektronix

Tektronix CFG250 Manual de usuario

Champion

Champion 200989 Manual de usuario

Vanner

Vanner 20-500 Series Manual de usuario

GE GEP Manual de usuario

Astrel Group

Astrel Group Power Reducer Guía rápida

MULTIQUIP

MULTIQUIP GDP-5H Guía

GoWISE

GoWISE PS1007 Manual de usuario

Promate

Promate PM13500D ES Manual de usuario

Mastervolt

Mastervolt WHISPER 3.5M3000 RPM Manual de usuario