Extech Instruments IR300UV Manual de usuario

USERMANUAL

InfraRedThermometer

Built‐inUVRefrigerantLeakDetectorandFlashlight

ModelIR300UV

Visit us at www.TestEquipmentDepot.com

EXTECHINSTRUMENTS

2 IR300UV‐en‐GB_V1.01/16

Introduction

CongratulationsonyourpurchaseoftheIR300UVIRThermometer.Thisthermometermakes

non‐contact(infrared)temperaturemeasurementsatthetouchofabutton.Thebuilt‐incoaxial

laserpointerincreasestargetaccuracywhilethebacklitLCDandhandymulti‐switchcombinefor

convenient,ergonomicoperation.TheUVlightsourceisconvenientforlocatingleakssuchas

refrigerants.Thisdeviceisshippedfullytestedandcalibratedand,withproperuse,willprovide

yearsofreliableservice.

Features

Measuresnon‐contactsurfacetemperatureupto500°C(932°F)

12:1DistancetoSpotRatio(FieldofView)

AreaandSingle‐pointlasertargeting

DisplayMAX,MIN,AVGorMAX‐MINDifference

AutomaticDataHoldwhentriggerisreleased

DisplayBacklight

Selectabletemperatureunits(°F/°C)

Adjustableemissivity

AudibleandvisiblealarmindicationforHighandLowTemperatureAlarm

UVleakdetectorwith5UV/BlueLEDs

Brightflashlightwith5WhiteLEDs

Safety

InternationalSafetySymbols

Thissymbol,adjacenttoanothersymbolor

terminal,indicatestheusermustrefertothe

manualforfurtherinformation

Warnings

oDonotdirectlyorindirectlypointthelaserattheeyes

ofapersonorananimal

oInspectfordamageorforanyshortageofpartsor

accessoriesbeforeuse

oReplacethebatteriesimmediatelyafterthebatteryindicatorflashes

oDonotusethethermometernearexplosivegases,steam,ordust

oNotethatanobjectwithhighreflectivitywillnormallycausethemeasuredtemperaturevaluetoread

muchlowerthantheactualtemperature

oUsethedeviceonlyasdescribedinthisUserGuide

Cautions

Toavoidthermometerdamage,pleaseavoidthefollowinghazards:

oEMFfromweldingequipmentorelectro‐inductionheaters

oStaticelectricity

oThermalshockcausedbylargeorabruptenvironmentaltemperaturechanges;wait30minutesto

allowthethermometertostabilizetonewenvironmentalconditions

oDonotusethisdeviceinexcessivelyhightemperatureenvironments

EXTECHINSTRUMENTS

3IR300UV‐en‐GB_V1.01/16

Description



MeterDescription

1. LCDDisplay

2. Multi‐Switchcontrol

3. BatteryCompartment

4. Laserpointer

5. White/BlueLEDs

6. IRsensor

7. Lenscovercontrol

8. MeasurementScanTrigger

DisplayDescription

Laserpointeractiveicon

Holdmode(displayedtemperaturefreezeswithtriggerrelease)

Maximum/Minimum/Averagetemperatureicons

Batterycapacityindicator

WhiteLEDsactive

Temperatureunits(°F/°C)

TemperatureAlarmicons

UVLEDsactive

Emissivitysetting

EXTECHINSTRUMENTS

4IR300UV‐en‐GB_V1.01/16

Operation

MeterPower

Themeterispoweredbythree1.5VAAbatteries.Withfreshbatteriesinstalled,themeter

switchesONwhenthetriggerispulled.RefertotheMaintenancesectionforBatteryInstallation

instructions.Thebatteryiconprovidesbatterystatusindication.Replacethebatteriesassoonas

thebatterystatusiconindicatesalowbattery.

SettingMode

Thevariousparametersofthemeteraresetusingthefive‐waymulti‐switchlocatedbelowthe

display.Theavailableparametersarelistedbelow:

Flashlight(ONOFF)

UVlight(ONOFF)

TemperatureUnits(°C°F)

Emissivity(0.10to1.00)

Laserpointer(ONOFF)

Max/Min/Avg&Max‐Min(ONOFF)

HILOAlarm(ONOFF)

HighTemperatureAlarmLimitsetting

LowTemperatureAlarmLimitsetting

Beeper(ONOFF)

SettingModeOverview

TheSettingsswitchhasfivepositionstoselectaparameter,turna

parameterONorOFF,andtoadjustparametervalues.

PressandreleasetheMeasurementTrigger.

PressthebuttonlefttoentertheSettingMode.The

parameterselectedwillappearinthedisplay.

Pressthebuttonrighttoadvancetothenextparameter.

Presstheupordown buttonstochangeaparameterstatusoradjustaparameter

value.

Pressthe buttontostoreparameterchangesandadvancetothenextparameter.

Pressthe buttonlefttoexittheSettingsmodeandreturntoMeasurementmode.

Note:IfnobuttonispressedwithintheAPOtimethemeterwillshutdown.Itmaybehelpful

toextendtheAPOtimewhenmakingadjustmentsintheSettingsmode.

EXTECHINSTRUMENTS

5IR300UV‐en‐GB_V1.01/16

SettingModeDetail

1. FlashlightSetting

EntertheSettingmode.The Flashlighticonflashes.

PressupforONorOFF.Press tostorethesetting

2. UVlightSetting

EntertheSettingmode.AdvanceuntiltheUViconflashes.

PressupforONorOFF.Press tostorethesetting

3. TemperatureUnitsSetting

EntertheSettingmode.Advanceuntilthe°For°Ciconflashes.

Pressuptochangetheunits.Press tostorethesetting

4. EmissivitySetting

EntertheSettingmode.AdvanceuntiltheEMSiconflashes.

Pressupordowntoadjustthesetting.Presstostorethesetting

5. LaserPointerSetting

EntertheSettingmode.Advanceuntiltheiconflashes.

PressupforONorOFF.Press tostorethesetting

6. MaxMinAvgMax‐MinSetting

EntertheSettingmode.AdvanceuntiltheMAX–MINAVGiconflashes.

PressupforONorOFF.Press tostorethesetting

7. AlarmHISetting

EntertheSettingmode.AdvanceuntiltheAlarmHIiconflashes.

PressupordownforONorOFF.Press tostorethesetting

IfONwasselected,Pressupordowntoadjustthelimit.

Presstostorethesetting

8. AlarmLOSetting

EntertheSettingmode.AdvanceuntiltheAlarmLOiconflashes.

PressupordownforONorOFF.Presstostorethesetting

IfONwasselected,Pressupordowntoadjustthelimit.

Presstostorethesetting

9. BacklightSetting

EntertheSettingmode.AdvanceuntiltheLItEiconflashes.

PressupordownforONorOFF.Presstostorethesetting

10. AutoPowerOFFSetting

EntertheSettingmode.AdvanceuntiltheAPOiconflashes.

Pressupordowntoadjustthesetting.Presstostorethesetting

EXTECHINSTRUMENTS

6IR300UV‐en‐GB_V1.01/16

SurfaceTemperatureMeasurements

1. Typicalsettingshouldbe:LaserpointerON,BacklightON,Temperatureunitssetasneeded,

Emissivitysetto0.95,APO(autopowerOFF)setto10secondsandFlashlightONif

measuringinadimlylitarea.

2. Openthelensprotectivelenscoverbyrotatingthe

coverwheelclockwise(facingthelens)untilthedotis

visibleonthewheel.

3. HoldthemeterbyitsHandleGripandpointittoward

thesurfacetobemeasured.

4. PullandholdtheTriggertoturnthemeteronand

begintestinginScanmode.Thedisplaywilllightifthe

batteriesaregood.Replacethebatteriesifthedisplay

doesnotlight.

5. ReleasetheTrigger;thereadingwillHOLDforthetime

setintheAPOsetting.Thebacklightwillturnoffafterapproximately4seconds.

6. Themeterdefaultstotheprogrammedconditionsinusewhenthemeterwaslastswitched

OFF.

LaserPointer

Thelaserpointercircleidentifiestheareabeing

measured.Thesizeoftheareaisdeterminedbythe

distancetospotratio.Objectsoutsidethecircleare

notmeasured.Thespotmeasuredshouldalwaysbe

largerthanthecircleforaccuratemeasurements.

MAX,MIN,AVERAGEandMAX‐MIN

IntheMAXMINAVGmodethemeterwillrecordtheMaximumvaluescanned,Minimumvalue

scanned,theAverageofthescannedvaluesandtheDifferencebetweentheMaxandMinvalue.

1. TurnMaxMinONinthesettingsmode

2. Pressandholdthetriggertoscananarea.Max,Min,AvgorMax‐Min

willbedisplayedinthelowerrightdisplay.Presstheupbuttonto

selecttheparametertobedisplayed.Thevalueswillbecontinuously

updatedforthelengthofthescan.



EXTECHINSTRUMENTS

7IR300UV‐en‐GB_V1.01/16

UVLeakDetector

Injectasmallamountofflorescentdyeintothesystemundertest.Thedye/systemmixture

(refrigerant,forexample)willescapeandaccumulateatallleaksites.TurntheblueUVLEDson

intheSettingmodeandscanthesystem.Theresidueofthedyeattheleakcanbeeasily

observedundertheUVlight.DyesareavailableatmostHVACsupplyoutlets.



LocatingHotorColdSpots

Todetectahotorcoldspot,aimthethermometerataregionbeyond

thetargetandthenscantheentireregioninaslow,up/downmotion.



DistancetoSpotRatio(FieldofView)

Themeter’sfieldofviewis12:1(distancetospotratio).Forexample,ifthemeteris60cm(24

inches)fromthetarget(spot),thediameterofthetargetmustbeatleast5cm(2inches).Other

distancesareshownbelowinthefieldofviewdiagram.

Notethatmeasurementsshouldnormallybemadefurtherthan60cm(24inches)fromthe

target.Themetercanmeasurefromfurtherdistancesbutthemeasurementmaybeaffectedby

externalsourcesoflight.Inaddition,thespotsizemaybesolargethatitencompassessurface

areasnotintendedtobemeasured.



2.5cm@30cm5cm@60cm10cm@120cm

1”@12”2”@24”4”@48”



Itisnecessarytoensurethatthesizeofthetargetislargerthanthespotsize.Thesmallerthe

target,thecloserthedistanceshouldbe.



EXTECHINSTRUMENTS

8IR300UV‐en‐GB_V1.01/16

Emissivity

Emissivityrepresentstheenergyreflectivityofamaterial.Mostorganicmaterialsandpainted

oroxidizedsurfaceshaveanemissivityofapproximately0.95.Ifpossible,maskingtapeorflat

blackpaintshouldbeappliedtocoverthemeasuredsurface.

Waitaperiodoftimetoallowthetapeorpainttoreachthermalequilibriumwiththesurface

ofthecoveredobject.Measurethetemperatureofthesurfacecoveredwithtapeorpaintonly

afterequilibriumhasbeenachieved.

HighLowLimits

TheHI/LOlimitsprovideanalarmwhenapresettemperatureisexceeded.

LensCover

Thelenscoverprotectsthelensfromdustwhenthemeterisnotinuse.Alwaysclosethecover

whenstoringthemeter.

MeasurementNotes

1. Theobjectundertestshouldbelargerthanthespot(target)sizecalculatedbythefieldof

viewdiagram.

2. Ifthesurfaceoftheobjectundertestiscoveredwithfrost,oil,grime,etc.,cleanbefore

takingmeasurements.

3. Ifanobject'ssurfaceishighlyreflectiveapplymaskingtapeorflatblackpainttothesurface

beforemeasuring.

4. Themetermaynotmakeaccuratemeasurementsthroughtransparentsurfacessuchas

glass.

5. Steam,dust,smoke,etc.canobscuremeasurements.

6. Themetercompensatesfordeviationsinambienttemperature.Itcan,however,takeupto

30minutesforthemetertoadjusttoextremelywideambienttemperaturechanges.

7. Tofindahotspot,aimthemeteroutsidetheareaofinterestthenscanacross(inanupand

downmotion)untilthehotspotislocated.

8. Whenthemeterisheldattheoptimumdistancefromthetarget,thesinglelaserdotwill

appearatthetopofthecircularlasertarget.Aslongasthesinglelaserdotiswithinthe

circularlasertarget,themeterwillmakeanaccuratemeasurement.

EXTECHINSTRUMENTS

9IR300UV‐en‐GB_V1.01/16

Maintenance

Cleaning

Tocleanthelensusecompressedairtocleardustandotherparticles,thencarefullycleanwitha

wetcottonswab.Thecottonswabshouldbemoistenedwithcleanwater.

Tocleanthemeterhousing,wipewithadamp,softcloth.Donotusesolventsorabrasives.Do

notimmersetheIR300UVinwaterorotherliquid.

ReplacingBatteries

Whenthebatteryiconindicatesalowbattery,orwhenthemeter

doesn’tswitchON,replacethebatteries.

Thebatterycompartmentlidislocatedontherearofthehandle.

RemovetheonePhilipsheadscrewandliftthelidoff.

Replacethethree1.5VAAbatteriesfollowingcorrectpolarityandthen

replaceandsecurethebatterycompartmentlid.

BatterySafetyNotes:Pleasedisposeofbatteriesresponsibly;neverdisposeof

batteriesinafire,batteriesmayexplodeorleak.Ifthemeterisnottobeused

for60daysormore,removethebatteryandstoreseparately.Donotmix

batterytypesorfreshnesslevels;pleaseusebatteriesofthesametypeandofthesamefreshnesslevel.

Neverdisposeofusedbatteriesorrechargeablebatteriesinhouseholdwaste.

Asconsumers,usersarelegallyrequiredtotakeusedbatteriestoappropriatecollectionsites,the

retailstorewherethebatterieswerepurchased,orwhereverbatteriesaresold.

Disposal:Donotdisposeofthisinstrumentinhouseholdwaste.Theuserisobligatedtotakeend‐of‐life

devicestoadesignatedcollectionpointforthedisposalofelectricalandelectronicequipment.

Specifications

InfraredThermometerSpecifications

Range/Resolution‐30~500oC(‐22~932oF)

Accuracy0°C:±1.5°Cor1.5%ofreading(whicheverisgreater)

32°F:±3°For1.5%ofreading(whicheverisgreater)

‐10°Cto0°C:±2°C

14°to32°F:±4°F

Note:Accuracyisspecifiedfortheambienttemperaturerange:

21~25°C(70~77°F)

ResponseTime500ms(95%ofreading)

Repeatability(%ofreading)±8%ofreadingor±1.0°C(1.8°F)whicheverisgreater

EmissivityAdjustablefrom0.10to1.00

Temp.Coefficient0.1°C/°Cor±0.1%/°Cofreading(whicheverisgreater)

FieldofViewD/S=Approx.12:1ratio(D=distance,S=spot)

LaserpowerLessthan1mW

Spectralresponse8to14microns

EXTECHINSTRUMENTS

10 IR300UV‐en‐GB_V1.01/16

GeneralSpecifications

Display BacklitLCDdisplaywithfunctionindicators

Displayresolution0.1°C(0.2°F)

Flashlight5whiteLEDs

UVlight5blueLEDs

OperatingTemperature 0°Cto50°C(32°Fto122°F)

OperatingHumidity10to90%RHnoncondensing@30°C(86°F)

StorageTemperature ‐20°Cto60°C(‐4°Fto140°F)withoutbattery

OperatingAltitude2000m(7000ft.)abovesealevel

StorageAltitude12,000m(40,000ft.)abovesealevel

DropProof1.2m(4ft.)

PowerSupply3x1.5VAAIECLR06batteries

AutomaticPowerOffAdjustable1to60seconds

Weight 300g(10.6oz.)

Dimensions185x54x104mm(7.3x2.1x4.1”)

VibrationandShockIEC60068‐2‐62,5g,10Hzto200Hz

IEC60068‐2‐2750g,11ms

EMCEN61326‐1:2006EN61326‐2:2006

ComplianceEN/IEC61010‐1

Allrightsreservedincludingtherightofreproductioninwholeorinpartinanyform

ISO‐9001Certified

Test Equipment Depot - 800.517.8431 - 99 Washington Street Melrose, MA 02176

TestEquipmentDepot.com

Tabla de contenidos

Otros manuales de Termómetro de Extech Instruments

Extech Instruments

Extech Instruments RH350 Manual de usuario

Extech Instruments

Extech Instruments EA15 Manual de usuario

Extech Instruments

Extech Instruments K.J.E.T. 422324 Manual de usuario

Extech Instruments

Extech Instruments IR320 Manual de usuario

Extech Instruments

Extech Instruments IRC130 Manual de usuario

Extech Instruments

Extech Instruments IR250 Manual de usuario

Extech Instruments

Extech Instruments VIR50 Manual de usuario

Extech Instruments

Extech Instruments 42545-NIST Manual de usuario

Extech Instruments

Extech Instruments 401014A Manual de usuario

Extech Instruments

Extech Instruments 42529 Manual de usuario

Extech Instruments

Extech Instruments TM55 Manual de usuario

Extech Instruments

Extech Instruments 42515 Manual de usuario

Extech Instruments

Extech Instruments MO295 Manual de usuario

Extech Instruments

Extech Instruments IR100 Manual de usuario

Extech Instruments

Extech Instruments 445582 Manual de usuario

Extech Instruments

Extech Instruments 42512 Manual de usuario

Extech Instruments

Extech Instruments 445580 Manual de usuario

Extech Instruments

Extech Instruments 39240 Manual de usuario

Extech Instruments

Extech Instruments RH250W Manual de usuario

Extech Instruments

Extech Instruments RH250W Manual de usuario

Extech Instruments

Extech Instruments 42510A Manual de usuario

Extech Instruments

Extech Instruments 42509 Manual de usuario

Extech Instruments

Extech Instruments 445703 Manual de usuario

Extech Instruments

Extech Instruments 42530 Manual de usuario

Manuales populares de Termómetro de otras marcas

Delton

Delton 981A Manual de usuario

Baker

Baker MM2P Manual de usuario

Tarmo

Tarmo 320281 Manual de usuario

Citizen

Citizen CTD 504 Manual de usuario

TFA

TFA 14.1500 Manual de usuario

Vive

Vive DMD1010 Manual de usuario

Gotemp

Gotemp THB4002 Manual de usuario

GREISINGER

GREISINGER G 1202 Manual de usuario

Amprobe

Amprobe TMD-53W Manual de usuario

Trotec

Trotec BP10 Manual de usuario

Radiance instruments

Radiance instruments RT616 Series Manual de usuario

Eurolec

Eurolec IR151 Manual de usuario

Scaneo

Scaneo TS42B Manual de usuario

Sper scientific

Sper scientific 800043 Manual de usuario

Microlife

Microlife NC 200 Manual de instrucciones

Motorola

Motorola MBP69SN Guía de configuración

The MeatStick

The MeatStick The MeatStick Manual de usuario

Hama

Hama TH35-A Manual de usuario