Generac Power Systems G007144 Manual de usuario

Owner’s Manual

50 Hz Air-Cooled Generator Sets

8 kVA to 13 kVA

SAVE THIS MANUAL FOR FUTURE REFERENCE

www.activategen.com

1-262-953-5155

This product is not intended

to be used in a critical life

support application.

ISO000209b

Original Instructions

ii Owner’s Manual for 50 Hz Air-Cooled Generator Sets

Use this page to record important information about your generator set.

Record the information found on your unit data label on this

page. See General Information for the location of the unit

data label. The unit has a label plate affixed to the inside

partition, to the left of the control panel console as shown in

Figure 2-1. See Operation for directions on how to open the

top lid and remove the front panel.

When contacting an Independent Authorized Service Dealer

(IASD) about parts and service, always supply the complete

model and serial numbers of the unit.

Operation and Maintenance: Proper maintenance and care

of the generator set ensures a minimum number of problems

and keeps operating expenses at a minimum. It is the

operator’s responsibility to perform all safety checks, to

make sure all maintenance for safe operation is performed

promptly, and to have the equipment checked periodically by

an IASD. Normal maintenance, service, and replacement of

parts are the responsibility of the owner/operator and are not

considered defects in materials or workmanship within the

terms of the warranty. Individual operating habits and usage

may contribute to the need for additional maintenance or

service.

When the generator set requires maintenance or service,

Generac recommends contacting an IASD for assistance.

Authorized service technicians are factory–trained and are

capable of handling maintenance and service needs. To

locate the nearest IASD, visit the dealer locator at:

www.generac.com/Service/DealerLocator/.

Model:

Serial:

Production Date:

Volts:

LPG Amps:

NG Amps:

Hz:

Phase:

Controller P/N:

Owner’s Manual for 50 Hz Air-Cooled Generator Sets iii

Original document - written in English.

EC Declaration of Conformity

Manufacturer: Generac Power Systems, Inc.

S45 W29290 Hwy 59

Waukesha, WI 53189 USA

Generac Power Systems, Inc. hereby declares that the machinery described below fulfils all the relevant provisions of the

Machinery Directive 2006/42/EC. The Machinery also conforms to the relevant provisions of Outdoor Noise Directive

2000/14/EC (as amended by Directive 2005/88/EC) Notified body: SNCH, 2a, Kalchesbruck L – 1852 Luxembourg and

the Electromagnetic Compatibility Directive 2014/30/EU.

Machinery Description: Generator Set

Model Number: Generac Model Numbers; G007144#, G007244#, G007145#, G007245#, G007146#

and G007246# (“#” – 0 to 9 for minor design changes)

The following standards have been complied with in part or in full as relevant:

Machinery Directive 2006/42/EC Harmonised Standards applied:

EN ISO 8528-13:2016 - Reciprocating internal combustion engine driven alternating current generating sets

IEC 60204-1:2010/AC:2010 - Electrical equipment of machines - Part 1: General requirements

ISO 12100:2010 - General principles for design - Risk Assessment and risk reduction, includes EN 14121:2007

Additional standards that have either been referred to or been complied with in part or in full as relevant:

ISO 8528-1:2005 - Reciprocating internal combustion engine driven alternating current generating sets

ISO 8528-5:2013 - Reciprocating internal combustion engine driven alternating current generating sets

IEC 60034-1:2010 - Rotating electrical machines – Part 1: Rating and performance

Harmonised Standards applied for Outdoor Noise Emission Directive 2000/14/EC:

ISO 8528-10:1998 – Reciprocating internal combustion engine driven alternating current generating sets

EN ISO 3744:2010 - Determination of sound power levels and sound energy levels of noise sources using sound pressure

Model number G007144# & G007244#: measured sound power level 94.0 dB(A), guaranteed sound power level 95 dB(A)

Model number G007145# & G007245#: measured sound power level 94.2 dB(A), guaranteed sound power level 95 dB(A)

Model number G007146# & G007246#: measured sound power level 94.8 dB(A), guaranteed sound power level 96 dB(A)

Harmonised Standards applied for Electromagnetic Compatibility Directive 2014/30/EU:

EN 55012:2007+A1:2009 – Vehicles, boats and internal combustion engines – Radio disturbance characteristics

EN 55014-1:2006 – Electromagnetic Compatibility – Requirements for household appliances, electric tools and similar

apparatus. Part 1 - Emission

EN 55014-2:2015 – Electromagnetic compatibility – Requirements for household appliances, electric tools and similar

apparatus. Part 2 - Immunity

EN 61000-3-2:2014 - Electromagnetic compatibility – Part 3-2: Limits – Limits for harmonic current emissions

EN 61000-3-3:2013 - Electromagnetic compatibility – Part 3-3: Limits – Limitation of voltage changes, voltage fluctuations

and flicker in public low-voltage supply systems.

A Technical file has been compiled in accordance with Part A of Annex VII of Machinery Directive 2006/42/EC and is available to the

European National authorities upon request.

Jeffrey Jonas Signature:

Staff Engineer-Certifications

Generac Power Systems, Inc.

S45 W29290 Hwy 59

Waukesha, Wisconsin, USA

This document was made at Generac Power Systems, Inc. at the address noted above on February 15, 2018

iv Owner’s Manual for 50 Hz Air-Cooled Generator Sets

Owner’s Manual for 50 Hz Air-Cooled Generator Sets v

Section 1: Safety Information

Introduction ..........................................................1

Safety Messages ..................................................1

Safety and Informational Decals ........................2

Safety Rules .........................................................5

General Safety ............................................................5

Installation ...................................................................6

Operation .....................................................................7

Maintenance ................................................................7

Hot Surfaces .........................................................9

Section 2: General Information

The Generator Set ..............................................11

Data Decals ........................................................12

Specifications ....................................................13

Generator Set ............................................................13

Engine .......................................................................14

Protection Systems ...........................................14

Emission Information ........................................14

Fuel Requirements ............................................15

Battery Requirements .......................................15

Battery Charger ..................................................15

Engine Oil Requirements ..................................15

Activating the Generator Set ............................15

Wi-Fi Module ......................................................15

Replacement Parts ............................................15

Accessories ........................................................16

Section 3: Operation

Site Prep Verification ........................................17

Generator Set Enclosure .................................. 17

Opening the Lid .........................................................17

Generator Main Line Circuit Breaker ...............17

LED Indicator Lights ..................................................18

Control Panel Interface .....................................18

Using the Control Panel Interface ....................18

Interface Menu Displays ................................... 19

The LCD Panel ..........................................................19

Menu System Navigation ..........................................20

Setting the Exercise Timer ............................... 22

Emergency Stop ................................................22

Operating Modes ...............................................23

Manual .......................................................................23

Auto ...........................................................................23

Exercise .....................................................................23

Manual Transfer Operation ...............................23

Transfer to Generator Set Power Source ..................23

Transfer to Mains Power Source ...............................24

Automatic Transfer Operation .......................... 24

Automatic Sequence of Operation ...................24

Mains (Utility) Power Failure .....................................24

Cranking ....................................................................24

Cold Smart Start ........................................................24

Load Transfer ............................................................25

Shutting Generator Set Down While Under Load

Or During A Mains Power (Utility) Outage ......25

Table of Contents

vi Owner’s Manual for 50 Hz Air-Cooled Generator Sets

Section 4: Maintenance

Maintenance .......................................................27

Prepare Generator Set for Maintenance ..........27

Generator Set Enable/Disable Procedure ................. 27

Enclosure Panel Removal ......................................... 28

Remove Front Access Panel .................................... 28

Remove Intake Side Panel .......................................28

Performing Scheduled Maintenance ................29

Service Schedule ...............................................29

Maintenance Log ...................................................... 30

Checking Engine Oil Level ................................31

Engine Oil Requirements ..................................31

Changing the Oil and Oil Filter .........................31

Servicing the Air Cleaner ..................................32

Spark Plugs ........................................................32

Check and Adjust Valve Clearance ..................33

Check Valve Clearance ............................................ 33

Adjust Valve Clearance ............................................. 34

Battery Maintenance ..........................................34

Cleaning the Sediment Trap .............................36

Attention After Submersion ..............................36

Corrosion Protection .........................................36

Remove From, and Return To Service .............36

Remove From Service .............................................. 36

Return to Service ...................................................... 37

Decommissioning ..............................................37

Section 5: Troubleshooting / Quick

Reference Guide

Generator Set Troubleshooting ........................39

Quick Reference Guide .....................................40

Safety Information

Owner’s Manual for 50 Hz Air-Cooled Generator Sets 1

Section 1: Safety Information

Introduction

Thank you for purchasing this compact, high

performance, air-cooled, engine-driven generator set. It

is designed to automatically supply electrical power to

operate critical loads during a mains (utility) power

failure.

This unit is factory installed in an all-weather, metal

enclosure intended exclusively for outdoor installation.

This generator set will operate using either vapor

withdrawn liquid propane (LPG) or natural gas (NG).

NOTE: This generator set is intended to be used for

supplying typical residential loads such as induction

motors (sump pumps, refrigerators, air conditioners,

furnaces, etc.), electronic components (computer,

monitor, TV, etc.), lighting loads, and microwaves, when

sized properly.

This unit is also equipped with a Wi-Fi® module, which

enables the owner to monitor the generator set status

from anywhere he or she has Internet access.

NOTE: Wi-Fi® is a registered trademark of Wi-Fi

Alliance®.

If any portion of this manual is not understood, contact

the nearest Independent Authorized Service Dealer

(IASD) for starting, operating, and servicing procedures.

This manual must be used in conjunction with the

appropriate installation manual.

NOTE:

SAVE THESE INSTRUCTIONS: The manufacturer

suggests this manual and the rules for safe operation be

copied and posted near the unit installation site. Safety

should be stressed to all operators and potential operators

of this equipment.

The information in this manual is accurate based on

products produced at the time of publication. The

manufacturer reserves the right to make technical

updates, corrections, and product revisions at any time

without notice.

Safety Messages

Throughout this publication and on tags and decals

affixed to the generator set, three types of safety

messages are used to alert personnel to special

instructions about a particular operation that may be

hazardous if performed incorrectly or carelessly. Observe

them carefully. Their definitions are as follows:

These safety messages cannot eliminate the hazards

they indicate. Observing safety precautions and strict

compliance with the special instructions while performing

the action or service are essential to preventing

accidents.

The operator is responsible for proper and safe use of

the equipment. The owner's manual contains important

safety information and instructions that the manufacturer

recommends owners and operators review before using

the equipment. In addition, anyone who may need to

operate the generator set in an emergency outage

situation should be instructed on how to properly start

and operate the unit to be prepared for such an event.

HAZARD WARNING

Yellow triangle with black border and

black symbol; indicates a hazardous

situation which, if not avoided, could

result in death or serious injury.

MANDATORY ACTION

Blue circle with white symbol; indicates

an action required to safeguard personal

health and / or avoid causing a

hazardous situation which could result in

death or serious injury.

PROHIBITION

Red ring with diagonal bar and black

symbol; indicates a prohibited action.

Performing the prohibited action may

cause a hazardous situation which could

result in death or serious injury.

—

NOTE

Notes provide additional information

important to a procedure or component.

Safety Information

2 Owner’s Manual for 50 Hz Air-Cooled Generator Sets

Safety and Informational Decals

This unit is equipped with safety and informational decals

displaying pictorial symbols. These symbols and decals

are described below. Locations are identified in

Figure 1-

Contact an IASD for a replacement if a decal is missing,

damaged, or illegible.

ID Decal Description Meaning

A Oil Drain Oil drain location

B Positive Battery Cable •Electricity is present. Keep positive terminal covered

at all times when connected to battery.

•Read and understand the manual completely before

using this equipment.

•Identifies positive battery cable.

C Negative Battery Cable Identifies negative battery cable

D Fuel Selection Step 1: Unit set for Natural Gas (NG) operation.

Step 2: Press and rotate fuel selector 180° to change

fuel type.

Step 3: Unit set for Liquid Propane (LPG) operation.

NOTE: This decal is intended to be discarded after

installation and need not be replaced if missing.

E Shock Hazard / Read

The Manual

•Live components carrying potentially lethal voltages

may be accessible inside. Render the equipment

safe before attempting further access.

•Read and understand manual completely before

attempting further access.

F Burn Hazard /

Asphyxiation Hazard

•Surface may be hot. Do not touch when operating

equipment. After equipment shutdown, allow

sufficient time for surfaces to cool prior to contact.

•Carbon monoxide, a colorless odorless poisonous

gas, is emitted in engine exhaust while equipment is

running. Avoid inhalation of exhaust gases.

NG LP

LPG

Safety Information

Owner’s Manual for 50 Hz Air-Cooled Generator Sets 3

G Activation •Activate the generator set before putting the unit into

operation.

•Read the manual for details.

H No User Serviceable

Parts

•Electricity is present at various locations inside this

enclosure.

•This equipment is designed for automatic operation

and may start at any time. Render the unit

inoperable before servicing.

•Battery is present. Wear appropriate protective gear.

•This equipment emits exhaust gases. Ensure proper

installation to prevent asphyxiation.

•Do not open the enclosure. There are no user-

serviceable parts inside. Contact an IASD.

•Read and understand the manual completely before

installing or operating this equipment.

•Do not smoke near this equipment.

•Do not allow open flames near this equipment.

J Read Owner’s Manual Read the manual for an explanation of this device.

K Lifting Point Install lifting attachments to this location and only this

location. Do not connect lifting device directly to the lift

point.

L Pinch Point Keep hands clear of these areas when installing the

front panel or closing the roof.

M1 See Data Decals.Model Data Decal Decal Location—8 kVA units

M2 See Data Decals.Model Data Decal Decal Location—10 kVA and 13 kVA units

NSee Data Decals.Fuel Data Decal Decal Location

PSound Power Level Guaranteed sound power level per Directive 2000/14/

EC. See Specifications for actual value.

QThreaded Connection Fuel inlet has a 1/2 in. NPT threaded connection.

WWW.ACTIVATEGEN.COM

12in.

NPT

Safety Information

4 Owner’s Manual for 50 Hz Air-Cooled Generator Sets

Figure 1-1. Safety Decals

005771

Otros manuales para G007144

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Inversor de Generac Power Systems

Generac Power Systems

Generac Power Systems 00862-1 Instrucciones de instalación

Generac Power Systems

Generac Power Systems QT022 Manual de usuario

Generac Power Systems

Generac Power Systems Guardian 004188-1 Manual de usuario

Generac Power Systems

Generac Power Systems 00802-3 Instrucciones de instalación

Generac Power Systems

Generac Power Systems GUARDIAN SERIES Manual de usuario

Generac Power Systems

Generac Power Systems A-2624 Manual de usuario

Generac Power Systems

Generac Power Systems PWRcell XVT076A03 Manual de usuario

Generac Power Systems

Generac Power Systems G0065510 Manual de usuario

Generac Power Systems

Generac Power Systems SD600 Manual de usuario

Generac Power Systems

Generac Power Systems 2.4L Manual de usuario

Generac Power Systems

Generac Power Systems 004709-0 Manual de usuario

Generac Power Systems

Generac Power Systems Magnum Series Manual de usuario

Generac Power Systems

Generac Power Systems GP1200I Manual de usuario

Generac Power Systems

Generac Power Systems MMG120 Manual de usuario

Generac Power Systems

Generac Power Systems 006071-0 Manual de usuario

Generac Power Systems

Generac Power Systems GUARDIAN SERIES 005870-1 Guía de instalación

Generac Power Systems

Generac Power Systems Guardian 005260-1 Manual de usuario

Generac Power Systems

Generac Power Systems GUARDIAN 04136-0 Manual de usuario

Generac Power Systems

Generac Power Systems 9592-3 Manual de usuario

Generac Power Systems

Generac Power Systems MEGA 2500 Manual de usuario

Generac Power Systems

Generac Power Systems Quietsource 004917-3 Manual de usuario

Generac Power Systems

Generac Power Systems 004270-2 Instrucciones de instalación

Generac Power Systems

Generac Power Systems 006180-0 Manual de usuario

Generac Power Systems

Generac Power Systems Centurion 004692-0 Instrucciones de instalación

Manuales populares de Inversor de otras marcas

Fourgroup

Fourgroup Easy Manual de usuario

Velleman

Velleman PI300M Manual de usuario

Sungrow

Sungrow SG350HX-US Manual de usuario

WilTec

WilTec 61897 Manual de usuario

SMA

SMA SUNNY BOY STORAGE 2.5 Manual de usuario

Simplicity

Simplicity LANDLORD 316 Manual de usuario

Santak

Santak SMAX 3000 Manual de usuario

ATON

ATON RA.Store-3 Manual de usuario

ZIEHL-ABEGG

ZIEHL-ABEGG FXET4AMQ Manual de usuario

Tektronix

Tektronix CFG250 Manual de usuario

Champion

Champion 200989 Manual de usuario

Vanner

Vanner 20-500 Series Manual de usuario

GE GEP Manual de usuario

Astrel Group

Astrel Group Power Reducer Guía rápida

MULTIQUIP

MULTIQUIP GDP-5H Guía

GoWISE

GoWISE PS1007 Manual de usuario

Promate

Promate PM13500D ES Manual de usuario

Mastervolt

Mastervolt WHISPER 3.5M3000 RPM Manual de usuario