Cornelius NITROPRO MINI Manual de usuario

NitroproMini(Model:CNBMini)

©2019,CorneliusInc.AllRightsReserved PublicationNumber:548000141

KITINSTUCTIONS

PREVENTATIVEMAINTENANCEKIT629097835‐548000141

Thiskitprovidesinstructionsforreplacementof

theaircompressorairfilterandtheconcentrate

pumpinternaltubing.

1.0AirCompressorAirFilter

Theaircompressor(Fig.1)islocatedintheleft

rearoftheenclosure.

1)Shutoffthepowertothedispenserandunplug

thepowercordfromthewallreceptacle.

2)Removethetop,back,andleftaccesspanels

fromthedispenser.

3)Withpoweroff,pullthereliefvalvering(Fig.2)

todepressurizetheairstoragechamber.

4)Notetheorientationoftheairfilter(Fig.1).

5)Disconnecttheairfilterfromtheairlineby

pressingonthedarkgrayringonthehoseside

ofeachconnectorwhilewithdrawingthehose.

6)Installthenewairfilterbyfirmlypressingthe

airhoseintoeachfilter‐connectorend.

7)Applypowerandconfirmnoairleakageatair‐

filterconnections.

8)Reinstalltheenclosureaccesspanels.

2.0ConcentratePumpTubing

1)Insidethecabinet,disconnectthewaterandair

linesatthebackofthechamber.

2)Pulleachtaptorelievelinepressure.

3)ShutoffpowertotheNitroprounit.

4)Inthecabinet,unplugthewiringconnector

fromthemixing‐dispensingassemblyand

removetheassembly.Placeitonthecounter‐

top(Fig.3).

5)Noteormarkthelocationsofthepumphoses

forreassembly.

6)Disconnectthetwohosesfromthepumpby

removingthehoseclampusingsidecuttersor

therecommendedOetikerHIP2800Escrimp‐

ing/cuttingtool(Fig.4).Cuttheclampopen.

Figure1‐AirCompressorAirFilter

Figure2‐AirCompressorPressureReliefValve

Figure3‐Mixing‐DispensingAssemblyRemoved

NitroproMini(Model:CNBMini)

PublicationNumber:548000141 ©2019,CorneliusInc.AllRightsReserved

KITINSTUCTIONS

PREVENTATIVEMAINTENANCEKIT629097835‐548000141

2.0ConcentratePumpTubing(Cont.)

Becarefultoavoiddamagingthetubing

whenremovingthehoseclamp.

7)Removethefourscrewssecuringthepump

brackettotheassemblybaseplate(accessfrom

underneath).

8)Openthepumpcoverbyremovingthethree

thumbscrewsontop(Fig.5).

9)Liftoutthepumprotorandbearing.Slideout

thetwopump‐hosenipplesfromthepump

housing.

10)Cleanthepump‐hosechamberasrequired.

11)Installthenewpumphose.Wheninstallingit

orienttherotorasshownintheupperphotos

ofFig.5sothatonlyonepointonthehose

mustbecompressed.

12)Reinstallthepumpcover.

13)Installthepumponthebaseplateandrecon‐

nectthehosesusingnewhoseclampsand

theOetiker(orequivalent)crimpingtool.

14)Reinstallthemixing‐dispensingassemblyinto

thecabinet,makingsuretoreconnectthe

plumbingandelectricalconnectors.

15)Confirmpumpoperationbydispensingboth

producttypesuntilairispurgedfromthe

lines.Checkforleaks.

CAUTION!

Figure4‐HoseClampRemoval(OeitikerTool)

Figure5‐ConcentratePumpandReplacementHose

PumpClosed PumpOpen

PumpHose

Otros manuales para NITROPRO MINI

Este manual sirve para los siguientes modelos

Otros manuales de Dispensador de Cornelius

Cornelius

Cornelius 2 Flavor Post-Mix Cold Coffee Dispenser Quest... Manual de usuario

Cornelius

Cornelius VIPER (E) 2 FLAVOR Manual de usuario

Cornelius

Cornelius Bubble Manual

Cornelius

Cornelius Remcor TJ45-D Manual de usuario

Cornelius

Cornelius Quest Bib Option Kit Manual de usuario

Cornelius

Cornelius IDC PRO 255 Manual de usuario

Cornelius

Cornelius UF-1 Guía de configuración

Cornelius

Cornelius Millenium II Manual de usuario

Cornelius

Cornelius JT20D Manual de usuario

Cornelius

Cornelius ICE-COOLED CHEST-A-FIELD DISPENSER Manual de usuario

Cornelius

Cornelius COLD CARB VENTURE Manual de instrucciones

Cornelius

Cornelius QUEST 4000 Manual de usuario

Cornelius

Cornelius SPIRE 4.2 Guía de seguridad

Cornelius

Cornelius Flavor OverLoad CG5017-1007 Manual de usuario

Cornelius

Cornelius The Profile PR150 BC Manual de usuario

Cornelius

Cornelius VANTAGE Manual de usuario

Cornelius

Cornelius 2230 C4-100 Manual de usuario

Cornelius

Cornelius JetSpray JS7 Manual de usuario

Cornelius

Cornelius Enduro/Duraflex Stand 175 Manual de usuario

Cornelius

Cornelius DF250 Manual de usuario

Cornelius

Cornelius ED22 Series Manual de usuario

Cornelius

Cornelius Universal 750 2849949xxx Guía de configuración

Cornelius

Cornelius NITROPRO MINI Manual de usuario

Cornelius

Cornelius Enduro 200 Manual de usuario

Manuales populares de Dispensador de otras marcas

Silver King

Silver King Majestic SK12MAJ Guía de inicio rápido

Franke

Franke F3Dn Twin Manual de usuario

STIEBEL ELTRON

STIEBEL ELTRON UltraHot Plus Manual de usuario

DAN DRYER

DAN DRYER 282 Manual de usuario

Essity

Essity Tork 473208 Manual de usuario

CBS

CBS SD300BU-88 Guía de configuración

Sealey

Sealey MK77 Manual de usuario

Fluid Management

Fluid Management Accutinter 1600 Manual de usuario

Franke

Franke DVS SD99-010 Manual de usuario

Graco

Graco Dispensit 1053-10C Guía de solución de problemas

ITALTINTO

ITALTINTO i50 Manual de usuario

Coca-Cola

Coca-Cola FREESTYLE 9000 Manual de usuario

Graco

Graco ProMix 2KE Manual de instrucciones

TECHCON SYSTEMS

TECHCON SYSTEMS TS1251 Manual de usuario

Wayne

Wayne GLOBAL VISTA CNG Manual de usuario

clarsen

clarsen H133 Manual de usuario

PicoBrew

PicoBrew Zymatic Manual de usuario

BOWMAN

BOWMAN BP-007 Manual de usuario