Edelbrock 5683 Manual de usuario

Brochure #63-0483

Catalog #5683

Rev. 11/07- AJ/mc

EDELBROCK CAT-BACK EXHAUST SYSTEM (SINGLE SIDEOUT 3”)

for 2004-2008 Ford F-150 Pick-Up Trucks with 2 & 4WD, 4.6L/5.4L V8

Catalog #5683

INSTALLATION INSTRUCTIONS

Application: Designed for 2004-2008 Ford F-150 pick-up trucks, 2 & 4WD with 4.6L, 5.2L V8 engine.

Suggested Tools for Installation:

❑3/8” rachet set with SAE and metric sockets ❑9/16” and 15mm wrenches

❑Jackstands and jack ❑Liquid penetrant and rubber lubricant

❑Long pry bars (for removing rubber-mounted hangers) ❑Hacksaw (to cut intermediate pipe to required length)

❑ Tape measure

DISASSEMBLY

1. Raise vehicle and support with the proper jackstands,

leaving the rear suspension hanging.

2. Use caution around hot exhaust systems to avoid burns.

3. Use penetrating oil on all nuts and bolts, and rubber lube

on the rubber hangers.

4. Remove all nuts, bolts, and hangers from the rear of the

catalytic converter to the tailpipes.

5. Remove the old exhaust system.

INSTALLATION

1. Install rear muffler hanger #23-4066 into rear muffler

isolator with clamp to passenger side.

2. Install tailpipe hanger #23-4067 into isolator behind rear

axle with clamp toward driver’s side.

3. Slide ends of overaxle into hangers clamps installed in

Steps 1 and 2.

4. Install muffler outlet onto overaxle pipe placing the rear

muffler hanger clamp onto muffler outlet nipple (muffler

inlet is stamped on nipple).

Please study these instructions carefully before installing your new Cat-Back Exhaust System. If you have any questions, please

contact our Technical Hotline at: 1-800-416-8628, 7:00 am to 5:00 pm, Monday through Friday, Pacific Standard Time or e-mail

us at [email protected].

WARNING: Exhaust gas contains carbon monoxide, a deadly invisible gas. Correct any leaks before driving!

5. Slide I-pipe #25-3217 onto catalytic converter outlet

pipe. Check length of I-pipe. Some vehicles will require

trimming due to various wheelbases. Mark I-pipe at this

time, remember the I-pipe should slide into muffler inlet

nipple 2”. This must be accounted for before cutting.

6. Install I-pipe onto catalytic outlet pipe and muffler with

supplied band clamps, only snug at this time.

7. Install hanger assembly #23-4063 onto I-pipe.

8. Install polished tailpipe and snug clamp.

9. Working from front to rear of vehicle align and tighten

clamps, being careful to give clearance for fuel lines,

brake lines, and spare tire.

Edelbrock Corporation, 2700 California Street, Torrance, CA 90503

Tech Line: 1-800-416-8628

E-mail: [email protected]

KIT CONTENTS

Qty. PN Description

1 23-4063 I-pipe hanger

1 23-4066 Muffler hanger

1 23-4067 Tailpipe hanger

1 25-3217 I-pipe

1 25-3222 Overaxle

1 25-3223 Tailpipe

1 25-55725 Muffler

IMPORTANT NOTE:

Proper installation is the responsibility of the installer. Improper installation will void warranty and may result in

poor performance and engine or vehicle damage.

Tabla de contenidos

Otros manuales de Pieza de automóvil de Edelbrock

Edelbrock

Edelbrock 4779 Manual de usuario

Edelbrock

Edelbrock 72961 Manual de usuario

Edelbrock

Edelbrock 1478 Manual de usuario

Edelbrock

Edelbrock 72285 Manual de usuario

Edelbrock

Edelbrock 72230 Manual de usuario

Edelbrock

Edelbrock 68732 Manual de usuario

Edelbrock

Edelbrock 5202 Manual de usuario

Edelbrock

Edelbrock ENDURASHINE 63-0299 Manual de usuario

Edelbrock

Edelbrock 5735 Manual de usuario

Edelbrock

Edelbrock 4250 Manual de usuario

Edelbrock

Edelbrock 5247 Manual de usuario

Edelbrock

Edelbrock 7798 Manual de usuario

Edelbrock

Edelbrock 6692 Manual de usuario

Edelbrock

Edelbrock 770769 Manual de usuario

Edelbrock

Edelbrock 5226 Manual de usuario

Edelbrock

Edelbrock 66662 Manual de usuario

Edelbrock

Edelbrock 67452 Manual de usuario

Edelbrock

Edelbrock 17000 Manual de usuario

Edelbrock

Edelbrock Russell R09430 Manual de usuario

Edelbrock

Edelbrock 1400 Manual de usuario

Edelbrock

Edelbrock 71850 Manual de usuario

Edelbrock

Edelbrock 63-0342 Manual de usuario

Edelbrock

Edelbrock 97383 Manual de usuario

Edelbrock

Edelbrock 68932 Manual de usuario

Manuales populares de Pieza de automóvil de otras marcas

Dakota Digital

Dakota Digital 650277 Manual de usuario

bosal

bosal 037031 Manual de usuario

Vintage Air

Vintage Air 571063 Manual de usuario

GFB

GFB EX38 Manual de usuario

bosal

bosal 028091 Manual de usuario

Dodge

Dodge 8W-43 Guía de inicio rápido

ICI

ICI Magnum FBM10DGN Manual de usuario

Volant Perfomance

Volant Perfomance 19435 Manual de usuario

BENDIX

BENDIX GEN 4 GEN 5 ABS Manual de usuario

Vintage Air

Vintage Air 571065 Manual de usuario

Rugged Ridge

Rugged Ridge 11503.13 Manual de usuario

BENDIX

BENDIX CYCLONE DURADRAIN TRAILER WATER Manual de usuario

Porsche

Porsche 968 - ASSEMBLY INSPECTION PROCEDURE AND MAINTENANCE... Guía

Sumitomo

Sumitomo FINE CYCLO FC-A 15 G Manual de usuario

Toshiba

Toshiba 48-1250 A Manual de usuario

aldes

aldes EHT2 Manual de usuario

Go Rhino

Go Rhino 24371T Manual de usuario

BBK

BBK 18950 Manual de usuario