Alliance Laundry Systems 25 Pound Capacity Manual de usuario

Installation/Operation/Maintenance

Tumble Dryers

25 Pound (11.3 Kilogram) Capacity

30 Pound (13.6 Kilogram) Capacity

35 Pound (16 Kilogram) Capacity

Stacked 30 Pound (13.6 Kilogram) Capacity

Stacked 45 Pound (20.4 Kilogram) Capacity

55 Pound (25 Kilogram) Capacity

Starting Serial No. 0602004144

Refer to Page 9 for Model Identification

START

25C

HIGH

TEMP

MED

TEMP

LOW

TEMP

HEAT

123

SELECT

TEMP

INSERT

COIN

PUSH

START

123

SELECT

TEMP

INSERT

COIN

PUSH

START

25C

HIGH

TEMP

MED

TEMP

LOW

TEMP

HEAT

TMB1278C_SVG

Original Instructions

Keep These Instructions for Future Reference.

(If this machine changes ownership, this manual must accompany machine.)

www.alliancelaundry.com Part No. 70458301ENR9

September 2014

Front Matter

Installation must conform with local codes or, in the absence of local codes, with:

In the U.S.A., installation must conform to the latest edition of the American National Standard Z223.1/ NFPA 54 “National Fuel Gas

Code” and Standard ANSI/NFPA 70 “National Electric Code.”

In Canada, installation must comply with Standards CAN/CSA-B149.1 or Natural Gas and Propane Installation Code and CSA C22.1,

latest edition, Canadian Electric Code, Part I.

In Australia and New Zealand, installation must comply with the Gas Installations Standard AS/NZS 5601 Part 1: General Installa-

tions.

WARNING

FOR YOUR SAFETY, the information in this manual must be followed to minimize the risk of fire or explosion

or to prevent property damage, personal injury or death.

W033

WARNING

• Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appli-

ance.

• WHAT TO DO IF YOU SMELL GAS:

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use any phone in your building.

• Clear the room, building or area of all occupants.

• Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

• If you cannot reach your gas supplier, call the fire department.

• Installation and service must be performed by a qualified installer, service agency or the gas supplier.

W052

IMPORTANT: Information must be obtained from a local gas supplier on instructions to be followed if the user

smells gas. These instructions must be posted in a prominent location. Step-by-step instructions of the above

safety information must be posted in a prominent location near the tumble dryer for customer use.

IMPORTANT: The installer must fully test the tumble dryer after installation and demonstrate to the owner how to

operate the machine.

WARNING

To reduce the risk of electric shock, fire, explosion, serious injury or death:

• Disconnect electric power to the tumble dryer before servicing.

• Close gas shut-off valve to gas tumble dryer before servicing.

• Close steam valve to steam tumble dryer before servicing.

• Never start the tumble dryer with any guards/panels removed.

• Whenever ground wires are removed during servicing, these ground wires must be reconnected to ensure

that the tumble dryer is properly grounded.

W002R1

Front Matter

Part No. 70458301ENR9 © Copyright, Alliance Laundry Systems LLC - DO NOT COPY or TRANSMIT 3

WARNING

• Installation of unit must be performed by a qualified installer.

• Install tumble dryer according to manufacturer’s instructions and local codes.

• DO NOT install a tumble dryer with flexible plastic venting materials. If flexible metal (foil type) duct is instal-

led, it must be of a specific type identified by the appliance manufacturer as suitable for use with tumble

dryer. Refer to section on connecting exhaust system. Flexible venting materials are known to collapse, be

easily crushed, and trap lint. These conditions will obstruct tumble dryer airflow and increase the risk of

fire.

W752R1

The following information applies to the state of Massachusetts, USA.

• This appliance can only be installed by a Massachusetts licensed plumber or gas fitter.

• This appliance must be installed with a 36 inch [91 cm] long flexible gas connector.

• A “T-Handle” type gas shut-off valve must be installed in the gas supply line to this appliance.

• This appliance must not be installed in a bedroom or bathroom.

Front Matter

4 © Copyright, Alliance Laundry Systems LLC - DO NOT COPY or TRANSMIT Part No. 70458301ENR9

Table of Contents

Introduction........................................................................................... 9

Model Identification........................................................................................9

Contact Information...................................................................................... 15

Safety Information................................................................................17

Explanation of Safety Messages..................................................................... 17

Important Safety Instructions......................................................................... 17

Specifications and Dimensions.............................................................. 19

Specifications and Dimensions.......................................................................19

Cabinet Dimensions – 025, 030, 035 and 055 Series.........................................23

Cabinet Dimensions – T30 and T45 Series...................................................... 24

Exhaust Outlet Locations – 025, 030, 035 and 055 Series................................. 25

Exhaust Outlet Locations – T30 and T45 Series............................................... 26

Gas Connection Locations – 025, 030, 035 and 055 Series................................27

Gas Connection Locations – T30 and T45 Series............................................. 28

Electrical Connection Locations – 025, 030, 035 and 055 Series........................29

Electrical Connection Locations – T30 and T45 Series..................................... 30

Steam Connection Locations – 025, 030 and 035 Series....................................31

Steam Connection Locations – T30 Series.......................................................32

Installation........................................................................................... 33

Pre-Installation Inspection............................................................................. 33

Location Requirements..................................................................................33

Position and Level the Tumble Dryer..............................................................34

Fifth Leveling Leg........................................................................................ 34

Fire Suppression System (Optional Equipment)............................................... 35

Check Local Codes and Permits..................................................................35

Water Requirements.................................................................................. 35

Water Connections.................................................................................... 35

Electrical Requirements............................................................................. 36

Auxiliary Alarm........................................................................................ 36

To Reverse the Loading Door (025, 030, 035 and 055 Series)........................... 37

Before Placing Tumble Dryer into Service...................................................... 39

Required for CE Models Only.................................................................... 41

Installing CE Gas Drying Tumble Dryer......................................................... 41

General Information.................................................................................. 41

CE Orifices...............................................................................................41

Properties of CE Gases.............................................................................. 44

Changing Gas Configuration...................................................................... 45

Specific Conversion Procedures..................................................................45

written consent of the publisher.

Part No. 70458301ENR9 © Copyright, Alliance Laundry Systems LLC - DO NOT COPY or TRANSMIT 5

Exhaust Requirements..........................................................................48

Exhaust Requirements................................................................................... 48

Layout......................................................................................................... 48

Make-Up Air................................................................................................48

Venting........................................................................................................48

Individual Venting.....................................................................................49

Manifold Venting...................................................................................... 50

Gas Requirements.................................................................................53

Gas Requirements.........................................................................................53

Gas Supply Pipe Sizing and Looping.............................................................. 55

High Altitude Burner Orifice Sizing............................................................... 57

Electrical Requirements........................................................................65

Electrical Requirements.................................................................................65

Wiring Diagram............................................................................................65

Wiring for Central Pay.................................................................................. 65

Grounding Instructions.................................................................................. 66

For CE Models Only..................................................................................67

Service/Ground Location........................................................................... 67

To Connect Electrical Service To The Tumble Dryer....................................... 70

Configuring Your Tumble Dryer for Other Service Voltages.............................70

Electrical Connections for T30 and T45 Only.................................................. 71

Conversion Instructions................................................................................. 72

Ferrite Ring Installation (025, 030, 035 and 055 Series Only)............................73

Electrical Specifications................................................................................ 74

Steam Requirements.............................................................................85

Steam Requirements......................................................................................85

Piping Recommendations.............................................................................. 87

Installing Steam Trap and Making Condensate Return Connections...................87

Single Drop Timer................................................................................ 88

Power-Up Mode........................................................................................... 88

Ready Mode.................................................................................................88

Start Mode................................................................................................... 88

Run Mode.................................................................................................... 88

Door Open Mode.......................................................................................... 88

End of Cycle Mode....................................................................................... 88

Setting Dry Time Dipswitches........................................................................88

Models Through Serial No. 0908xxxxx....................................................... 88

Models Starting Serial No. 0909xxxxx........................................................ 88

Resetting Cycle Time to Zero.........................................................................88

Dipswitch Settings........................................................................................ 89

Topoffs........................................................................................................ 92

Temperature Selector Switch......................................................................... 92

To Program a Short Test Cycle.......................................................................92

6 © Copyright, Alliance Laundry Systems LLC - DO NOT COPY or TRANSMIT Part No. 70458301ENR9

Error Codes..................................................................................................92

Operating Instructions..........................................................................93

Operating Instructions................................................................................... 93

Emergency Stop Button On CE Models.......................................................... 93

Operating Instructions................................................................................... 93

Reversing Operation......................................................................................94

Control Instructions.......................................................................................94

Dual Digital Timer Control........................................................................ 94

Electronic OPL Micro Control....................................................................96

Single Drop Control...................................................................................97

MDC Coin and Card Control......................................................................97

Quantum Control ......................................................................................98

Galaxy 600 Control .................................................................................. 98

LED OPL Control .................................................................................... 99

UniLinc Control ..................................................................................... 100

DX4 Coin Control................................................................................... 101

DX4 OPL Control....................................................................................102

Diagnostic Microprocessor Control .......................................................... 102

DMP OPL Models...................................................................................104

DMP Coin.............................................................................................. 106

Ignition Control Operation and Troubleshooting for Models Starting 3/11/13... 108

Internal Control Failure............................................................................108

Troubleshooting...................................................................................... 108

Proper Electrode Location........................................................................ 109

Flame Current Measurement.....................................................................109

Ignition Control Operation for Non-CE Models Through 3/10/13.................... 109

Ignition Control Operation for CE Models Through 3/10/13............................110

System Tests........................................................................................... 111

Diagnostic LED (DGN LED)/Error Codes................................................. 111

Adjustments........................................................................................112

Adjustments............................................................................................... 112

Gas Burner Air Shutter................................................................................ 112

Airflow Switch .......................................................................................... 113

Loading Door Switch.................................................................................. 113

Door Strike.................................................................................................114

Maintenance....................................................................................... 115

Daily..........................................................................................................115

Monthly..................................................................................................... 115

Quarterly....................................................................................................115

Bi-Annually................................................................................................116

Annually.................................................................................................... 116

Fire Suppression System (Optional Equipment) Maintenance Test...................116

Before You Call for Service.................................................................118

Part No. 70458301ENR9 © Copyright, Alliance Laundry Systems LLC - DO NOT COPY or TRANSMIT 7

Removing Tumble Dryer from Service................................................ 119

Disposal of Unit...................................................................................120

8 © Copyright, Alliance Laundry Systems LLC - DO NOT COPY or TRANSMIT Part No. 70458301ENR9

Introduction

Model Identification

Information in this manual is applicable to these models:

Gas Steam Electric

025 Series CHD25G2-

CA025L

CHD25G2-

CA025N

CHD25G2-

CT025L

CHD25G2-

CT025N

CHD25G2-

CU025L

CHD25G2-

CU025N

CK025N

CK025R

CT025R

CU025R

DR25G2-

BA025L

DR25G2-

BA025N

DR25G2-

BK025N

DR25G2-

BK025R

DR25G2-

BT025L

DR25G2-

BT025N

DR25G2-

BT025R

DR25G2-

BU025L

DR25G2-

BU025N

DR25G2-

BU025R

HA025L

HA025N

HK025N

HK025R

HT025L

HT025N

HT025R

HU025L

HU025N

HU025R

IPD25G2

IT025L

IT025N

IT025R

MT025L

MT025N

MT025R

SA025L

SA025N

SK025N

SK025R

ST025L

ST025N

ST025R

SU025L

SU025N

SU025R

UA025L

UA025N

UK025N

UK025R

UT025L

UT025N

UT025R

UU025L

UU025N

UU025R

YT025L

YT025N

YU025L

YU025N

CHD25S2-

CT025S

CHD25S2-

CU025S

DR25S2-

BT025S

DR25S2-

BU025S

HT025S

HU025S

IPD25S2

IT025S

MT025S

ST025S

SU025S

UT025S

UU025S

YT025S

YU025S

CHD25E2-

CT025E

CHD25E2-

CU025E

CT025F

CU025F

DR25E2-

BT025E

DR25E2-

BT025F

DR25E2-

BU025E

DR25E2-

BU025F

HT025E

HT025F

HU025E

HU025F

IPD25E2

IT025E

IT025F

MT025E

MT025F

ST025E

ST025F

SU025E

SU025F

UT025E

UT025F

UU025E

UU025F

YT025E

YU025E

Introduction

Part No. 70458301ENR9 © Copyright, Alliance Laundry Systems LLC - DO NOT COPY or TRANSMIT 9

Gas Steam Electric

030 Series CHD30G2-

CA030L

CHD30G2-

CA030N

CHD30G2-

CT030L

CHD30G2-

CT030N

CHD30G2-

CU030L

CHD30G2-

CU030N

CK030N

CK030R

CT030R

CU030R

DR30G2-

BA030L

DR30G2-

BA030N

DR30G2-

BK030N

DR30G2-

BK030R

DR30G2-

BT030D

DR30G2-

BT030L

DR30G2-

BT030N

DR30G2-

BT030R

DR30G2-

BU030L

DR30G2-

BU030N

DR30G2-

BU030R

HA030L

HA030N

HK030N

HK030R

HT030D

HT030L

HT030N

HT030R

HU030L

HU030N

HU030R

IPD30G2

IT030L

IT030N

IT030R

MT030L

MT030N

MT030R

SA030L

SA030N

SK030N

SK030R

ST030D

ST030L

ST030N

ST030R

SU030L

SU030N

SU030R

UA030L

UA030N

UK030N

UK030R

UT030L

UT030N

UT030R

UU030L

UU030N

UU030R

YT030L

YT030N

YU030L

YU030N

CHD30S2-

CT030S

CHD30S2-

CU030S

DR30S2-

BT030S

DR30S2-

BU030S

HT030S

HU030S

IPD30S2

IT030S

MT030S

ST030S

SU030S

UT030S

UU030S

YT030S

YU030S

CHD30E2-

CT030E

CHD30E2-

CU030E

CT030F

CU030F

DR30E2-

BT030E

DR30E2-

BT030F

DR30E2-

BU030E

DR30E2-

BU030F

HT030E

HT030F

HU030E

HU030F

IPD30E2

IT030E

IT030F

MT030E

MT030F

ST030E

ST030F

SU030E

SU030F

UT030E

UT030F

UU030E

UU030F

YT030E

YU030E

Introduction

Otros manuales para 25 Pound Capacity

Este manual sirve para los siguientes modelos

198

Tabla de contenidos

Otros manuales de Secadora de Alliance Laundry Systems

Alliance Laundry Systems

Alliance Laundry Systems T477C Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems CHD25G2-CT025L Instrucciones de funcionamiento

Alliance Laundry Systems

Alliance Laundry Systems Speed Queen DF7000SE Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems LWS01M series Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems HA025E Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems 602004144 Manual de instrucciones

Alliance Laundry Systems

Alliance Laundry Systems Speed Queen FF7009WN Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems DRYING TUMBLERS 70269501R3 Instrucciones de funcionamiento

Alliance Laundry Systems

Alliance Laundry Systems LTS87A*H Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems 70420801 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems continuity Manual del propietario

Alliance Laundry Systems

Alliance Laundry Systems Drying Tumbler 110 Pound Capacity Part No.... Manual de instalación y operación

Alliance Laundry Systems

Alliance Laundry Systems BD3LLFGS401UW01 Instrucciones de funcionamiento

Alliance Laundry Systems

Alliance Laundry Systems ADG41F1 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems D677I Guía

Alliance Laundry Systems

Alliance Laundry Systems LES33A Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems DRY683C Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems DR3000WG Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems D715I Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems DV6010WE Guía

Alliance Laundry Systems

Alliance Laundry Systems 512906 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems 505048R2 Manual del propietario

Alliance Laundry Systems

Alliance Laundry Systems 505828 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems AT120FG Manual de usuario

Manuales populares de Secadora de otras marcas

Bosch

Bosch WTA79200GB Manual de usuario

Amana

Amana W10233410A Manual de usuario

Miele

Miele TWH 780 WP Manual de usuario

Asko

Asko T760 Manual de usuario

Bosch

Bosch Logixx 10 WTB76556GB Hoja de especificaciones

STIEBEL ELTRON

STIEBEL ELTRON Ultronic S Manual de instrucciones

Electrolux

Electrolux EW2H328R2 Manual de usuario

Beko

Beko DS8433RX1M Manual de usuario

Dawlance

Dawlance Spinner DS 6000 C Manual de usuario

Electrolux

Electrolux TP5080TW Manual de usuario

AEG

AEG TR838P4OB Manual de usuario

Indesit

Indesit IDV 75 Manual de usuario

Infiniton

Infiniton SD-DG85C Manual de usuario

BOMANN

BOMANN WT 5019 Manual de usuario

Asko

Asko T793C Manual de usuario

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer Manual de usuario

Frigidaire

Frigidaire CAQE7077KW0 Manual del propietario

Bosch

Bosch WTX8HKM9SN Manual de usuario