Flowserve APS1 Manual

Flowserve Corporation 765 South 100 East Phone: 801 373 3028

Flow Control Division Provo, Utah 84606 Facsimile: 801 489 2228

Automation Business Unit www.flowserve.com Email: [email protected]

LMR0015-0 (AUTO-15) 8/01

Automax Valve Automation Systems

Installation, Operation and Maintenance Instructions

Operation

The Automax APS1 with the Automax A25N solenoid valve

purges the spring chamber with exhaust air. This prevents

corrosive atmospheres from being pulled into the

spring chamber.

The APS1 consists of a single compact block with no

moving parts, sandwich mounted between the SuperNova

actuator and the Automax solenoid valve. There are no

tubing or fittings required.

Maintenance Instructions

Trouble Shooting the APS1

Actuator will not cycle.

1. Check for proper orientation of APS1 and

solenoid valve.

2. Check for plugged exhaust port.

3. Check for correct supply pressure.

Air leaks through breather exhaust when actuator

is held open.

1. Check for actuator leakage.

2. Check for solenoid valve leakage.

Installation Instructions

The Automax APS1 may be installed very easily to the

SuperNova series spring return actuators utilizing any

Automax A25N series NAMUR solenoid valve.

1. Place each O-ring provided into the O-ring bore on the

rear of the module (the side with two large ports). Each

O-ring should be completely seated in the bore.

2. Place the actuator with the two ports facing you, and the

stem pointing up. Orient the APS1 module with the

O-rings toward the actuator, and the central thru-port

hole to the right.

3. Place the Automax solenoid valve with the (3) O-rings

toward the APS1 and the operator toward the right.

4. The APS1 is then "sandwich" mounted between the

solenoid valve and the SuperNova actuator with the two

screws provided.

5. Install the pipe plug into port #3 of the solenoid valve

and the bronze breather vent into port #5.

6. Connect the air supply to port #1 and the assembly is

ready for operation.

APS1 Module

Page 1 of 2

SUPERNOVA ACTUATOR

AUTOMAX NAMUR

SOLENOID VALVE

BREATHER VENT

AIR SUPPLY

Flowserve Corporation 765 South 100 East Phone: 801 373 3028

Flow Control Division Provo, Utah 84606 Facsimile: 801 489 2228

Automation Business Unit www.flowserve.com Email: [email protected]

LMR0015-0 (AUTO-15) 8/01

Automax Valve Automation Systems

Installation, Operation and Maintenance Instructions

APS1 Profile View

Page 2 of 2

APS1 Exploded View with BOM

AUTOMAX NAMUR

SOLENOID VALVE

SUPERNOVA ACTUATOR

APS1 PURGE SYSTEM

Standard Components

Part # Description Material Qty P/N

1 APS1 Block Aluminum 1 105839

Anodized

2 O-Ring Nitrile 2 105775

3 M5-.8X40mm Steel 2 106008

SHCS

4 Vent Bronze 1 106200

5 Pipe Plug Steel 1 100933

AIR SUPPLY

(PORT #1)

SUPERNOVA

ACTUATOR

AUTOMAX NAMUR

SOLENOID VALVE

Tabla de contenidos

Otros manuales de Unidad de control de Flowserve

Flowserve

Flowserve Valtek Valdisk Guía

Flowserve

Flowserve NAF ProCap Instrucciones de instalación

Flowserve

Flowserve Atomac AKH3.2 Manual de usuario

Flowserve

Flowserve Valtek MegaStream Guía

Flowserve

Flowserve Valtek GS Manual de usuario

Flowserve

Flowserve Valtek Tek-Check Guía

Flowserve

Flowserve H71 Series Manual

Flowserve

Flowserve Valdisk 150 Manual

Flowserve

Flowserve Valtek Guía

Flowserve

Flowserve Nordstrom Series Instrucciones de funcionamiento

Flowserve

Flowserve Valtek Three-way Guía

Flowserve

Flowserve NAF-Setball Manual de usuario

Flowserve

Flowserve Valtek Guía

Flowserve

Flowserve Edward 602Y Manual de usuario

Flowserve

Flowserve Worcester V-Flow 53 Series Manual de usuario

Flowserve

Flowserve NAF Duball DL Manual de usuario

Flowserve

Flowserve Durco Sleeveline G4XZ Manual de usuario

Flowserve

Flowserve S25N Manual

Flowserve

Flowserve T4E-1 Manual de usuario

Flowserve

Flowserve Worcester V-Flow 51 Series Manual de usuario

Flowserve

Flowserve atomac AtoPro Series Manual de usuario

Flowserve

Flowserve CPT 44 Manual

Flowserve

Flowserve MaxFlo4 Manual de usuario

Flowserve

Flowserve ColdFlow 341000 Manual de usuario

Manuales populares de Unidad de control de otras marcas

Festo

Festo Compact Performance CP-FB6-E Manual de lista de piezas

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Manual de usuario

JS Automation

JS Automation MPC3034A Manual de usuario

JAUDT

JAUDT SW GII 6406 Series Guía rápida

Spektrum

Spektrum Air Module System Manual de usuario

BOC Edwards

BOC Edwards Q Series Manual de usuario

KHADAS

KHADAS BT Magic Manual de usuario

Etherma

Etherma eNEXHO-IL Manual de usuario

PMFoundations

PMFoundations Attenuverter Manual de usuario

GEA

GEA VARIVENT Manual de usuario

Walther Systemtechnik

Walther Systemtechnik VMS-05 Manual de usuario

Altronix

Altronix LINQ8PD Instrucciones de montaje

Eaton

Eaton Powerware Series Manual de usuario

WAGO

WAGO 750-407/040-000 Manual de usuario

Sony

Sony CCU-590 Manual de usuario

Graco

Graco 25D614 Manual de usuario

Task Force Tips

Task Force Tips YE-RF-900 Manual de programación

Shini

Shini SPV-U Series Manual de usuario