Front Runner QE Series Manual de usuario

ENG

220 min

Mitsubishi Pajero Sport (QE Series)

Foot Rail

IMPORTANT WARNING!

Don’t be a hero and muscle through this without ﬁrst reading these ﬁtting instructions! Improper installation of this gear may void certain aspects of

your warranty.

Before you begin, take a moment and open all your Front Runner rack kit boxes and gather the assembly instructions for the various components.

A complete kit will contain:

1. A Front Runner Mounting System speciﬁc to your vehicle

2. A Front Runner Rack Tray or Load Bar Slats

This document will guide you through the assembly of the mounting system and assist you in ﬁtting the roof rack tray or load bars to your speciﬁc

vehicle.

Please refer to the next page for a list of all the components, quantities and tools required.

FAMP002

READ ME FIRST

START HERE!

IT IS CRITICAL THAT ALL FRONT RUNNER PRODUCTS BE PROPERLY AND SECURELY ASSEMBLED AND ATTACHED TO YOUR VEHICLE. IMPROPER ATTACHMENT COULD

RESULT IN AN AUTOMOBILE ACCIDENT, AND COULD CAUSE SERIOUS BODILY INJURY OR DEATH. YOU ARE RESPONSIBLE FOR ASSEMBLING AND SECURING ALL FRONT

RUNNER PRODUCTS TO YOUR VEHICLE. CHECKING THE ATTACHMENTS PRIOR TO USE, AND PERIODICALLY INSPECTING THE PRODUCTS FOR ADJUSTMENT, WEAR AND

DAMAGE. THEREFORE YOU MUST READ AND UNDERSTAND ALL OF THE INSTRUCTIONS AND PRECAUTIONS SUPPLIED WITH YOUR FRONT RUNNER PRODUCT PRIOR TO

INSTALLATION OR USE. IF YOU DO NOT UNDERSTAND ALL OF THE INSTRUCTIONS AND CAUTIONS, OR IF YOU HAVE NO MECHANICAL EXPERIENCE AND ARE NOT THOROUGHLY

FAMILIAR WITH THE INSTALLATION PROCEDURES, YOU SHOULD HAVE THE PRODUCT INSTALLED BY A PROFESSIONAL INSTALLER OR OTHER QUALIFIED PERSONNEL.

IN THE BOX

FIGURE 1.1

1 2 X Front Foot Rail; 1xLH, 1xRH

2 2 X Rear Foot Rail; 1xLH, 1xRH

3 2 X Foot Spacer 1

4 2 X Foot Spacer 2

5 2 X Foot Spacer 3

6 2 X Foot Spacer 4

7 2 X Joiner Plate

8 20 X Nut Cap M6

9 12 X M6 x 20 Hex Bolt

10 12 X M6 Spring Washer

11 20 X M6 x 12 x 1 SS Flat Washer

12 10 X M8 x 20 Hex Bolt

13 10 X M8 x 16 x 1.6 SS Flat Washer

IN THE BOX

TOOLS NEEDED

12mm

13mm

4mm

10mm Allen Key

Measuring

Tape

IN THE BOX IN THE BOX

14 10 X M8 Nyloc Nut

15 10 X M8 Nut Cap

16 8 X M6 x 16 Button Head Bolt

17 8 X M6 Nyloc Nut

IN THE BOX IN THE BOX CONTINUED

1RH

2RH

1GET ORGANIZED

Here is what you are looking at for FAMP002

FAMP002_REV_A00

FIT AND SECURE

13mm

2.1

2.2

2.3

Before you start with the ﬁtment of the

foot rails, you need to remove the

factory roof rails. Do this by unclipping

and removing the front and rear

end-caps of the roof rail. In the middle of

the roof rail you will see a small cover

plate, this will also need to be removed.

Now loosen the two bolts in front, one

bolt in the middle and 3 bolts at the rear

of the roof rail.

After you have removed all the bolts,

remove both the roof rails from the

vehicle.

Place a bead of sealant in and over each

hole in the roof, then place the spacers

(items 3, 4, 5 & 6) over front, middle and

two rear holes as shown.

Place the foot rail that you assembled in

step 2.2 on the spacers and loosely

secure it with items 9, 10 & 11 as shown.

Assemble the front and rear foot rail

(items 1 and 2) with the joiner plate

(item 7) and fasteners (items 16, 11, 17

& 8) as shown.

10mm

4mm

12mm

10mm

FRONT OF VEHICLE

Factory Roof Rails

FAMP002_REV_A00

FIT AND SECURE

2.2

2.4

2.1

3.2

3.3

4MM

3.1

Refer to RRSTUNI when assembling your Slimline II Tray.

Make sure that the wind deﬂector is

installed before you proceed to the next

step.

3.4

Centre the rack and fully tighten all the fasteners. Use M6 & M8 nut caps (Items 8 & 15) to

ﬁnish off the nuts.

Slide item 12 into the t-slots shown in

step 3.3. Loosely ﬁt the roof rack to the

foot rails by using items 13 & 14.

13mm

FAMP002_REV_A00

COMPLETION

INSTALL OTHER VEHICLE AND RACK ACCESSORIES

Now's the time to visit your favorite Front Runner Dealer in person or online.

4.1

Congratulations. You did it. Take a step back and admire your work!

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Accesorios para automóviles de Front Runner

Front Runner

Front Runner Pro Bike Carrier Manual de usuario

Front Runner

Front Runner MKIII Small Manual de usuario

Front Runner

Front Runner KRTL015L Manual de instrucciones

Front Runner

Front Runner SSDS109 Manual de usuario

Front Runner

Front Runner SSDR010 Manual de usuario

Front Runner

Front Runner GWTL101-2 Manual de usuario

Front Runner

Front Runner PRO UNDER RACK TABLE bracket Manual de usuario

Front Runner

Front Runner KSTF003T Manual de usuario

Front Runner

Front Runner KSVT001 Manual de usuario

Front Runner

Front Runner TRAC003 Manual de usuario

Front Runner

Front Runner Easy-Out Manual de usuario

Front Runner

Front Runner FAJK007 Manual de usuario

Front Runner

Front Runner SLIMLINE II Manual de usuario

Front Runner

Front Runner SSDR003 Manual de usuario

Front Runner

Front Runner PBTH001 Manual de usuario

Front Runner

Front Runner BGTH002 Manual de usuario

Front Runner

Front Runner BRONCO TBRA040 Manual de usuario

Front Runner

Front Runner LAMS001 Manual de usuario

Front Runner

Front Runner SLIMLINE II Instrucciones de montaje

Front Runner

Front Runner Pro Water Tank with Strap Manual de usuario

Front Runner

Front Runner LAMG002 Manual de usuario

Front Runner

Front Runner FSLI021 Manual de usuario

Front Runner

Front Runner PBTT002 Manual de usuario

Front Runner

Front Runner SSDS802 Manual de usuario

Manuales populares de Accesorios para automóviles de otras marcas

James Baroud

James Baroud Odyssey Manual de usuario

Motorola

Motorola i50sx Manual de usuario

Yakima

Yakima 9MM STANDARD BIKE MOUNT Manual de usuario

Feniex

Feniex T3 Manual de usuario

Renault

Renault 77 11 423 180 Manual de usuario

Kia

Kia E8300-4D000 Manual de usuario

Brink

Brink 756843 Manual de usuario

Whispbar

Whispbar K085W Manual de usuario

v.link

v.link CI-VL2-PC-HSD Manual de usuario

Viking

Viking Stack-Rack Guía de configuración rápida

Aries

Aries 203015 Manual de usuario

Choetech

Choetech AT0005 Manual de usuario

ZZ2

ZZ2 ZZAIR-PRO Manual de usuario

Holman

Holman 4A80L Manual de usuario

Thule

Thule 2075 Manual de usuario

Motorola

Motorola T325 Manual de usuario

TAUBENREUTHER

TAUBENREUTHER 16-3950 Guía de instalación

DV8

DV8 FBJL-02 Manual de usuario