Alliance Laundry Systems UT025 Manual del propietario

Programming

Drying Tumblers

Refer to page 3 for Model Numbers

Part No. 70381401R5

February 2008

Keep These Instructions for Future Reference.

(If this machine changes ownership, this manual must accompany machine.)

70381401 1

Installation must conform with local codes or in the absence of local codes with:

In the U.S.A., installation must conform to the latest edition of the American National Standard Z223.1/NFPA 54

“National Fuel Gas Code” and Standard ANSI/NFPA 70 “National Electric Code.”

In Canada, installation must comply with Standards CSA B149.1 or Natural Gas and Propane Code CSA C22.1,

latest edition, Canadian Electric Code, Part I.

In Australia, installation must comply with the Australian Gas Association Installation Code for Gas Burning

Appliances and Equipment.

IMPORTANT: Information must be obtained from a local gas supplier on instructions to be followed if the

user smells gas. These instructions must be posted in a prominent location. Step-by-step instructions of the

above safety information must be posted in a prominent location near the tumbler for customer use.

FOR YOUR SAFETY, the information in this

manual must be followed to minimize the

risk of fire or explosion or to prevent

property damage, personal injury or death.

W033

• Do not store or use gasoline or other

flammable vapors and liquids in the

vicinity of this or any other appliance.

• WHAT TO DO IF YOU SMELL GAS:

– Do not try to light any appliance.

– Do not touch any electrical switch; do

not use any phone in your building.

– Clear the room, building or area of all

occupants.

– Immediately call your gas supplier from

a neighbor’s phone. Follow the gas

supplier’s instructions.

– If you cannot reach your gas supplier,

call the fire department.

• Installation and service must be

performed by a qualified installer, service

agency or the gas supplier. W052

WARNING

FOR YOUR SAFETY

Do not store or use gasoline or other

flammable vapors and liquids in the

vicinity of this or any other appliance. W053

POUR VOTRE SÉCURITÉ, les informations

de ce guide doivent être respectées afin de

réduire les risques d’incendie, d’explosion

ou d’éviter les dommages matériels,

personnels ou blessures mortelles. W033R3QU

• Ne pas entreposer ou utiliser d’essence

ou toutes autres vapeurs et liquides

inflammables à proximité de cette

machine ou de tout autre appareil.

• QUE FAIRE EN CAS D’ODEUR DE GAZ :

– Ne pas mettre d’appareil en marche.

– Ne pas toucher aux interrupteurs

électriques ; ne pas utiliser le

téléphone des lieux.

– Évacuer la pièce, le bâtiment ou la zone

de tous les occupants.

– Appeler immédiatement le fournisseur

de gaz de la maison d’un voisin.

Respecter les instructions

communiquées par le fournisseur.

– Si vous ne pouvez pas joindre le

fournisseur de gaz, appeler le service

d’incendie.

• L’installation et l’entretien doivent être

effectués par un installateur, service

d’entretien qualifiés ou par le fournisseur

de gaz.

W052R5QU

MISE EN GARDE

POUR VOTRE SÉCURITÉ

Ne pas entreposer ou utiliser d’essence

ou toutes autres vapeurs et liquides

inflammables à proximité de cette unité

ou de tout autre appareil. W053R2QU

means without the expressed written consent of the publisher.

270381401

Table of

Contents

Introduction......................................................................................... 3

Model Identification ............................................................................. 3

Customer Service.................................................................................. 5

Wiring Diagram .................................................................................... 5

Safety Information.............................................................................. 6

Important Safety Instructions ............................................................... 7

Programming the Electronic OPL Control...................................... 9

Introduction to Programming ............................................................... 9

Signal .................................................................................................... 10

Reversing .............................................................................................. 10

Status Lights ......................................................................................... 10

Automatic Dry and Condition Mode .................................................... 11

Time Dry and No Heat Modes.............................................................. 12

Custom.................................................................................................. 13

Custom Cycle Record ..................................................................... 13

Special Cycle Mode.............................................................................. 14

Special Time Mode............................................................................... 14

Security Lock-Out ................................................................................ 14

Show Mode........................................................................................... 14

Temperature Sensor .............................................................................. 15

Temperature Adjustment ...................................................................... 15

Temperature Display (°F/°C)................................................................ 15

Cylinder Temperature Display ............................................................. 15

70381401

Introduction

Model Identification

Information in this manual is applicable to these

models:

Gas Steam/Thermal Oil Electric

25 Pound

HA025L

HA025N

HT025L

HT025N

HU025L

HU025N

LA025L

LA025N

LT025L

LT025N

LU025L

LU025N

PA025L

PA025N

PT025L

PT025N

PU025L

PU025N

SA025L

SA025N

ST025L

ST025N

SU025L

SU025N

UA025L

UA025N

UT025L

UT025N

UU025L

UU025N

HT025S

HU025S

LT025S

LU025S

PT025S

PU025S

ST025S

SU025S

UT025S

UU025S

HT025E

HU025E

LT025E

LU025E

PT025E

PU025E

ST025E

SU025E

UT025E

UU025E

30 Pound

HA030L

HA030N

HT030L

HT030N

HU030L

HU030N

LA030L

LA030N

LT030L

LT030N

LU030L

LU030N

PA030L

PA030N

PT030L

PT030N

PU030L

PU030N

SA030L

SA030N

ST030D

ST030L

ST030N

SU030L

SU030N

UA030L

UA030N

UT030L

UT030N

UU030L

UU030N

HT030S

HU030S

LT030S

LU030S

PT030S

PU030S

ST030S

SU030S

UT030S

UU030S

HT030E

HU030E

LT030E

LU030E

PT030E

PU030E

ST030E

SU030E

UT030E

UU030E

35 Pound

AT035L

AT035N

HA035L

HA035N

HT035L

HT035N

HU035L

HU035N

LA035L

LA035N

LT035L

LT035N

LU035L

LU035N

PA035L

PA035N

PT035L

PT035N

PU035L

PU035N

SA035L

SA035N

ST035L

ST035N

SU035L

SU035N

UA035L

UA035N

UT035L

UT035N

UU035L

UU035N

AT035S

HT035S

HU035S

LT035S

LU035S

PT035S

PU035S

ST035S

SU035S

UT035S

UU035S

HT035E

HU035E

LT035E

LU035E

PT035E

PU035E

ST035E

SU035E

UT035E

UU035E

50 Pound

AT050L

AT050N

GT050L

GT050N

GU050L

GU050N

HA050L

HA050N

HT050L

HT050N

HU050L

HU050N

LA050L

LA050N

LT050L

LT050N

LU050L

LU050N

NT050L

NT050N

PT050L

PT050N

PU050L

PU050N

SA050L

SA050N

ST050D

ST050L

ST050N

SU050L

SU050N

UA050L

UA050N

UT050L

UT050N

UU050L

UU050N

AT050S

GU050S

HT050S

HT050T

HU050S

HU050T

LT050S

LT050T

LU050S

LU050T

PT050S

PT050T

PU050S

PU050T

ST050S

ST050T

SU050S

SU050T

UT050S

UT050T

UU050S

UU050T

AT050E

GU050E

HT050E

HU050E

LT050E

LU050E

PT050E

PU050E

ST050E

SU050E

UT050E

UU050E

Models continued on next page.

Introduction

70381401

Includes models with the following control suffixes:

OM – OPL micro RM – reversing OPL micro

(Continued)

Gas Steam/Thermal Oil Electric

55 Pound

HA055L

HA055N

HT055L

HT055N

HU055L

HU055N

SA055L

SA055N

ST055L

ST055N

SU055L

SU055N

UA055L

UA055N

UT055L

UT055N

UU055L

UU055N

Not Applicable

HT055E

HU055E

ST055E

SU055E

UT055E

UU055E

75 Pound

AT075L

AT075N

HA075L

HA075N

HT075L

HT075N

HU075L

HU075N

LA075L

LA075N

LT075L

LT075N

LU075L

LU075N

NT075L

NT075N

PT075L

PT075N

PU075L

PU075N

SA075L

SA075N

ST075D

ST075L

ST075N

STF75L

STF75N

SU075L

SU075N

UA075L

UA075N

UT075L

UT075N

UTF75L

UTF75N

UU075L

UU075N

AT075S

HT075S

HT075T

HU075S

HU075T

LT075S

LT075T

LU075S

LU075T

PT075S

PT075T

PU075S

PU075T

ST075S

ST075T

SU075S

SU075T

UT075S

UT075T

UU075S

UU075T

AT075E

HT075E

HU075E

LT075E

LU075E

PT075E

PU075E

ST075E

SU075E

UT075E

UU075E

120 Pound

AT120L

AT120N

HA120L

HA120N

HT120L

HT120N

HU120L

HU120N

LA120L

LA120N

LT120L

LT120N

LU120L

LU120N

PT120L

PT120N

PU120L

PU120N

SA120L

SA120N

ST120L

ST120N

SU120L

SU120N

UA120L

UA120N

UT120L

UT120N

UU120L

UU120N

WT120L

WT120N

XT120L

XT120N

XU120L

XU120N

AT120S

HT120S

HT120T

HU120S

HU120T

LT120S

LT120T

LU120S

LU120T

PT120S

PT120T

PU120S

PU120T

ST120S

ST120T

SU120S

SU120T

UT120S

UT120T

UU120S

UU120T

WT120S

WT120T

XT120S

XT120T

XU120S

XU120T

YU120S

YU120T

Not Applicable

170 Pound

AT170L

AT170N

HA170L

HA170N

HT170L

HT170N

HU170L

HU170N

LA170L

LA170N

LT170L

LT170N

LU170L

LU170N

PT170L

PT170N

PU170L

PU170N

SA170L

SA170N

ST170L

ST170N

SU170L

SU170N

UA170L

UA170N

UT170L

UT170N

UU170L

UU170N

WT170L

WT170N

XT170L

XT170N

XU170L

XU170N

AT170S

HT170S

HT170T

HU170S

HU170T

LT170S

LT170T

LU170S

LU170T

PT170S

PT170T

PU170S

PU170T

ST170S

ST170T

SU170S

SU170T

UT170S

UT170T

UU170S

UU170T

WT170S

WT170T

XT170S

XT170T

XU170S

XU170T

Not Applicable

Introduction

70381401

Customer Service

If literature or replacement parts are required, contact

the source from which the machine was purchased or

contact Alliance Laundry Systems at (920) 748-3950

for the name and address of the nearest authorized

parts distributor.

For technical assistance, call (920) 748-3121.

Wiring Diagram

The wiring diagram is located in the junction or

contactor box.

670381401

Safety Information

Precautionary statements (“DANGER,” “WARNING”

and “CAUTION”), followed by specific instructions,

are found in this manual and on machine decals. These

precautions are intended for the personal safety of the

operator, user, servicer and those maintaining the

machine.

Additional precautionary statements (“IMPORTANT”

and “NOTE”) are followed by specific instructions.

IMPORTANT: The word “IMPORTANT” is used

to inform the reader of specific procedures where

minor machine damage will occur if the procedure

is not followed.

NOTE: The word “NOTE” is used to communicate

installation, operation, maintenance or servicing

information that is important but not hazard

related.

IMPORTANT: Warranty is void unless drying

tumbler is installed according to instructions in the

Installation Manual. Compliance with minimum

specifications and requirements detailed herein,

and with applicable local gas fitting regulations,

municipal building codes, water supply regulations,

electrical wiring regulations, and any other

relevant statutory regulations. Because of varied

requirements, applicable local codes should be

thoroughly understood and all pre-installation

work arranged for accordingly.

NOTE: The WARNING and IMPORTANT

instructions appearing in this manual are not meant

to cover all possible conditions and situations that

may occur. It must be understood that common

sense, caution and carefulness are factors which

CANNOT be built into this tumbler. These factors

MUST BE supplied by the person(s) installing,

maintaining or operating the tumbler.

Always contact your dealer, distributor, service agent

or the manufacturer on any problems or conditions you

do not understand.

Indicates an imminently hazardous

situation that, if not avoided, will cause

severe personal injury or death.

DANGER

Indicates a hazardous situation that, if not

avoided, could cause severe personal

injury or death.

WARNING

Indicates a hazardous situation that, if not

avoided, may cause minor or moderate

personal injury or property damage.

CAUTION

Failure to install, maintain, and/or operate

this machine according to manufacturer’s

instructions may result in conditions which

can produce serious injury, death and/or

property damage. W051R1

WARNING

Safety Information

70381401

Important Safety Instructions

Save These Instructions

1. Read all instructions before using the tumbler.

2. Refer to the Grounding Instructions for the

proper grounding of the tumbler.

3. Do not dry articles that have been previously

cleaned in, washed in, soaked in, or spotted with

gasoline, dry-cleaning solvents, or other

flammable or explosive substances as they give

off vapors that could ignite or explode.

4. Do not allow children on or in the tumbler. This

appliance is not intended for use by young

children or infirm persons without supervision.

Young children should be supervised to ensure

that they do not play with the appliance.

5. Before the tumbler is removed from service or

discarded, remove the door to the drying

compartment and the door to the lint

compartment.

6. Do not reach into the tumbler if the cylinder is

revolving.

7. Do not install or store the tumbler where it will

be exposed to water and/or weather.

8. Do not tamper with the controls.

9. Do not repair or replace any part of the tumbler,

or attempt any servicing unless specifically

recommended in the user-maintenance

instructions or in published user-repair

instructions that you understand and have the

skills to carry out.

10. Do not use fabric softeners or products to

eliminate static unless recommended by the

manufacturer of the fabric softener or product.

11. To reduce the risk of fire, DO NOT DRY plastics

or articles containing foam rubber or similarly

textured rubberlike materials.

12. Always clean the lint filter daily.

13. Keep area around the exhaust opening and

adjacent surrounding area free from the

accumulation of lint, dust, and dirt.

14. The interior of the tumbler and the exhaust duct

should be cleaned periodically by qualified

service personnel.

15. If not installed, operated and maintained in

accordance with the manufacturer’s instructions

or if there is damage to or mishandling of this

product’s components, use of this product could

expose you to substances in the fuel or from fuel

combustion which can cause death or serious

illness and which are known to the State of

California to cause cancer, birth defects or other

reproductive harm.

16. Tumbler will not operate with the loading door

open. DO NOT bypass the door safety switch to

permit the tumbler to operate with the door open.

The tumbler will stop tumbling when the door is

opened. Do not use the dryer if it does not stop

tumbling when the door is opened or starts

tumbling without pressing or turning the START

mechanism. Remove the tumbler from use and

call the service person.

17. Tumbler will not operate with lint panel open.

DO NOT bypass lint panel safety switch to

permit the tumbler to operate with the lint panel

open.

18. Do not put articles soiled with vegetable or

cooking oil in the tumbler, as these oils may not

be removed during washing. Due to the

remaining oil, the fabric may catch on fire by

itself.

19. To reduce the risk of fire, DO NOT put clothes

which have traces of any flammable substances

such as machine oil, flammable chemicals,

thinner, etc. or anything containing wax or

chemicals such as in mops and cleaning cloths, or

anything dry-cleaned at home with dry-cleaning

solvent in the tumbler.

20. Use the tumbler only for its intended purpose,

drying water-washed fabrics.

21. ALWAYS disconnect the electrical power to the

tumbler before servicing. Disconnect power by

shutting off appropriate breaker or fuse.

22. Install this tumbler according to the Installation

Instructions. All connections for electrical

power, grounding, and gas supply must comply

with local codes and be made by licensed

personnel when required.

Hazardous Voltage. Can cause shock, burn

or cause death. Allow machine power to

remain off for two minutes prior to working

in and around AC inverter drive. W359

WARNING

Safety Information

70381401

23. Remove laundry immediately after tumbler stops.

24. Always read and follow manufacturer’s

instructions on packages of laundry and cleaning

aids. Heed all warnings or precautions. To reduce

the risk of poisoning or chemical burns, keep

them out of reach of children at all times

(preferably in a locked cabinet).

25. Do not tumble fiberglass curtains and draperies

unless the label says it can be done. If they are

dried, wipe out the cylinder with a damp cloth to

remove particles of fiberglass.

26. Always follow the fabric care instructions

supplied by the garment manufacturer.

27. Never operate the tumbler with any guards and/or

panels removed.

28. DO NOT operate the tumbler if it is smoking,

grinding or has missing or broken parts.

29. DO NOT bypass any safety devices.

30. Solvent vapors from dry-cleaning machines

create acids when drawn through the heater of the

drying unit. These acids are corrosive to the

tumbler as well as to the laundry load being

dried. Be sure make-up air is free of solvent

vapors.

31. Failure to install, maintain and/or operate this

machine according to the manufacturer’s

instructions may result in conditions which can

produce bodily injury and/or property damage.

To reduce the risk of serious injury, install

lockable door(s) to prevent public access to

rear of tumblers. W055

WARNING

Este manual sirve para los siguientes modelos

258

Tabla de contenidos

Otros manuales de Secadora de Alliance Laundry Systems

Alliance Laundry Systems

Alliance Laundry Systems CHD25G2-CA025L Manual del propietario

Alliance Laundry Systems

Alliance Laundry Systems DRY725C Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems ADEE9BGS433XW34 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems LES33 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems Drying Tumbler 110 Pound Capacity Part No.... Manual de instalación y operación

Alliance Laundry Systems

Alliance Laundry Systems Speed Queen DR7004WE Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems HE-HG Seies Instrucciones de montaje

Alliance Laundry Systems

Alliance Laundry Systems SFG109*F Guía

Alliance Laundry Systems

Alliance Laundry Systems W800 Guía de solución de problemas

Alliance Laundry Systems

Alliance Laundry Systems 800795 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems 25 Pound Capacity Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems IGHP190E Manual del propietario

Alliance Laundry Systems

Alliance Laundry Systems LES33A F4562 Series Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems Speed Queen DF7000WG Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems 513123 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems CA170L Manual del propietario

Alliance Laundry Systems

Alliance Laundry Systems 513257R1 Guía

Alliance Laundry Systems

Alliance Laundry Systems LTS97A*N Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems AT170FG Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems CHD25G2-CT025L Instrucciones de funcionamiento

Alliance Laundry Systems

Alliance Laundry Systems 70420801 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems FES17AxF Instrucciones de montaje

Alliance Laundry Systems

Alliance Laundry Systems DR5004WE Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems AE Series Manual de usuario

Manuales populares de Secadora de otras marcas

Bosch

Bosch WTA79200GB Manual de usuario

Amana

Amana W10233410A Manual de usuario

Miele

Miele TWH 780 WP Manual de usuario

Asko

Asko T760 Manual de usuario

Bosch

Bosch Logixx 10 WTB76556GB Hoja de especificaciones

STIEBEL ELTRON

STIEBEL ELTRON Ultronic S Manual de instrucciones

Electrolux

Electrolux EW2H328R2 Manual de usuario

Beko

Beko DS8433RX1M Manual de usuario

Dawlance

Dawlance Spinner DS 6000 C Manual de usuario

Electrolux

Electrolux TP5080TW Manual de usuario

AEG

AEG TR838P4OB Manual de usuario

Indesit

Indesit IDV 75 Manual de usuario

Infiniton

Infiniton SD-DG85C Manual de usuario

BOMANN

BOMANN WT 5019 Manual de usuario

Asko

Asko T793C Manual de usuario

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer Manual de usuario

Frigidaire

Frigidaire CAQE7077KW0 Manual del propietario

Bosch

Bosch WTX8HKM9SN Manual de usuario