Cornelius DF250 Manual de usuario

ICE DIVERTER ED/DF DISPENSER KIT

P/N 02394

INSTALLATION MANUAL

Release Date: August 25, 2004

Publication Number: 92303INS

Revision Date: August 22, 2011

Revision: E

Visit the IMI Cornelius web site at www.cornelius.com for all your Literature needs.

The products, technical information, and instructions contained in this manual are subject to change without notice.

These instructions are not intended to cover all details or variations of the equipment, nor to provide for every possi-

ble contingency in the installation, operation or maintenance of this equipment. This manual assumes that the per-

son(s) working on the equipment have been trained and are skilled in working with electrical, plumbing, pneumatic,

and mechanical equipment. It is assumed that appropriate safety precautions are taken and that all local safety and

construction requirements are being met, in addition to the information contained in this manual.

This Product is warranted only as provided in Cornelius’ Commercial Warrant applicable to this Product and is sub-

ject to all of the restrictions and limitations contained in the Commercial Warranty.

Cornelius will not be responsible for any repair, replacement or other service required by or loss or damage resulting

from any of the following occurrences, including but not limited to, (1) other than normal and proper use and normal

service conditions with respect to the Product, (2) improper voltage, (3) inadequate wiring, (4) abuse, (5) accident,

(6) alteration, (7) misuse, (8) neglect, (9) unauthorized repair or the failure to utilize suitably qualified and trained per-

sons to perform service and/or repair of the Product, (10) improper cleaning, (11) failure to follow installation, oper-

ating, cleaning or maintenance instructions, (12) use of “non-authorized” parts (i.e., parts that are not 100%

compatible with the Product) which use voids the entire warranty, (13) Product parts in contact with water or the

product dispensed which are adversely impacted by changes in liquid scale or chemical composition.

Contact Information:

To inquire about current revisions of this and other documentation or for assistance with any Cornelius product con-

tact:

www.cornelius.com

800-238-3600

Trademarks and Copyrights:

This document contains proprietary information and it may not be reproduced in any way without permission from

Cornelius.

Printed in U.S.A.

Ice Diverter ED/DF Dispensers Installation Instructions

NOTE: For dispensing Scotsman NME654, NME954 and NME 1254 “Nugget” style ice and Cornelius

WCC500 and WCC700 “Chunklet” style ice cubes.

WARNING:

Disconnect power to the unit before servicing. Follow all lock out/tag out procedures established by the user. Verify all

power is off to the unit before performing any work.

Failure to comply could result in serious injury, death or damage to the equipment.

Perform the following procedure:

1. Remove upper front panel/merchandiser from dispenser.

2. Remove ice chute portion and gate restrictor.

3. Install ice diverter as shown (see Figure 1) and reinstall the gate restrictor removed in previous step. Gate

restrictor should be installed in ‘front’ of ice diverter .

Figure 1. Exploded View of Ice Diverter Installation

4. Remove screws securing white reflector panel and gain access to electrical box. Locate timer board and

reset agitation timer to 0.5 seconds ‘ON’ and 3 hours ‘OFF’ (see Figure 3).

5. Re-install front panel and plug unit back into outlet.

6. Unit should now be ready to dispense ice for customer use.

Figure 2. Gate Restrictor Full Opening Figure 3. Timer Board Settings Reset

STORAGE

HOPPER

GATE

MOUNTING

PLATE

ICE DIVERTER

P/N 15484

ICE CHUTE

FLANGE EXTENDS

INTO STORAGE

HOPPER THROUGH

GATE OPENING

APPLY RTV TO THIS

SURFACE TO SEAL TO

HOPPER GATE

MOUNTING PLATE

GASKET

FLAT WASHER

10-32 NUT

IMI Cornelius Inc.

www.cornelius.com

Otros manuales para DF250

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Dispensador de bebidas de Cornelius

Cornelius

Cornelius ED-250 Manual de usuario

Cornelius

Cornelius Jet Spray EJ1 Manual de usuario

Cornelius

Cornelius Enduro 200 Manual de usuario

Cornelius

Cornelius Impulse Juice Dispenser 851000109 Guía de configuración

Cornelius

Cornelius IDC 255 Manual de usuario

Cornelius

Cornelius 2232MS Manual

Cornelius

Cornelius Enduro 300 BC Guía de configuración

Cornelius

Cornelius FCB PINNACLE 2 Flavour Manual de usuario

Cornelius

Cornelius IntelliCarb Cold Beverage Dispenser Guía de instalación

Cornelius

Cornelius CB1522 Manual de usuario

Cornelius

Cornelius ED 300 BC Manual de usuario

Cornelius

Cornelius IDC PRO 255 Manual de usuario

Cornelius

Cornelius MILLENNIUM MJ30-4 PB Manual

Cornelius

Cornelius ED 300 BN Manual de usuario

Cornelius

Cornelius Ice Cooled Dispensers Manual de usuario

Cornelius

Cornelius Drop-In Post-Mix Dispenser 2323 Universal Manual de usuario

Cornelius

Cornelius VIPER 4 FLAVOR Manual de usuario

Cornelius

Cornelius Flavorfusion Ice Drink Dispenser with Flavor... Manual de usuario

Cornelius

Cornelius ENDURO 250 Manual de usuario

Cornelius

Cornelius JETSPRAY Guía de configuración

Cornelius

Cornelius TEA URN Manual de usuario

Cornelius

Cornelius 6 Flavor Guía

Cornelius

Cornelius REMCOR R-134A Suplemento

Cornelius

Cornelius A.B.S. Unit Manual de usuario

Manuales populares de Dispensador de bebidas de otras marcas

PEGAS

PEGAS Evolution Manual de usuario

Ugolini

Ugolini MT micro Manual de usuario

Bunn

Bunn SLCA-7 Instrucciones de instalación

Gekkeikan

Gekkeikan Sake Machine Manual de usuario

Olympia

Olympia DH709 Manual de usuario

Marco

Marco ECOSMART PB10 Manual de usuario

Marvel

Marvel ML24BN Series Manual

Cecilware

Cecilware 2K-GB-LD Manual

Sure Vend

Sure Vend 673 Manual de usuario

Nostalgia Electrics

Nostalgia Electrics KEG7000SS Manual de usuario

Bunn

Bunn LCR-3 HV Guía de solución de problemas

Servend

Servend SV-200 Manual de usuario

EdgeStar

EdgeStar VBR440 Manual de usuario

CDS AUTOMATEN

CDS AUTOMATEN ML-16C2-C Manual de usuario

Siemens

Siemens GA 3000 Manual de instrucciones y seguridad

Selbach

Selbach Fruit Juice dispenser Manual de usuario

Taylor

Taylor C302NP Manual de usuario

Vinotemp

Vinotemp VT-WINEDISP2 Manual de usuario