Condair Nortec SAM-e Manual de usuario

DELETE THIS PAGE AFTER PRINTING

OR GENERATING PDF

Nortec

SAM-e

Installation and

Operation Manual

Includes installation, operation

maintenance and troubleshooting

information for your Nortec SAM-e

and Nortec Mini SAM-e Short

Absorption Manifold.

1507619-L| 15 Jan 2020

Important:

Read and save these instructions. This guide to be left with equipment.

Thank you for choosing Condair.

Proprietary Notice

This document and the information disclosed herein are proprietary data of CONDAIR LTD. Neither this

document nor the information contained herein shall be reproduced, used, or disclosed to others without the

written authorization of CONDAIR LTD., except to the extent required for installation or maintenance of

recipient’s equipment. All references to the Condair name should be taken as referring to CONDAIR LTD.

Liability Notice

Condair does not accept any liability for installations of humidity equipment installed by unqualified personnel

or the use of parts/components/equipment that are not authorized or approved by Condair.

INSTALLATION DATE (MM/DD/YYYY)

MODEL #

SERIAL #

Contents

2 Introduction

2 Location of Humidifier’s Manifold in an Air Conditioning System

4 Identify your Components

5 How to Use this Manual

7 Nortec SAM-e In-Duct

15 Installation in Vertical Duct

17 Nortec Mini SAM-e Installation Procedures

21 Plumbing

22 Nortec SAM-e with Pressure Steam

24 Nortec Mini SAM-e with Pressurized Steam

29 Nortec SAM-e with Atmospheric Steam

31 Nortec Mini SAM-e with Atmospheric Steam

33 Atmospheric Steam Lines

34 Plumbing

34 Atmospheric Nortec SAM-e Steam Lines

39 Length of Steam Line Runs

39 Material for Steam Lines

40 Atmospheric Nortec SAM-e Condensate Drainage

41 Steam Lines and Condensate Returns

45 Insulated Nortec SAM-e & Nortec Mini SAM-e

46 Insulation

49 Nortec SAM-e Insulation Retrofit

52 Nortec Mini SAM-e Insulation Retrofit

55 Troubleshooting, Maintenance, Spare Parts

1 | Nortec SAM-e Installation

CAUTION: Plumbing

•Plumbing to be performed by a licensed plumber.

•Drain water from humidifier can be very hot. Do not drain to public sink.

•All plumbing work should be done according to local plumbing code.

CAUTION: Installation

•Do not mount on hot surfaces.

•Do not mount in area where freezing can occur.

•Do not mount on vibrating surface.

•Do not mount on floor.

•The Nortec RH2 produces steam at atmospheric pressure no devices which could

block steam output should be connected to the steam outlet.

•Steam lines must be installed so that no restriction can produce backpressure in

the humidifier.

•

CAUTION: Servicing

•Disconnect main power before any servicing.

•During and following operation of the humidifier, the steam and components in

contact with the steam such as the blower pack, steam lines, steam distributors,

and condensate lines can become hot and can burn if touched.

•Condair does not accept any liability for installations of humidity equipment

installed by unqualified personnel or the use of parts/components/equipment

that are not authorized or approved by Condair.

Nortec SAM-e Installation | 2

Introduction

Receiving and Unpacking Equipment

Check packing slip to ensure ALL material has been delivered. Each humidifier may be shipped

in more than one box.

All material shortages are to be reported to CONDAIR within 48 hours from receipt of goods.

CONDAIR assumes no responsibility for any material shortages beyond this period.

Inspect boxes for damage and note on shipping waybill accordingly.

After unpacking, inspect equipment for damage. If damage is found, notify the shipper promptly.

All CONDAIR products are shipped on an F.O.B. factory basis. Any and all damage, breakage, or loss

claims are to be made to the shipping company.

Location of Humidifier’s Manifold in an Air Conditioning System

Although Nortec SAM-e distribution systems are designed to provide drip-less humidification, several

operating factors related to steam supply may result in excess moisture or water collecting in steam-tube

pipe with the potential for water damage. To ensure protection against water damage, best practice

includes either a sealed section of duct or, preferably a drip-pan with drain installed underneath each

unit. In addition, to facilitate maintenance checks and inspections, an inspection cover, inspection glass

or service opening should be installed downstream.

For more information, see Nortec SAM-e Engineering Manual [1503529-X].

Notes

Absorption distance: the distance between the Nortec SAM-e and the first obstruction (coil, elbow,

damper, etc.) that steam may encounter. Traces of steam may pass the obstruction, but will not

condense, leaving obstructions dry. If any of the duct or air-handling unit (AHU) conditions are changed

between design and installation, calculated absorption distance may change. It is advisable to re-

calculate absorption distance to ensure that Nortec SAM-e operates as intended. If changes are

required, please contact factory for assistance.

3 | Nortec SAM-e Installation

Identify your Components

Nortec SAM-e Installation | 4

Identify your Optional Components

5 | Nortec SAM-e Installation

How to Use this Manual

Nortec SAM-e - In Duct

Section 2

Follow steps 1-8

Nortec SAM-e - Vertical Duct Installation

Section 4

Follow steps 1-8

Then refer to Section 3.

Nortec mini SAM-e

Section 5

Follow steps 1-2

This section includes installation in vertical duct

Nortec SAM-e Installation | 6

Plumbing

Section 6

6A - Nortec SAM-e Pressure Steam

6B - Nortec mini SAM-e Pressure Steam

6C - Nortec SAM-e Atmospheric Steam

6D - Nortec mini SAM-e Atmospheric Steam

Steam Lines

Section 7

Nortec SAM-e Insulation

Section 8

8A - Nortec SAM-e Retrofit

8B - Nortec mini SAM-e Retrofit

Troubleshooting, Spare Parts & Warranty

Section 9

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Humidificador de Condair

Condair

Condair US Series Manual de usuario

Condair

Condair RH Series Manual de usuario

Condair

Condair GS series Manual de usuario

Condair

Condair GS II Series Manual de usuario

Condair

Condair HumiLife RH Series Manual de usuario

Condair

Condair RM Series Manual de usuario

Condair

Condair Nortec GSTC Manual de usuario

Condair

Condair Nortec GS II Series Manual de usuario

Condair

Condair ME series Manual de usuario

Condair

Condair Nortec EL-Series Manual de usuario

Condair

Condair CS 2.0 Manual de usuario

Condair

Condair EL Series Manual de usuario

Condair

Condair GS OC Series Guía

Condair

Condair HumiLife RE Series Manual de usuario

Condair

Condair SOFT 10 Manual de usuario

Condair

Condair DL Manual de usuario

Condair

Condair EL Manual de usuario

Condair

Condair SH2 Manual de usuario

Condair

Condair HP Series Manual de usuario

Condair

Condair ME series Manual de usuario

Condair

Condair MD Series Manual técnico

Condair

Condair Nortec RS Series Manual de instalación y operación

Condair

Condair GS C Series Guía

Condair

Condair CP3 Manual de usuario

Manuales populares de Humidificador de otras marcas

Boneco

Boneco H300 Manual de usuario

Bionaire

Bionaire CM1 Manual

Air-O-Swiss

Air-O-Swiss AOS 7131 Manual

KING

KING K 5002 Rainbow Manual de usuario

Crane

Crane EE-6902 Manual de usuario

Glaziar

Glaziar Ness Manual de usuario

Philips

Philips DreamStation Go Dimensiones

Honeywell

Honeywell MISTMATE HUL520BC Manual de usuario

Stadler Form

Stadler Form Hera Manual de usuario

Hunter

Hunter 31206 Manual de usuario

TaoTronics

TaoTronics TT-AH004 Manual de usuario

adorini

adorini Cigar Heaven Manual de usuario

Lanaform

Lanaform Aroma Manual de usuario

Aprilaire

Aprilaire 800 Series Manual de usuario

Pyle

Pyle SereneLife PHUMDIF8 Manual de usuario

Trotec

Trotec B 200 Manual de usuario

Pure Humidifier

Pure Humidifier EC Series Manual de usuario

Crane

Crane EE-864 Manual de usuario