Alliance Laundry Systems CHD25G2-CT025L Instrucciones de funcionamiento

Programming

Tumble Dryer

OPL Electronic Control

Refer to Page 7 for Model Identification

Original Instructions

Keep These Instructions for Future Reference.

(If this machine changes ownership, this manual must accompany machine.)

www.alliancelaundry.com Part No. 70444901ENR10

February 2016

Front Matter

WARNING

Machine installations must comply with minimum

specifications and requirements stated in the appli-

cable Installation Manual, any applicable municipal

building codes, water supply requirements, electrical

wiring regulations and any other relevant statutory

regulations. Due to varied requirements and applica-

ble local codes, this machine must be installed, ad-

justed, and serviced by qualified maintenance per-

sonnel familiar with applicable local codes and the

construction and operation of this type of machinery.

They must also be familiar with the potential hazards

involved. Failure to observe this warning may result

in personal injury, property damage, and/or equip-

ment damage, and will void the warranty.

W820

NOTE: The WARNINGS and IMPORTANT SAFETY IN-

STRUCTIONS appearing in this manual are not meant

to cover all possible conditions and situations that may

occur. Common sense, caution, and care must be exer-

cised when installing, maintaining, or operating the

machine.

Any problems or conditions not understood should be reported to

the dealer, distributor, service agent or the manufacturer.

Front Matter

DO NOT COPY or TRANSMIT

3 Part No. 70444901ENR10

Table of Contents

Front Matter.......................................................................................... 3

Introduction........................................................................................... 7

Model Identification........................................................................................7

Nameplate Location...................................................................................... 17

Preliminary Information.......................................................................18

About the Control......................................................................................... 18

DIP Switch Configuration..............................................................................18

Power Failure Recovery................................................................................ 18

Communications...........................................................................................18

Audit Information......................................................................................... 18

Restore to Factory Defaults............................................................................18

Entering Program Mode................................................................................ 19

Control Identification........................................................................... 20

Operational Keypad...................................................................................... 20

Operation Modes.......................................................................................... 21

General Modes of Operation.......................................................................21

Power-up Mode.........................................................................................21

Idle Mode................................................................................................. 22

Run Mode.................................................................................................22

Rapid Advance Mode................................................................................ 23

Pause Mode.............................................................................................. 23

Error Mode............................................................................................... 23

Communication Mode............................................................................... 23

Cool Down Mode......................................................................................23

End of Cycle Mode....................................................................................23

Extended Tumble Mode............................................................................. 23

Reversing Mode (reversing models only).....................................................23

Entering Diagnostic Mode From Idle Mode................................................. 23

Displaying Temperature Mode....................................................................23

Machine Cycle Definition and Operation.............................................. 24

Machine Cycle Operation.............................................................................. 24

Time Dry Cycle.........................................................................................24

Auto-Dry Cycle.........................................................................................24

Moisture Dry Cycle (if equipped)................................................................24

Rotation Sensor Equipped Machines...............................................................24

To Start a Cycle............................................................................................ 24

written consent of the publisher.

DO NOT COPY or TRANSMIT

4 Part No. 70444901ENR10

Entering the Manual Mode................................................................... 25

How to Enter the Manual Mode......................................................................25

Programming Control...........................................................................27

What Can Be Programmed?........................................................................... 27

How to Program a Cycle................................................................................27

Programmable Options Available................................................................... 27

Collecting Audit Information................................................................ 38

How to Enter Audit Feature........................................................................... 38

How to Read Audit Data................................................................................38

How to Exit Audit Feature............................................................................. 38

Manual Reset........................................................................................39

Custom Save.........................................................................................40

Testing Machine and Electronic Control Functions............................... 41

How to Enter Testing Feature.........................................................................41

How to Start Tests.........................................................................................41

How to Exit Testing Feature...........................................................................41

Diagnostic Test Descriptions..........................................................................44

Control Software Version Number Test........................................................44

Loading Door Test.....................................................................................44

Lint Door Test...........................................................................................44

Heater Interlock Test..................................................................................44

Dip Switch Status......................................................................................44

ICM Alarm Status..................................................................................... 45

ICM Reset Test......................................................................................... 45

External Alarm Test...................................................................................45

Tumble Dryer On Temperature Test............................................................ 45

Thermistor Temperature Test...................................................................... 45

Machine Configuration Display #2 Test.......................................................45

Machine Configuration Display #3 Test.......................................................46

Airflow Switch Test...................................................................................46

Fan Motor Test..........................................................................................46

Damper Motor Test....................................................................................46

Reverse Motor Test....................................................................................47

Rotation Sensor Test.................................................................................. 47

Moisture Sensor Test (Shorted Test Jumper).................................................47

Moisture Sensor Test (Resistance Test Jumper)............................................ 47

Production Test Cycle....................................................................................47

To Enter Production Test Cycle...................................................................47

To Exit Production Test Cycle.................................................................... 48

Machine Errors.................................................................................... 49

DO NOT COPY or TRANSMIT

5 Part No. 70444901ENR10

PDA Communications Error.......................................................................... 49

Open Thermistor Error.................................................................................. 49

Shorted Thermistor Error...............................................................................49

Stove and Cabinet Limit Errors...................................................................... 49

Auto Ignition Retry (Gas Models Only).......................................................... 49

Air Flow Switch Errors..................................................................................49

Airflow Switch Sensed Closed While Not In Run Mode................................49

Airflow Switch Does Not Close After Cycle Started..................................... 49

Airflow Switch Bounces During A Running Cycle....................................... 49

Rotation Sensor Error....................................................................................50

Fan Motor Contactor Error.............................................................................50

Fan Motor Centrifugal Switch Error............................................................... 50

DIP Switch/Harness Index Mismatch Error..................................................... 50

Moisture Sensor Error................................................................................... 50

Error Codes..........................................................................................51

Communication Mode...........................................................................53

Infra-red Communications............................................................................. 53

How to Begin Communications with An External Device................................. 53

Cycle Charts.........................................................................................54

DO NOT COPY or TRANSMIT

6 Part No. 70444901ENR10

Introduction

Model Identification

Information in this manual is applicable to these tumble dryer

models:

Gas Steam/Thermal Oil Electric

25 Pound CHD25G2-

CA025L

CHD25G2-

CA025N

CHD25G2-

CT025L

CHD25G2-

CT025N

CHD25G2-

CU025L

CHD25G2-

CU025N

CK025N

CK025R

CT025R

CU025R

DR25G2-

BA025L

DR25G2-

BA025N

DR25G2-

BK025N

DR25G2-

BK025R

DR25G2-

BT025L

DR25G2-

BT025N

DR25G2-

BT025R

DR25G2-

BU025L

DR25G2-

BU025N

DR25G2-

BU025R

HA025L

HA025N

HK025N

HK025R

HT025L

HT025N

HT025R

HU025L

HU025N

HU025R

IPD25G2

IT025L

IT025N

IT025R

LA025L

LA025N

LK025N

LT025L

LT025N

LU025L

LU025N

NT025L

NT025N

NU025L

NU025N

PA025L

PA025N

PK025N

PT025L

PT025N

PU025L

PU025N

SA025L

SA025N

SK025N

SK025R

ST025L

ST025N

ST025R

SU025L

SU025N

SU025R

UA025L

UA025N

UK025N

UK025R

UT025L

UT025N

UT025R

UU025L

UU025N

UU025R

CHD25S2-

CT025S

CHD25S2-

CU025S

DR25S2-

BT025S

DR25S2-

BU025S

HT025S

HU025S

IPD25S2

IT025S

LT025S

LU025S

NT025S

NU025S

PT025S

PU025S

ST025S

SU025S

UT025S

UU025S

CHD25E2-

CT025E

CHD25E2-

CU025E

CT025F

CU025F

DR25E2-

BT025E

DR25E2-

BT025F

DR25E2-

BU025E

DR25E2-

BU025F

HT025E

HT025F

HU025E

HU025F

IPD25E2

IT025E

IT025F

LT025E

LU025E

NT025E

NU025E

PT025E

PU025E

ST025E

ST025F

SU025E

SU025F

UT025E

UT025F

UU025E

UU025F

Table continues...

Introduction

DO NOT COPY or TRANSMIT

7 Part No. 70444901ENR10

Gas Steam/Thermal Oil Electric

30 Pound CHD30G2-

CA030L

CHD30G2-

CA030N

CHD30G2-

CT030L

CHD30G2-

CT030N

CHD30G2-

CU030L

CHD30G2-

CU030N

CK030N

CK030R

CT030R

CU030R

DR30G2-

BA030L

DR30G2-

BA030N

DR30G2-

BK030N

DR30G2-

BK030R

DR30G2-

BT030D

DR30G2-

BT030L

DR30G2-

BT030N

DR30G2-

BT030R

DR30G2-

BU030L

DR30G2-

BU030N

DR30G2-

BU030R

HA030L

HA030N

HK030N

HK030R

HT030D

HT030L

HT030N

HT030R

HU030L

HU030N

HU030R

IPD30G2

IT030L

IT030N

IT030R

LA030L

LA030N

LK030N

LT030L

LT030N

LU030L

LU030N

NT030L

NT030N

NU030L

NU030N

PA030L

PA030N

PK030N

PT030L

PT030N

PU030L

PU030N

SA030L

SA030N

SK030N

SK030R

ST030D

ST030L

ST030N

ST030R

SU030L

SU030N

SU030R

UA030L

UA030N

UK030N

UK030R

UT030L

UT030N

UT030R

UU030L

UU030N

UU030R

CHD30S2-

CT030S

CHD30S2-

CU030S

DR30S2-

BT030S

DR30S2-

BU030S

HT030S

HU030S

IPD30S2

IT030S

LT030S

LU030S

NT030S

NU030S

PT030S

PU030S

ST030S

SU030S

UT030S

UU030S

CHD30E2-

CT030E

CHD30E2-

CU030E

CT030F

CU030F

DR30E2-

BT030E

DR30E2-

BT030F

DR30E2-

BU030E

DR30E2-

BU030F

HT030E

HT030F

HU030E

HU030F

IPD30E2

IT030E

IT030F

LT030E

LU030E

NT030E

NU030E

PT030E

PU030E

ST030E

ST030F

SU030E

SU030F

UT030E

UT030F

UU030E

UU030F

Table continues...

Introduction

DO NOT COPY or TRANSMIT

8 Part No. 70444901ENR10

Gas Steam/Thermal Oil Electric

30 Pound

Stacked

CHD30STG

2-CAT30L

CHD30STG

2-CAT30N

CHD30STG

2-CTT30L

CHD30STG

2-CTT30N

CHD30STG

2-CUT30L

CHD30STG

2-CUT30N

CKT30N

CKT30R

CTT30R

CUT30R

DR335

DR335G2-

BKT30N

DR335G2-

BKT30R

DR335G2-

BTT30R

DR335G2-

BUT30R

DRST30G2-

BAT30L

DRST30G2-

BAT30N

DRST30G2-

BTT30D

DRST30G2-

BTT30L

DRST30G2-

BTT30N

DRST30G2-

BUT30L

DRST30G2-

BUT30N

HAT30L

HAT30N

HKT30N

HKT30R

HTT30D

HTT30L

HTT30N

HTT30R

HUT30L

HUT30N

HUT30R

IPD30STG2

ITT30L

ITT30N

ITT30R

LAT30L

LAT30N

LKT30N

LTT30L

LTT30N

LUT30L

LUT30N

NTT30L

NTT30N

NUT30L

NUT30N

PAT30L

PAT30N

PKT30N

PTT30L

PTT30N

PUT30L

PUT30N

SAT30L

SAT30N

SKT30N

SKT30R

STT30D

STT30L

STT30N

STT30R

SUT30L

SUT30N

SUT30R

UAT30L

UAT30N

UKT30N

UKT30R

UTT30L

UTT30N

UTT30R

UUT30L

UUT30N

UUT30R

CHD30STS2

-CTT30S

CHD30STS2

-CUT30S

DRST30S2-

BTT30S

DRST30S2-

BUT30S

HTT30S

HUT30S

IPD30STS2

ITT30S

LTT30S

LUT30S

NTT30S

NUT30S

PTT30S

PUT30S

STT30S

SUT30S

UTT30S

UUT30S

CHD30STE2

-CTT30E

CHD30STE2

-CUT30E

CTT30F

CUT30F

DR335G2-

BTT30F

DR335G2-

BUT30F

DRST30E2-

BTT30E

DRST30E2-

BUT30E

HTT30E

HTT30F

HUT30E

HUT30F

IPD30STE2

ITT30E

ITT30F

LTT30E

LUT30E

NTT30E

NUT30E

PTT30E

PUT30E

STT30E

STT30F

SUT30E

SUT30F

UTT30E

UTT30F

UUT30E

UUT30F

Table continues...

Introduction

DO NOT COPY or TRANSMIT

9 Part No. 70444901ENR10

Gas Steam/Thermal Oil Electric

35 Pound CHD35G2-

CA035L

CHD35G2-

CA035N

CHD35G2-

CT035L

CHD35G2-

CT035N

CHD35G2-

CU035L

CHD35G2-

CU035N

CK035N

CK035R

CT035R

CU035R

DR35G2-

BA035L

DR35G2-

BA035N

DR35G2-

BK035N

DR35G2-

BK035R

DR35G2-

BT035L

DR35G2-

BT035N

DR35G2-

BT035R

DR35G2-

BU035L

DR35G2-

BU035N

DR35G2-

BU035R

HA035L

HA035N

HK035N

HK035R

HT035L

HT035N

HT035R

HU035L

HU035N

HU035R

IPD35G2

IT035L

IT035N

IT035R

LA035L

LA035N

LK035N

LT035L

LT035N

LU035L

LU035N

NT035L

NT035N

NU035L

NU035N

PA035L

PA035N

PK035N

PT035L

PT035N

PU035L

PU035N

SA035L

SA035N

SK035N

SK030R

ST035L

ST035N

ST035R

SU035L

SU035N

SU035R

UA035L

UA035N

UK035N

UK035R

UT035L

UT035N

UT035R

UU035L

UU035N

UU035R

CHD35S2-

CT035S

CHD35S2-

CU035S

DR35S2-

BT035S

DR35S2-

BU035S

HT035S

HU035S

IPD35S2

IT035S

LT035S

LU035S

NT035S

NU035S

PT035S

PU035S

ST035S

SU035S

UT035S

UU035S

CHD35E2-

CT035E

CHD35E2-

CU035E

CT035F

CU035F

DR35E2-

BT035E

DR35E2-

BT035F

DR35E2-

BU035E

DR35E2-

BU035F

HT035E

HT035F

HU035E

HU035F

IPD35E2

IT035E

IT035F

LT035E

LU035E

NT035E

NU035E

PT035E

PU035E

ST035E

ST035F

SU035E

SU035F

UT035E

UT035F

UU035E

UU035F

Table continues...

Introduction

DO NOT COPY or TRANSMIT

10 Part No. 70444901ENR10

Este manual sirve para los siguientes modelos

556

Tabla de contenidos

Otros manuales de Secadora de Alliance Laundry Systems

Alliance Laundry Systems

Alliance Laundry Systems DRY710C Guía

Alliance Laundry Systems

Alliance Laundry Systems 510963R6 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems 505828 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems DRY722C-SVG Guía

Alliance Laundry Systems

Alliance Laundry Systems KE Series Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems LEB07A*-1709 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems D310IE3B Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems LES33AW Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems DR5004WE Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems DRY683C Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems DRYING TUMBLERS 70269501R3 Instrucciones de funcionamiento

Alliance Laundry Systems

Alliance Laundry Systems LTS97A*N Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems Drying Tumblers 50 Pound Capacity 75 Pound Capacity Model Identification Part No.... Manual del propietario

Alliance Laundry Systems

Alliance Laundry Systems UA025L Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems DRY684C Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems Drying Tumblers none Manual de funcionamiento

Alliance Laundry Systems

Alliance Laundry Systems D677I_SVG Instrucciones de funcionamiento originales

Alliance Laundry Systems

Alliance Laundry Systems D355IE1B Manual del propietario

Alliance Laundry Systems

Alliance Laundry Systems T433I Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems 513218R5 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems 505048R2 Manual del propietario

Alliance Laundry Systems

Alliance Laundry Systems continuity Manual del propietario

Alliance Laundry Systems

Alliance Laundry Systems HSE117*C802 Instrucciones de montaje

Alliance Laundry Systems

Alliance Laundry Systems 602004144 Guía de solución de problemas

Manuales populares de Secadora de otras marcas

Bosch

Bosch WTA79200GB Manual de usuario

Amana

Amana W10233410A Manual de usuario

Miele

Miele TWH 780 WP Manual de usuario

Asko

Asko T760 Manual de usuario

Bosch

Bosch Logixx 10 WTB76556GB Hoja de especificaciones

STIEBEL ELTRON

STIEBEL ELTRON Ultronic S Manual de instrucciones

Electrolux

Electrolux EW2H328R2 Manual de usuario

Beko

Beko DS8433RX1M Manual de usuario

Dawlance

Dawlance Spinner DS 6000 C Manual de usuario

Electrolux

Electrolux TP5080TW Manual de usuario

AEG

AEG TR838P4OB Manual de usuario

Indesit

Indesit IDV 75 Manual de usuario

Infiniton

Infiniton SD-DG85C Manual de usuario

BOMANN

BOMANN WT 5019 Manual de usuario

Asko

Asko T793C Manual de usuario

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer Manual de usuario

Frigidaire

Frigidaire CAQE7077KW0 Manual del propietario

Bosch

Bosch WTX8HKM9SN Manual de usuario