Cisco ONS 15454 Manual

Cisco ONS 15454 Hardware Installation Guide

First Published: 2016-11-26

Last Modified: 2019-10-04

Americas Headquarters

Cisco Systems, Inc.

170 West Tasman Drive

San Jose, CA 95134-1706

USA

http://www.cisco.com

Tel: 408 526-4000

800 553-NETS (6387)

Fax: 408 527-0883

CONTENTS

Preface xvii

PREFACE

Revision History xviii

Document Objectives xxiii

Audience xxiii

Related Documentation xxiii

Document Conventions xxiii

Obtaining Optical Networking Information xxix

Where to Find Safety and Warning Information xxix

Obtaining Documentation, Obtaining Support, and Security Guidelines xxix

Overview 1

CHAPTER 1

Compliance Standards 1

Cisco ONS 15454 ANSI 1

Cisco ONS 15454 ETSI 2

Cisco ONS 15454 M2 Shelf 2

Cisco ONS 15454 M6 Shelf 4

Preparing to Install the ONS 15454 (ANSI and ETSI), ONS 15454 M2 and ONS 15454 M6 Shelf 7

CHAPTER 2

Important Safety Recommendations 7

Required Tools and Equipment 9

Cisco Supplied Materials 9

User Supplied Materials 11

Ordering Solutions for ONS 15454 M2 and ONS 15454 M6 15

Card Slot Requirements 15

ONS 15454 15

ONS 15454 M2 18

Cisco ONS 15454 Hardware Installation Guide

iii

ONS 15454 M6 19

Card Replacement 19

NTP-G305 Unpack and Inspect the ONS 15454, ONS 15454 M2, and ONS 15454 M6 Shelves 20

DLP-G676 Unpack and Verify the ONS 15454, ONS 15454 M2, and ONS 15454 M6 Shelves 20

DLP-G677 Inspect the ONS 15454, ONS 15454 M2, and ONS 15454 M6 Shelves 21

Installing the ONS 15454 M12 (ANSI and ETSI) Shelf 23

CHAPTER 3

ONS 15454 ANSI Rack Installation 24

Reversible Mounting Bracket 25

Mounting a Single Node 26

Mounting Multiple Nodes 26

ONS 15454 ANSI Bay Assembly 26

ONS 15454 ETSI Rack Installation 27

Mounting a Single Node 28

Mounting Multiple Nodes 29

NTP-G306 Install the ONS 15454 Shelf 31

DLP-G3 Reverse the Mounting Bracket to Fit a 19-inch (482.6-mm) Rack (ANSI Only) 33

DLP-G4 Install the External Brackets and Air Filter (ANSI Only) 34

DLP-G678 Mount the ONS 15454 Shelf in a Rack (One Person) 36

DLP-G679 Mount the ONS 15454 Shelf in a Rack (Two People) 37

DLP-G680 Mount Multiple ONS 15454 Shelf Assemblies in a Rack 39

DLP-G8 Install the Air Ramp 42

Front Door 45

ONS 15454 ANSI Backplane Covers 53

Lower Backplane Cover 54

Rear Cover 54

Alarm Interface Panel 56

Alarm Interface Panel Replacement 56

NTP-G3 Open and Remove the Front Door 56

DLP-G9 Open the Front Cabinet Compartment (Door) 57

DLP-G10 Remove the Front Door 58

NTP-G4 Open and Remove the FMEC Cover (ETSI Only) 60

DLP-G11 Open the FMEC Cover 61

DLP-G12 Remove the FMEC Cover 62

Cisco ONS 15454 Hardware Installation Guide

Contents

NTP-G5 Remove the Backplane Covers (ANSI Only) 63

DLP-G13 Remove the Lower Backplane Cover 64

DLP-G14 Remove the Backplane Sheet Metal Cover 65

ONS 15454 ETSI Front Mount Electrical Connection 65

NTP-G6 Install the MIC-A/P and MIC-T/C/P FMECs (ETSI Only) 66

Power and Ground Description 67

NTP-G7 Install the Power and Ground 68

DLP-G17 Connect Office Power to the ONS 15454 ETSI 70

DLP-G18 Connect Office Power to the ONS 15454 ANSI 71

DLP-G19 Turn On and Verify Office Power 74

Shelf Voltage and Temperature 75

NTP-G230 View Shelf Voltage and Temperature 76

Fan-Tray Assembly 76

Fan-tray Units for ONS 15454 Cards 78

Fan Speed 81

Fan Failure 81

Air Filter 82

NTP-G8 Install the Fan-Tray Assembly 82

ONS 15454 ANSI Alarm Expansion Panel 85

NTP-G9 Install the Alarm Expansion Panel (ANSI Only) 91

ONS 15454 ANSI Alarm, Timing, LAN, and Craft Pin Connections 94

Alarm Contact Connections 97

Timing Connections 98

LAN Connections 98

TL1 Craft Interface Installation 99

NTP-G10 Attach Wires to Alarm, Timing, LAN, and Craft Pin Connections 100

DLP-G20 Install Alarm Wires on the MIC-A/P (ETSI Only) 101

DLP-G21 Install Timing Wires on the MIC-C/T/P (ETSI Only) 104

DLP-G22 Install LAN Wires on the MIC-C/T/P (ETSI Only) 105

DLP-G23 Install Alarm Wires on the Backplane (ANSI Only) 106

DLP-G24 Install Timing Wires on the Backplane (ANSI Only) 109

DLP-G25 Install LAN Wires on the Backplane (ANSI Only) 110

DLP-G26 Install the TL1 Craft Interface Wires (ANSI Only) 111

NTP-G11 Install an External Wire-Wrap Panel on the AEP (ANSI Only) 112

Cisco ONS 15454 Hardware Installation Guide

Contents

NTP-G12 Install and Close the FMEC Cover (ETSI Only) 117

NTP-G13 Install the Rear Cover (ANSI Only) 118

Typical DWDM Rack Layouts 120

NTP-G14 Install DWDM Equipment 123

DLP-G27 Install the DCU Shelf 123

DLP-G28 Install the Fiber Patch-Panel Tray 124

DLP-G29 Install the Fiber-Storage Tray 125

DLP-G371 Install the Ethernet Adapter Panel 126

DLP-G352 Install the Y-Cable Module Tray 126

DLP-G30 Install the FlexLayer Shelf 127

DLP-G31 Install the FlexLayer Modules 128

DLP-G32 Install the Y-Cable Protection Modules in the FlexLayer Shelf 129

DLP-G377 Install the Y-Cable Protection Modules in the Y-Cable Module Tray 130

NTP-G15 Install the Common Control Cards 131

DLP-G33 Install the TCC2, TCC2P, or TCC3 Card 132

DLP-G34 Install the AIC-I Card 135

DLP-G309 Install the MS-ISC-100T Card 136

Multishelf Management 137

Multishelf LAN Topologies 137

ONS 15454 Multishelf Node and Subtending Shelves 138

ONS 15454 Multishelf Node and Subtending Shelves—Upgrade 138

NTP-G301 Connect the ONS 15454 Multishelf Node and Subtending Shelves to an MS-ISC-100T

Card 138

NTP-G304 Configure the MS-ISC-100T Card for a ONS 15454 Multishelf Node for Non-Default Public

and Private VLAN IDs 141

NTP-G307 Perform the ONS 15454 Shelf Installation Acceptance Test 143

DLP-G35 Inspect the Shelf Installation and Connections 145

DLP-G36 Measure Voltage 146

NTP-G295 Connect the ONS 15454 Multishelf Node and Subtending Shelves to a Catalyst 2950 or

Catalyst 3560 146

NTP-G296 Upgrade the ONS 15454 Multishelf with MS-ISC Card Configuration Using the Catalyst

3560 148

NTP-G297 Upgrade the ONS 15454 Multishelf with Catalyst 2950 Configuration Using the Catalyst

3560 150

Cisco ONS 15454 Hardware Installation Guide

Contents

NTP-G298 Configure a Cisco Catalyst 2950 or Catalyst 3560 (Active and Standby) for a ONS 15454

Multishelf Node 152

Ethernet Adapter Panel 154

Filler and Blank Cards 156

Cable Routing and Management 157

Fiber Management 158

Fiber Management Using the Patch-Panel Trays 160

Standard and Deep Patch-Panel Trays (32-Channel) 160

40-Channel Patch-Panel Tray 161

Mesh Patch-Panel Tray 162

Install PP-Mesh 163

Install PP-Mesh on an ANSI 19" Configuration 164

Install PP-Mesh on an ANSI 23" Configuration 167

Install PP-Mesh on an ETSI Configuration 171

Fiber Management Using the Y-Cable Module Tray 173

Fiber Management Using the Fiber-Storage Tray 173

Fiber Management Using the Optional ANSI Tie-Down Bar 175

Installing the ONS 15454 M2 Shelf 177

CHAPTER 4

Installing the ONS 15454 M2 Shelf 177

ANSI Rack Installation 177

Mounting Brackets 178

Mounting a Single Node 179

ETSI Rack Installation 179

Mounting a Single Node 180

Wall Mounting the ONS 15454 M2 Shelf 180

Desktop Mounting the ONS 15454 M2 Shelf 181

Air Deflector 181

Air Plenum 181

Air Plenum Rack and Cabinet Compatibility 182

NTP-G343 Install the Air Plenum in ONS 15454 M2 Shelf 183

DLP-G763 Install Air Plenum for ONS 15454 M2 Shelf in ANSI 19-inch Configuration 185

DLP-G764 Install Air Plenum in ONS 15454 M2 Shelf for ANSI 23-inch Configuration 187

DLP-G765 Install Air Plenum for ONS 15454 M2 Shelf in ETSI Configuration 191

Cisco ONS 15454 Hardware Installation Guide

vii

Contents

NTP-G266 Install the ONS 15454 M2 Shelf 194

DLP-G582 Mounting the 19-inch Brackets on the ONS 15454 M2 Shelf for ANSI Rack

Configuration 197

DLP-G583 Mounting the 23-inch Brackets on the ONS 15454 M2 Shelf for ANSI Rack

Configuration 198

DLP-G584 Mounting the Bracket with Air Deflectors (Front-to-Back) on the ONS 15454 M2

Shelf for ANSI Rack Configuration 199

DLP-G585 Mounting the Brackets on the ONS 1545 M2 Shelf for ETSI Rack Configuration 202

DLP-G586 Mounting the Air Deflectors (Front-to-Front) on the ONS 15454 M2 Shelf for ETSI

Rack Configuration 203

DLP-G587 Mounting the Bracket with Air Deflectors (Front-to-Back) on the ONS 15454 M2

Shelf for ETSI Rack Configuration 205

DLP-G588 Mounting the Bracket with Air Deflectors (Front-to-Top) on the ONS 15454 M2 Shelf

for ETSI Rack Configuration 208

DLP-G589 Mount the ONS 15454 M2 Shelf on a Rack (One Person) 209

DLP-G590 Mount the ONS 15454 M2 Shelf on the Wall 211

DLP-G591 Mount the ONS 15454 M2 Shelf on the Desktop 214

Front Door 215

NTP-G269 Install the Standard Door of the ONS 15454 M2 Shelf 216

NTP-G270 Open and Remove the Standard Door of the ONS 15454 M2 Shelf 218

DLP-G594 Open the Standard Door of the ONS 15454 M2 Shelf 219

DLP-G595 Remove the Standard Door of the ONS 15454 M2 Shelf 220

NTP-G343 Install the Deep-Front Panel of the ONS 15454 M2 Shelf 222

NTP-G331 Remove the Deep-Front Panel of the ONS 15454 M2 Shelf 226

Power Modules 228

AC Power Module 229

DC Power Module 230

NTP-G267 Install the Power Module in the ONS 15454 M2 Shelf 230

DLP-G592 Install the AC Power Module in the ONS 15454 M2 Shelf 231

DLP-G593 Install the DC Power Module in the ONS 15454 M2 Shelf 233

Fan-Tray Assembly 234

Fan Speed 235

Fan Failure 235

NTP-G268 Install the Fan-Tray Assembly in the ONS 15454 M2 Shelf 235

Power and Ground Description 237

Cisco ONS 15454 Hardware Installation Guide

viii

Contents

ANSI Power and Ground 238

ETSI Power and Ground 238

NTP-G271 Install the Power and Ground to the ONS 15454 M2 Shelf 239

DLP-G596 Connect Office Power (AC) to the ONS 15454 M2 Shelf 241

DLP-G597 Connect Office Power (DC) to the ONS 15454 M2 Shelf (ANSI Only) 244

DLP-G598 Connect Office Power (DC) to the ONS 15454 M2 Shelf (ETSI Only) 249

DLP-G599 Turn On and Verify AC Office Power on the ONS 15454 M2 Shelf 251

DLP-G600 Turn On and Verify DC Office Power on the ONS 15454 M2 Shelf 252

NTP-G291 Attach Wires to Timing, LAN, and Craft Pin Connections in ONS 15454 M2 254

DLP-G292 Install Timing Wires in ONS 15454 M2 - ANSI 255

DLP-G293 Install Timing Wires in ONS 15454 M2 - ETSI 257

DLP-G294 Install LAN Wires in ONS 15454 M2 261

NTP-G313 Install and Configure the TNC, TNCE, TSC, or TSCE Card 261

DLP-G604 Install the TNC, TNCE, TSC, or TSCE Card 262

DLP-G605 Provision PPM and Port for the TNC and TNCE Cards 265

DLP-G606 Configure UDC and VoIP for the TNC and TNCE Cards 266

NTP-G275 Perform the ONS 15454 M2 Shelf Installation Acceptance Test 267

DLP-G601 Inspect the ONS 15454 M2 Shelf Installation and Connections 268

DLP-G602 Measure DC Voltage on the ONS 15454 M2 Shelf 268

Filler and Blank Cards 269

Air Filter 270

Shelf Voltage and Temperature 270

Installing the ONS 15454 M6 Shelf 271

CHAPTER 5

ANSI Rack Installation 272

Reversible Mounting Bracket 273

Mounting a Single Shelf 273

Mounting Multiple Nodes 274

ETSI Rack Installation 274

Mounting a Single Node 275

Mounting Multiple Nodes 276

Air Deflector 276

Air Plenum 276

Air Plenum Rack and Cabinet Compatibility 278

Cisco ONS 15454 Hardware Installation Guide

Contents

NTP-G344 Install the Air Plenum in ONS 15454 M6 Shelf 279

DLP-G766 Install Air Plenum for ONS 15454 M6 Shelf in ANSI 19-inch Cabinet 280

DLP-G767 Install Air Plenum in ONS 15454 M6 Shelf for ANSI 23-inch Configuration 284

DLP-G768 Install Pre-assembled Air Plenums in ANSI 23-inch Configuration 287

DLP-G769 Install Air Plenum for ONS 15454 M6 Shelf in ETSI Configuration 289

Air Flow Performance of ONS 15454 M6 293

NTP-G252 Install the ONS 15454 M6 Shelf 294

DLP-G674 Verify the ONS 15454 M6 Shelf for AC Power Module Installation 297

DLP-G675 Verify the ONS 15454 M6 Shelf for DC Power Module Installation 298

DLP-G560 Mounting the Reversible Brackets on the ONS 15454 M6 Shelf for ANSI Rack

Configuration 299

DLP-G561 Mounting the Bracket with Air Deflectors (Front-to-Back) on the ONS 15454 M6 Shelf

for ANSI Rack Configuration 302

DLP-G562 Mounting the Brackets on the ONS 15454 M6 Shelf for ETSI Rack Configuration 304

DLP-G563 Mounting the Air Deflectors (Front-to-Front) on the ONS 15454 M6 Shelf for ETSI Rack

Configuration 306

DLP-G564 Mounting the Bracket with Air Deflectors (Front-to-Back) on the ONS 15454 M6 Shelf

for ETSI Rack Configuration 307

DLP-G565 Mounting the Bracket with Air Deflectors (Front-to-Top) on the ONS 15454 M6 Shelf

for ETSI Rack Configuration 309

DLP-G821 Mounting the Bracket with Air Deflectors (Front-to-Side) on the ONS 15454 M6 Shelf

for ETSI Rack Configuration 313

DLP-G566 Mount the ONS 15454 M6 Shelf on a Rack (One Person) 315

DLP-G567 Mount the ONS 15454 M6 Shelf on a Rack (Two People) 317

DLP-G568 Mount Multiple ONS 15454 M6 Shelves on a Rack 318

Front Door 320

NTP-G258 Install the Standard Door of the ONS 15454 M6 Shelf 323

NTP-G259 Open and Remove the Standard Door of the ONS 15454 M6 Shelf 327

DLP-G576 Open the Standard Door of the ONS 15454 M6 Shelf 328

DLP-G577 Remove the Standard Door of the ONS 15454 M6 Shelf 330

NTP-G327 Install the Deep-Front Panel of the ONS 15454 M6 Shelf 332

NTP-G329 Remove the Deep-Front Panel of the ONS 15454 M6 Shelf 339

External Connection Units 342

ECU 342

ECU2 343

Cisco ONS 15454 Hardware Installation Guide

Contents

Otros manuales para ONS 15454

Tabla de contenidos

Otros manuales de Servidor de Cisco

Cisco

Cisco c240 Instrucciones de instalación y mantenimiento

Cisco

Cisco Meraki MX65 Manual de usuario

Cisco

Cisco UCS C220 M3 Manual del sistema

Cisco

Cisco AS5300 - Universal Access Server Manual de usuario

Cisco

Cisco Nexus 7000 Series Manual de usuario

Cisco

Cisco NAC-3300 Series Manual de usuario

Cisco

Cisco UCS 5108 Manual de usuario

Cisco

Cisco UCS B420 M3 Manual

Cisco

Cisco C880 M4 Manual de usuario

Cisco

Cisco UCS C210 Instrucciones de instalación y mantenimiento

Cisco

Cisco UCS B420 M3 Manual de usuario

Cisco

Cisco ISE-3315 Manual de usuario

Cisco

Cisco TelePresenceMCU 5300 Series Manual de usuario

Cisco

Cisco VPN 3002 Hardware Client Manager Manual de usuario

Cisco

Cisco UCS C24 Instrucciones de instalación y mantenimiento

Cisco

Cisco Content Delivery Engine CDE100 Manual

Cisco

Cisco UCS B440 M2 Manual del sistema

Cisco

Cisco UCS 5100 Guía rápida

Cisco

Cisco UCS C240 M3 Manual de usuario

Cisco

Cisco Sourcefire Defense Center 750 Manual de usuario

Cisco

Cisco UCS 5100 Manual de uso y cuidado

Cisco

Cisco TelePresence Video Communication Server... Manual de usuario

Cisco

Cisco UCS C200 Manual

Cisco

Cisco APIC M4 Instrucciones de instalación y mantenimiento

Manuales populares de Servidor de otras marcas

HP AlphaServer ES47 Manual de usuario

Dell

Dell PowerEdge R410 Manual de usuario

PowerNAS

PowerNAS CMA Manual de usuario

Supero

Supero FatTwin F617R3-FT Manual de usuario

MSI

MSI P1-109N-L70 Manual de usuario

Dell

Dell PowerEdge XE9640 Manual

Dell

Dell PS4100 Instrucciones de montaje

EtroVISION

EtroVISION EV3151 Manual de usuario

NEC

NEC Express5800/T110j Manual de usuario

HP ProLiant Gen9 Manual de usuario

Compaq

Compaq ProLiant 3000 Manual

Dell

Dell PowerEdge 3YPMN Manual de usuario

iRobo

iRobo IPC2U Manual de usuario

Nortel

Nortel 1000 Con?guration guide Manual de usuario

Asus

Asus AP7500 Manual de operación y mantenimiento

Avid Technology

Avid Technology AirSpeed 5000 Manual de usuario

HP Integrity rx2600 Guía de instalación

Milestone

Milestone Husky IVO 350T Manual de usuario