Dimplex DS5603 Guía de inicio rápido

PARTS & SERVICE MANUAL

FOR THE 20” STOVE

MODEL NUMBER:

DS5598

DS5603

DS5804

TABLE OF CONTENTS

OPERATION PAGE1

PARTS DRAWING PAGE 3

PARTSLIST PAGE4

WIRING DIAGRAM PAGE 9

LIGHT BULB REPLACEMENT PAGE 11

MAIN ON/OFF SWITCH REPLACEMENT PAGE 13

FLAME MOTOR/FLAME ROD REPLACEMENT PAGE 14

HEATER ON/OFF SWITCH REPLACEMENT PAGE 16

HEATER ASSEMBLY REPLACEMENT PAGE 17

HEATER THERMOSTAT CONTROL REPLACEMENT PAGE 18

POWER CORD REPLACEMENT PAGE 19

DS5598, DS5603, DS5804

NOTE

A 15amp, 120 volt circuit is required. A dedicated circuit is preferred but not essential in

all cases. A dedicated circuit will be required if, after installation, the circuit breaker trips

or fuse blows on a regular basis when the heater is operating. Additional appliances on

the same circuit may exceed the current rating of the circuit breaker.

WARNING

Ensure the power cord is not installed so that it is pinched or against a sharp edge and

ensure that the power cord is stored or secured to avoid tripping or snagging to reduce

the risk of fire, electric shock or injury to persons.

Construction and electrical outlet wiring must comply with local building codes and other

applicable regulations to reduce the risk of fire, electric shock and injury to persons.

Do not attempt to wire your own new outlets or circuits. To reduce the risk of fire,

electric shock or injury to persons, always use a licensed electrician.

STOVE INSTALLATION

1. Make sure the units MAIN ON/OFF switch is switched OFF (refer to operating

instruction section).

2. Plug the unit into a 15Amp/120volt outlet. If the cord does not reach, you may use

an extension cord rated for a minimum of 1875 watts.

OPERATION

To access the controls go to the back of the Stove.

A. MAIN ON/OFF SWITCH

The on/off switch supplies power to all unit functions (heat/flame)

B. HEATER ON/OFF SWITCH

The HEATER ON/OFF SWITCH supplies power to the heater fan and the heater

element.

C. HEATER THERMOSTAT CONTROL

To adjust the temperature to your individual requirements, turn the thermostat control

clockwise all the way to turn on the heater. When the room reached the desired

temperature, turn the thermostat knob counter clockwise until you hear a click. Leave in

this position to maintain the room temperature at this setting. For additional heat, turn

clockwise until you hear the click again and the heater will turn on. To turn the heater

off, switch the HEATER ON/OFF SWITCH to the OFF position.

NOTE

When the heater is switched ON, the heater fan will operate. The heater element may

or may not be on, depending on the thermostat control setting (SEE “HEATER

THERMOSTAT CONTROL”).

DS5598, DS5603, DS5804

RESETTING THE TEMPERATURE CUTOFF SWITCH

Should the heater overheat, an automatic cut out will turn the heater off and it will not

come back on without being reset. It can be reset by switching the MAIN ON/OFF

SWITCH to OFF and waiting 5 minutes before switching the unit back on.

CAUTION

If you need to continuously reset the heater, unplug the unit and call Dimplex North

America Limited at 1-800-668-6663.

OPTIONAL REMOTE CONTROL

The remote control has a range of approximately 50ft. (15.25m) it does not have to be

pointed at the fireplace and can pass through most obstacles (including walls). It is

supplied with one of 243 independent frequencies to prevent interference with other

units. The frequency designation is indicated on the back of the transmitter (FIGURE 3)

REMOTE CONTROL INSTALLATION

1. Plug fireplace cordset into the outlet located on the side of the receiver. (FIGURE 2)

2. Plug receiver into the wall outlet.

3. Install a 9 volt battery into the transmitter. (FIGURE 3)

NOTE

• Fireplace MAIN on/off switch must be in the

ON position prior to using the Remote Control.

• ON/OFF Remote Control may be used to

control most other electrical devices including

T.V.’s, stereos and lamps.

CAUTION

• For indoor use in dry areas only

• For use on electrical devices with 15 amp

resistive load or 1/3 HP inductive load

• 120 volt AC only

FIGURE 2

Receiver

Outlet

OPEN

Frequency

Code

Battery

Cover

FIGURE 3

DS5598, DS5603, DS5804

DS5603

Top Panel

DS5804

Top Panel

DS5598

Top Panel

DS5603

Door Assembly

DS5603

Side Panel

DS5804

Door Assembly

DS5804

Side Panel

DS5598

Door Assembly DS5598

Side Panel

DS5598

REPLACEMENT PARTS

ENGINE ASSY STOVE, PLASTIC DOOR, DS5598

CATALOGUE NO. DS5598 DS5598

PART NO. 6900330800 6900330700

MOD LEVEL: MOD. E MOD. D

MADE IN: CHINA CANADA

REPLACEMENT PART REPLACEMENT PART NO.

1. FOOT, PLASTIC 0438230159RP 0438230159RP

2. DOOR 0438240159RP 0438240159RP*

3. LOGSET 0438270100RP 0438030100RP

4. FLICKER MOTOR 2000210100RP 2000140100RP

5. HEATER ASSEMBLY 2200490400RP 2000230100RP

6. CAPACITOR 2300030100RP N/A

7. THERMOSTAT 2300150100RP* 2300150100RP*

8. MAIN ON/OFF SWITCH 2800070200RP 2800070200RP

9. HEATER ON/OFF SWITCH 2800070200RP 2800070200RP

10.TERMINAL BLOCK 4000070100RP N/A

11.CORD SET 4100040200RP 4100040200RP

12.LOWER LIGHT ASSEMBLY 4200120300RP 2500080100RP

13.UPPER LIGHT ASSEMBLY 4200120400RP 2500100100RP

14.MIRROR 5900060400RP 5900060400RP

15.REFLECTOR ASSEMBLY 5900080500RP 5900080500RP

16.GLASS FRONT 5900110100RP 5900110100RP

17.CONTROL KNOB 8800000300RP 8800000300RP

OPTIONAL ACCESSORIES

18.REMOTE CONTROL 6800240100RP 6800050200RP

DS5598

REPLACEMENT PARTS

ENGINE ASSY STOVE, PLASTIC DOOR, DS5598

CATALOGUE NO. DS5598

PART NO. 6900330400

MOD LEVEL: MOD. C

MADE IN: CANADA

REPLACEMENT PART REPLACEMENT PART NO.

1. FOOT, PLASTIC 0438620159RP

2. DOOR 0438600159RP*

3. LOGSET 0438030100RP

4. FLICKER MOTOR 2000140100RP

5. HEATER ASSEMBLY 6902410100RP

6. CAPACITOR N/A

7. THERMOSTAT 2300150100RP*

8. MAIN ON/OFF SWITCH 2800070200RP

9. HEATER ON/OFF SWITCH 2800070200RP

10.TERMINAL BLOCK N/A

11.CORD SET 4100040200RP

12.LOWER LIGHT ASSEMBLY 2500080100RP

13.UPPER LIGHT ASSEMBLY 2500100100RP

14.MIRROR 5900060400RP

15.REFLECTOR ASSEMBLY 5900080500RP

16.GLASS FRONT 5900110100RP

17.CONTROL KNOB 8800000300RP

OPTIONAL ACCESSORIES

18.REMOTE CONTROL 6800050200RP

DS5603

REPLACEMENT PARTS

ENGINE ASSY STOVE, PLASTIC DOOR, DS5603

CATALOGUE NO. DS5603 DS5603

PART NO. 6900330900 6900330600

MOD LEVEL: MOD. E MOD. D

MADE IN: CHINA CANADA

REPLACEMENT PART REPLACEMENT PART NO.

1. FOOT, PLASTIC 0438620159RP 0438620159RP

2. DOOR 0438600159RP 0438600159RP*

3. LOGSET 0438270100RP 0438030100RP

4. FLICKER MOTOR 2000210100RP 2000140100RP

5. HEATER ASSEMBLY 2200490400RP 2000230100RP

6. CAPACITOR 2300030100RP N/A

7. THERMOSTAT 2300150100RP* 2300150100RP*

8. MAIN ON/OFF SWITCH 2800070200RP 2800070200RP

9. HEATER ON/OFF SWITCH 2800070200RP 2800070200RP

10.TERMINAL BLOCK 4000070100RP N/A

11.CORD SET 4100040200RP 4100040200RP

12.LOWER LIGHT ASSEMBLY 4200120300RP 2500080100RP

13.UPPER LIGHT ASSEMBLY 4200120400RP 2500100100RP

14.MIRROR 5900060400RP 5900060400RP

15.REFLECTOR ASSEMBLY 5900080500RP 5900080500RP

16.GLASS FRONT 5900360100RP 5900360100RP

17.CONTROL KNOB 8800000300RP 8800000300RP

18.REMOTE CONTROL 6800240100RP 6800050200RP

DS5603

REPLACEMENT PARTS

ENGINE ASSY STOVE, PLASTIC DOOR, DS5603

CATALOGUE NO. DS5603

PART NO. 6900330500

MOD LEVEL: MOD. C

MADE IN: CANADA

REPLACEMENT PART REPLACEMENT PART NO.

1. FOOT, PLASTIC 0438620159RP

2. DOOR 0438600159RP*

3. LOGSET 0438030100RP

4. FLICKER MOTOR 2000140100RP

5. HEATER ASSEMBLY 6902410100RP

6. CAPACITOR N/A

7. THERMOSTAT 2300150100RP*

8. MAIN ON/OFF SWITCH 2800070200RP

9. HEATER ON/OFF SWITCH 2800070200RP

10.TERMINAL BLOCK N/A

11.CORD SET 4100040200RP

12.LOWER LIGHT ASSEMBLY 2500080100RP

13.UPPER LIGHT ASSEMBLY 2500100100RP

14.MIRROR 5900060400RP

15.REFLECTOR ASSEMBLY 5900080500RP

16.GLASS FRONT 5900360100RP

17.CONTROL KNOB 8800000300RP

18.REMOTE CONTROL 6800050200RP

DS5804

REPLACEMENT PARTS

ENGINE ASSY STOVE, PLASTIC DOOR, DS5804

CATALOGUE NO. DS5804

PART NO. 6900331000

MOD LEVEL: MOD. E

MADE IN: CHINA

REPLACEMENT PART REPLACEMENT PART NO.

1. FOOT, PLASTIC 0438620159RP

2. DOOR 0438690159RP

3. LOGSET 0438270100RP

4. FLICKER MOTOR 2000210100RP

5. HEATER ASSEMBLY 2200490400RP

6. CAPACITOR 2300030100RP

7. THERMOSTAT 2300150100RP*

8. MAIN ON/OFF SWITCH 2800070200RP

9. HEATER ON/OFF SWITCH 2800070200RP

10.TERMINAL BLOCK 4000070100RP

11.CORD SET 4100040200RP

12.LOWER LIGHT ASSEMBLY 4200120300RP

13.UPPER LIGHT ASSEMBLY 4200120400RP

14.MIRROR 5900060400RP

15.REFLECTOR ASSEMBLY 5900080500RP

16.GLASS FRONT 5900400100RP

17.CONTROL KNOB 8800000300RP

18.REMOTE CONTROL 6800240200RP

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Cocina de Dimplex

Dimplex

Dimplex DS3311 Manual de usuario

Dimplex

Dimplex DS4411 Manual de usuario

Dimplex

Dimplex RIT20 Manual de usuario

Dimplex

Dimplex Purifire Electric Stove Manual de usuario

Dimplex

Dimplex DS5598 Manual de usuario

Dimplex

Dimplex Opti-myst Cassington CSN20 Manual de usuario

Dimplex

Dimplex MILANOef EDS7001F Guía de inicio rápido

Dimplex

Dimplex EOS-2006 Manual de usuario

Dimplex

Dimplex EOSM-2007 Manual de usuario

Dimplex

Dimplex ELECTRALOG CS1205 Manual de usuario

Dimplex

Dimplex Club CLB20R Manual de usuario

Dimplex

Dimplex Opti-V 360 Manual de usuario

Dimplex

Dimplex Club CLB20 Manual de usuario

Dimplex

Dimplex CASSINGTON EN60555-2 Manual de usuario

Dimplex

Dimplex CLUB Manual de usuario

Dimplex

Dimplex Mirage MIR40 Manual de usuario

Dimplex

Dimplex ELECTRALOG CS4416 Manual de usuario

Dimplex

Dimplex Stockbridge 2.0 Manual de usuario

Dimplex

Dimplex Optiflame 3D Laverton LVT20 Manual de instrucciones

Dimplex

Dimplex Rectory Manual de usuario

Dimplex

Dimplex Optiflame Cassia Noir RTOFSTV20 Manual de instrucciones

Dimplex

Dimplex ELECTRALOG CS3311 Guía de inicio rápido

Dimplex

Dimplex ELECTRALOG CS3311 Manual de usuario

Dimplex

Dimplex ELECTRIC PATIO STOVE Manual de usuario

Manuales populares de Cocina de otras marcas

Arada

Arada Cassette Stove Manual de usuario

Parmco

Parmco FS 600 Manual de usuario

MCZ

MCZ SUITE AIR 10 M2 Manual de usuario

HearthStone

HearthStone Stowe DV 8321 Guía de solución de problemas

Cattara

Cattara FAMILY Manual de usuario

Stanley

Stanley Argon F500 OVAL Manual de usuario

Avalon

Avalon B-VENT Manual de usuario

Nordpeis

Nordpeis Vega Manual de usuario

Exquisit

Exquisit EKC601-5 Manual de operación

Stanley

Stanley Oisin Oil MK II Manual del propietario

Thermocet

Thermocet Brookfield S/CC Manual de usuario

HASE

HASE delhi Manual de usuario

Vermont Castings

Vermont Castings Intrepid 2 Manual de usuario

Italiana Camini

Italiana Camini CLASSICA Guía de inicio rápido

Avalon

Avalon Vashon Avanti DVS FS Manual de usuario

Spartherm

Spartherm ambiente a1 Manual de usuario

Warmlite

Warmlite WL46040 Manual de usuario

Regency

Regency Ultimate U39E Series Guía de inicio rápido