Eaton Powerware 9155 Manual de usuario
Eaton 9155 Parallel UPS
8–15 kVA
User's Guide
®
Class A EMC Statements
FCC Part 15
NOTE This equipment has been tested and found to comply with the limits for a Class A digital device, pursuant to
part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference
when the equipment is operated in a commercial environment. This equipment generates, uses, and can radiate
radio frequency energy and, if not installed and used in accordance with the instruction manual, may cause harmful
interference to radio communications. Operation of this equipment in a residential area is likely to cause harmful
interference in which case the user will be required to correct the interference at his own expense.
ICES-003
This Class A Interference Causing Equipment meets all requirements of the Canadian Interference Causing
Equipment Regulations ICES‐003.
Cet appareil numérique de la classe A respecte toutes les exigences du Reglement sur le matériel brouilleur du
Canada.
IEC 62040-2
Some configurations are classified under IEC 62040-2 as “C2 UPS for Unrestricted Sales Distribution.”
VCCI Notice
Eaton, ABM, FERRUPS, Powerware Hot Sync, and X-Slot are registered trademarks of Eaton or its subsidiaries and
affiliates. Greenlee is a registered trademark of Greenlee Textron. National Electrical Code and NEC are registered
trademarks of National Fire Protection Association, Inc. All other trademarks are property of their respective
companies.
ECopyright 2004–2015 Eaton, Raleigh, NC, USA. All rights reserved. No part of this document may be reproduced
in any way without the express written approval of Eaton.
Special Symbols
The following are examples of symbols used on the UPS or accessories to alert you to important
information:
RISK OF ELECTRIC SHOCK - Observe the warning associated with the risk of electric
shock symbol.
CAUTION: REFER TO OPERATOR'S MANUAL - Refer to your operator's manual for
additional information, such as important operating and maintenance
instructions.
This symbol indicates that you should not discard the UPS or the UPS batteries
in the trash. This product contains sealed, lead‐acid batteries and must be
disposed of properly. For more information, contact your local recycling/reuse or
hazardous waste center.
This symbol indicates that you should not discard waste electrical or electronic
equipment (WEEE) in the trash. For proper disposal, contact your local
recycling/reuse or hazardous waste center.
Eaton 9155 Parallel UPS (8–15 kVA) User's Guide S164201592 Rev D www.eaton.com/powerquality i
Table of Contents
1 Introduction 1.........................................................
2 Safety Warnings 3.....................................................
3 UPS Setup 7..........................................................
Inspecting the Equipment 7...............................................................
Floor Loading 8........................................................................
Clearances 8.........................................................................
Unloading the Cabinet(s) 9................................................................
4 Parallel Installation 13...................................................
5 Installing Options 23....................................................
Powerware Hot Sync CAN Bridge Card 24......................................................
6 Stabilizing the Cabinet 31................................................
7 Extended Battery Module Installation 35....................................
8 Operation 39...........................................................
Control Panel Functions 39................................................................
Changing the Language 40..............................................................
Display Functions 40..................................................................
User Settings 42.....................................................................
Parallel UPS Startup 45...................................................................
Configuring the UPS for EBMs 49............................................................
Parallel System Shutdown 50..............................................................
Individual UPS Shutdown 51...............................................................
Restarting the Parallel System 52...........................................................
9 Parallel Bypass 53......................................................
10 Troubleshooting 55......................................................
Typical Alarms and Conditions 55............................................................
Silencing the Alarm 57...................................................................
Service and Support 58...................................................................
11 Warranty 59...........................................................
Two-Year Limited Warranty (US and Canada) 59.................................................
Load Protection Guarantee (US and Canada) 61..................................................
TABLE OF CONTENTS
Eaton 9155 Parallel UPS (8–15 kVA) User's Guide S164201592 Rev D www.eaton.com/powerquality
ii
Eaton 9155 Parallel UPS (8–15 kVA) User's Guide S164201592 Rev D www.eaton.com/powerquality 1
Chapter 1 Introduction
A parallel system with up to three uninterruptible power supplies (UPSs)
can be installed to provide a parallel capacity and/or redundant system.
This load sharing system provides more capacity than a single UPS and
can provide backup, depending on the load and configuration. In
addition, when one UPS is taken out of service for maintenance or is not
operating properly, a redundant UPS continues to supply uninterrupted
power to the critical load. A parallel Eaton®Powerware Hot Sync®
Controller Area Network (CAN) Bridge Card provides connectivity for
system metering and operational mode control. The parallel system
consists of two or three UPSs, each with a CAN Bridge Card and a
parallel tie cabinet.
Figure 1 shows the Eaton 9155 UPS and an optional Extended Battery
Module (EBM).
Figure 1. The Eaton 9155 UPS and EBM (2-High Cabinets Shown)
INTRODUCTION
Eaton 9155 Parallel UPS (8–15 kVA) User's Guide S164201592 Rev D www.eaton.com/powerquality
2
Eaton 9155 Parallel UPS (8–15 kVA) User's Guide S164201592 Rev D www.eaton.com/powerquality 3
Chapter 2 Safety Warnings
IMPORTANT SAFETY INSTRUCTIONS
SAVE THESE INSTRUCTIONS
This manual contains important instructions that you should follow during installation and
maintenance of the UPS and batteries. Please read all instructions before operating the
equipment and save this manual for future reference.
DANGER
This UPS contains LETHAL VOLTAGES. All repairs and service should be performed by
AUTHORIZED SERVICE PERSONNEL ONLY. There are NO USER SERVICEABLE
PARTS inside the UPS.
WARNING
SThis UPS contains its own energy source (batteries). The UPS output may carry live
voltage even when the UPS is not connected to an AC supply.
STo reduce the risk of fire or electric shock, install this UPS in a temperature and humidity
controlled, indoor environment, free of conductive contaminants. Ambient temperature
must not exceed 40°C (104°F). Do not operate near water or excessive humidity (95%
maximum).
STo reduce the risk of fire, connect only to a circuit provided with 100 amperes maximum
branch circuit overcurrent protection in accordance with the National Electrical Code®
(NEC®), ANSI/NFPA 70.
SOutput overcurrent protection and disconnect switch must be provided by others.
CAUTION
SBatteries can present a risk of electrical shock or burn from high short circuit current.
Observe proper precautions. Servicing should be performed by qualified service personnel
knowledgeable of batteries and required precautions. Keep unauthorized personnel away
from batteries.
SProper disposal of batteries is required. Refer to your local codes for disposal
requirements.
SNever dispose of batteries in a fire. Batteries may explode when exposed to flame.
SAFETY WARNINGS
Eaton 9155 Parallel UPS (8–15 kVA) User's Guide S164201592 Rev D www.eaton.com/powerquality
4
Consignes de Sécurité
CONSIGNES DE SÉCURITÉ IMPORTANTES
CONSERVER CES INSTRUCTIONS
CE MANUEL CONTIENT DES CONSIGNES DE SÉCURITÉ
IMPORTANTES
DANGER!
Cet onduleur contient des TENSIONS MORTELLES. Toute opération d'entretien et de
réparation doit être EXCLUSIVEMENT CONFIÉE A UN PERSONNEL QUALIFIÉ AGRÉÉ.
AUCUNE PIÈCE RÉPARABLE PAR L'UTILISATEUR ne se trouve dans l'onduleur.
WARNING
SCet onduleur renferme sa propre source d'énergie (batteries). Les prises de sortie peuvent
être sous tension même lorsque l'onduleur n'est pas branché sur le secteur.
SPour réduire les risques d'incendie et de décharge électrique, installer l'onduleur
uniquement à l'intérieur, dans un lieu dépourvu de matériaux conducteurs, où la
température et l'humidité ambiantes sont contrôlées. La température ambiante ne doit
pas dépasser 40 °C. Ne pas utiliser à proximité d'eau ou dans une atmosphère
excessivement humide (95 % maximum).
SLa protection contre une surintensité pour le(s) circuit(s) de sortie de courant alternatif
doit être fournie par un autre fournisseur.
SLes interrupteurs de déconnexion convenables pour le(s) circuit(s) de sortie de courant
alternatif doivent être fournie par un autre fournisseur.
ATTENTION!
SLes batteries peuvent présenter un risque de décharge électrique ou de brûlure par des
courts-circuits de haute intensité. Prendre les précautions nécessaires.
SUne mise au rebut réglementaire des batteries est obligatoire. Consulter les règlements
en vigueur dans votre localité.
SNe jamais jeter les batteries au feu. L'exposition aux flammes risque de les faire
exploser.
Otros manuales para Powerware 9155
9
Tabla de contenidos
Otros manuales de Unión Postal Universal de Eaton
Eaton
Eaton EX 2200 RT 3U Manual de usuario
Eaton
Eaton 3SMini Instrucciones de montaje
Eaton
Eaton 9315 Manual de usuario
Eaton
Eaton FERRUPS Manual de usuario
Eaton
Eaton Ellipse ECO 500 Manual de usuario
Eaton
Eaton 9PX EBM 240V Manual de usuario
Eaton
Eaton Powerware 9390 Manual de usuario
Eaton
Eaton 93PM IBC-L Manual de usuario
Eaton
Eaton 93PM IBC-L Manual de usuario
Eaton
Eaton 3S Manual de usuario
Eaton
Eaton Power Xpert 9395 UPS Plus 1 Manual de usuario
Eaton
Eaton 5E Gen2 Instrucciones de montaje
Eaton
Eaton FerrUPS FE Manual de usuario
Eaton
Eaton Power Xpert 9395 Manual de usuario
Eaton
Eaton RT 1250VA Manual de usuario
Eaton
Eaton 9395 UPS and Plus 1 UPS 650825 kVA Manual de usuario
Eaton
Eaton 10000HXL31 Manual de usuario
Eaton
Eaton Ellipse MAX 600 Pulsar Series Manual de usuario
Eaton
Eaton 5SC 1500G Manual de usuario
Eaton
Eaton MBP6Ki Manual de usuario
Manuales populares de Unión Postal Universal de otras marcas
Pylontech
Pylontech Victron & Pylontech US5000 Manual de usuario
Tecnoware
Tecnoware EVO DSP PLUS MM 6.8 Manual de usuario
Mecer
Mecer ME-1000-WTU Manual de usuario
Mustek
Mustek PowerMust 530(B) Plus Manual de instalación y operación
Emerson
Emerson Liebert NXL series Manual de usuario
MAKELSAN
MAKELSAN BOXER SERIES Manual de usuario
