Alliance Laundry Systems ADE3SRGS173CW01 Manual de usuario

Troubleshooting

Home Dryers

Refer to Page 6 for Model Numbers

DRY726C_SVG

Original Instructions

Keep These Instructions for Future Reference.

CAUTION: Read the instructions before using the machine.

(If this machine changes ownership, this manual must accompany machine.)

www.alliancelaundry.com Part No. D515517ENR3

June 2018

Table of Contents

Safety Information..................................................................................5

Locating an Authorized Service Person.............................................................6

Introduction........................................................................................... 7

Customer Service............................................................................................7

Serial Plate Location....................................................................................... 7

Model Identification........................................................................................7

How Your Dryer Works...................................................................................9

Troubleshooting....................................................................................10

No Timer Advance in Automatic Cycles......................................................... 10

Electric Dryers.......................................................................................... 10

Gas Dryers................................................................................................10

Troubleshooting Flowcharts..................................................................12

Dryer Motor Does Not Run............................................................................13

Dryer Stops in Cycle; Quits After the First Few Loads; Has a BurningSmell; Cy-

cles on Motor Thermal Protector.................................................................15

Dryer Motor Runs but Cylinder Does Not Turn................................................16

Dryer Motor Does Not Stop........................................................................... 18

Dry Runs Only When Door is Open................................................................19

Dryer Heating Assembly Does Not Heat or Burner Does Not Ignite...................20

Igniter Does Not Glow (Gas Supply Sufficient) - Gas Dryer Models..................22

Burner Ignites and Goes Out Repeatedly (Gas Dryer Models)........................... 23

Igniter Glows but Burner Does Not Ignite (Gas Dryer Models)......................... 24

Dryer Heater Assembly or Burner Shuts Off Prematurely................................. 25

Dryer Heater Assembly or Burner Repeatedly Cycles Off On Limit Thermostat.27

Dryer Heater Assembly or Burner Does Not Shut Off.......................................29

Clothes Do Not Dry in Dryer......................................................................... 30

Timer/Electronic Control Does Not Advance in Automatic Cycle......................32

Clothes Are Too Hot When Removed from Dryer............................................ 34

Excessive Chattering or Vibrating Noise in Dryer............................................ 35

Excessive Humming or Whistling Noise in Dryer............................................ 36

Error Codes - Electronic Control Models.............................................. 37

Adjustments......................................................................................... 39

Leveling Legs...............................................................................................39

Burner Flame (Gas Models)........................................................................... 39

written consent of the publisher.

DO NOT COPY or TRANSMIT

3 Part No. D515517ENR3

Test Procedures.....................................................................................41

Timer Contacts............................................................................................. 41

Fabric Selector Switch...................................................................................41

Drive Motor................................................................................................. 42

Drive Motor - Motor Switch.......................................................................... 43

Drive Motor - Motor Windings.......................................................................45

Motor Switch................................................................................................45

Burner System Operation - Gas Models.......................................................... 47

Electrical Circuit Ignition System (Gas Models).............................................. 48

Gas Valve Coils Check (Gas Models)..............................................................48

Sensor Check (Gas Models)........................................................................... 49

Igniter Check (Gas Models)........................................................................... 49

Thermal Fuse Electric (Models)..................................................................... 49

Heater Assembly (Electric Models)................................................................ 49

Cycling or Limit Thermostat.......................................................................... 50

Door Switch................................................................................................. 50

Internal Wiring of Dryer Motor Switch.................................................51

DO NOT COPY or TRANSMIT

4 Part No. D515517ENR3

Safety Information

Precautionary statements (“DANGER,” “WARNING,” and

“CAUTION”), followed by specific instructions, are found in this

manual and on machine decals. These precautions are intended

for the personal safety of the operator, user, servicer, and those

maintaining the machine.

DANGER

Indicates an imminently hazardous situation that, if

not avoided, will cause severe personal injury or

death.

WARNING

Indicates a hazardous situation that, if not avoided,

could cause severe personal injury or death.

CAUTION

Indicates a hazardous situation that, if not avoided,

may cause minor or moderate personal injury or

property damage.

Additional precautionary statements (“IMPORTANT” and

“NOTE”) are followed by specific instructions.

IMPORTANT: The word “IMPORTANT” is used to in-

form the reader of specific procedures where minor

machine damage will occur if the procedure is not fol-

lowed.

NOTE: The word “NOTE” is used to communicate in-

stallation, operation, maintenance or servicing informa-

tion that is important but not hazard related.

In the interest of safety, some general precautions relating to the

operation of this machine follow.

WARNING

• Failure to install, maintain and/or operate this

product according to the manufacturer’s instruc-

tions may result in conditions which can produce

serious injury, death and/or property damage.

• Do not repair or replace any part of the product or

attempt any servicing unless specifically recom-

mended or published in this Service Manual and

unless you understand and have the skills to car-

ry out the servicing.

• Whenever ground wires are removed during serv-

icing, these ground wires must be reconnected to

ensure that the product is properly grounded and

to reduce the risk of fire, electric shock, serious

injury or death.

W006R2

WARNING

To reduce the risk of electric shock, fire, explosion,

serious injury or death:

• Disconnect electric power to the dryer before

servicing.

• Close gas shut-of valve to gas dryer before serv-

icing.

• Never start the Dryer with any guards/panels re-

moved.

• Whenever ground wires are removed during serv-

icing, these ground wires must be reconnected to

ensure that the dryer is properly grounded.

W001R1

CAUTION

If you or an unqualified person perform service on

your product, you must assume the responsibility

for any personal injury or property damage which

may result. The manufacturer will not be responsible

for any injury or property damage arising from im-

proper service and/or service procedures.

W008

Safety Information

DO NOT COPY or TRANSMIT

5 Part No. D515517ENR3

NOTE: The WARNINGS and IMPORTANT INSTRUC-

TIONS appearing in this manual are not meant to cover

all possible conditions and situations that may occur.

Common sense, caution and care must be exercised

when installing, maintaining or operating the machine.

Always contact your dealer, distributor, service agent or the man-

ufacturer about any problems or conditions you do not under-

stand.

Locating an Authorized Service Person

Alliance Laundry Systems is not responsible for personal injury

or property damage resulting from improper service. Review all

service information before beginning repairs.

Warranty service must be performed by an authorized technician,

using authorized factory parts. If service is required after the war-

ranty expires, Alliance Laundry Systems also recommends con-

tacting an authorized technician and using authorized factory

parts.

Safety Information

DO NOT COPY or TRANSMIT

6 Part No. D515517ENR3

Introduction

Customer Service

If literature or replacement parts are required, contact the source

from whom the machine was purchased or contact Alliance

Laundry Systems at (920) 748-3950 for the name and address of

the nearest authorized parts distributor.

For technical assistance, call (920) 748-3121.

Serial Plate Location

When calling or writing about your product, be sure to mention

model and serial numbers. Model and serial numbers are located

on Serial Plate as shown.

DRY2527N_SVG

1. Serial Plate

Figure 1

Model Identification

Information in this manual is applicable to these washer models:

ADE3SRGS173CW01 ADEE9BSS543DN01 ADGE9BGS115CW01 ADLE9RGS303XW34

ADE3SRGS173TW01 ADEE9BSS543FN01 ADGE9BGS115CW14 ADLE9RGS305XW34

ADE3SRGS175CW01 ADEE9RGS173CW01 ADGE9BGS115TW01 ASEE8AGW173TW01

ADE3SRGS175CW14 ADEE9RGS173TW01 ADGE9BGS123DW01 ASGE8AGW113TW01

ADE3SRGS175TW01 ADEE9RGS175CW01 ADGE9BGS125DW01 ZDE3SRGS173CW01

ADE4BRGS175CW01 ADEE9RGS175CW14 ADGE9BGS543DW01 ZDE3SRGS173FW28

ADE4BRGS175CW14 ADEE9RGS175TW01 ADGE9BGS545DW01 ZDEE8RGS173CW01

ADE4BRGS175TW01 ADEE9RGS433XW34 ADGE9BSS113CN01 ZDEE8RGS543FW01

ADEE8BWS435AW01 ADEE9RGS435XW34 ADGE9BSS113FN01 ZDEE8RGS545FW01

ADEE8RGS173CW01 ADEE9RGS453NW29 ADGE9BSS113TN01 ZDEE8RWS545RW01

ADEE8RGS173TW01 ADEE9RGS453NW36 ADGE9BSS115CN01 ZDEE9BGS173CW01

ADEE8RWS455SW01 ADEE9RGS455LW26 ADGE9BSS115CN14 ZDEE9BGS543FW01

Table continues...

Introduction

DO NOT COPY or TRANSMIT

7 Part No. D515517ENR3

ADEE8RWS545RW01 ADEE9RGS455NW29 ADGE9BSS115TN01 ZDEE9BGS545FW01

ADEE9BGS173CW01 ADEE9RGS455NW36 ADGE9BSS123DN01 ZDEE9BSS173CN01

ADEE9BGS173TW01 ADEE9RGS543DW01 ADGE9BSS303XN01 ZDEE9BSS543FN01

ADEE9BGS175CW01 ADEE9RGS543FW01 ADGE9BSS303XN26 ZDEE9RGS173CW01

ADEE9BGS175CW14 ADEE9RGS545FW01 ADGE9BSS543DN01 ZDEE9RGS543FW01

ADEE9BGS175TW01 ADEE9RGS565XW01 ADGE9RGS113CW01 ZDEE9RGS545FW01

ADEE9BGS433XW34 ADEE9RGS565XW34 ADGE9RGS113FW01 ZDG3SRGS113CW01

ADEE9BGS435NW29 ADG3SRGS113CW01 ADGE9RGS113TW01 ZDG3SRGS113FW28

ADEE9BGS435XW34 ADG3SRGS113TW01 ADGE9RGS115CW01 ZDGE8RGS113CW01

ADEE9BGS453NW36 ADG3SRGS115CW01 ADGE9RGS115CW14 ZDGE8RGS113FW01

ADEE9BGS455NW36 ADG3SRGS115CW14 ADGE9RGS115FW01 ZDGE8RGS115FW01

ADEE9BGS543DW01 ADG3SRGS115TW01 ADGE9RGS115TW01 ZDGE9BGS113CW01

ADEE9BGS545DW01 ADG4BRGS115CW01 ADGE9RGS123DW01 ZDGE9BGS113FW01

ADEE9BSS173CN01 ADG4BRGS115CW14 ADGE9RGS303XW01 ZDGE9BGS115FW01

ADEE9BSS173TN01 ADG4BRGS115TW01 ADGE9RGS303XW26 ZDGE9BSS113CN01

ADEE9BSS175CN01 ADGE8BWS305AW01 ADGE9RGS305XW01 ZDGE9BSS113FN01

ADEE9BSS175CN14 ADGE8RGS113CW01 ADGE9RGS543DW01 ZDGE9RGS113CW01

ADEE9BSS175TN01 ADGE8RGS113TW01 ADLE9BGS303XW34 ZDGE9RGS113FW01

ADEE9BSS433LN01 ADGE9BGS113CW01 ADLE9BGS305XW34 ZDGE9RGS115FW01

Table continues...

Introduction

DO NOT COPY or TRANSMIT

8 Part No. D515517ENR3

ADEE9BSS433XN34 ADGE9BGS113TW01 ADLE9BSS303XN34

How Your Dryer Works

1. Lint Filter

2. Cylinder

3. Exhaust Fan

4. Gas Valve

5. Air Duct

6. Heater Duct

The dryer uses heated air to dry loads of laundry. When the motor

is started, the exhaust fan pulls room temperature air in through

louvers at the rear of the dryer and over the heat source (burner

flame for gas and heating element for electric). The heated air

moves through the heater duct and into the cylinder, where it cir-

culates through the wet load. The air then passes through the lint

filter, air duct, and exhaust fan, where it is vented to the outdoors.

The dryer has an automatic drying feature. At cycle start, when

fabric is wet and the temperature inside dryer is cool, the heat

source (burner on gas models and heating element on electric

models) is energized and heats the cylinder until operating tem-

perature (as set on Fabric Selector) is reached. Power is not sup-

plied to timer motor while heat source is energized during an au-

tomatic cycle. The heat source runs for longer periods of time in

the beginning of the cycle, when it is working to reach the operat-

ing temperature, resulting in very little timer advancement. As

the fabric dries and the cylinder heat is maintained, the heat

source is powered less, allowing the timer to advance to cycle

end. If dryer heats but timer does not advance, refer to No Timer

Advance in Automatic Cycles.

Introduction

DO NOT COPY or TRANSMIT

9 Part No. D515517ENR3

Troubleshooting

WARNING

To reduce the risk of electric shock, fire, explosion,

serious injury or death:

• Disconnect electric power to the dryer before

servicing.

• Close gas shut-of valve to gas dryer before serv-

icing.

• Never start the Dryer with any guards/panels re-

moved.

• Whenever ground wires are removed during serv-

icing, these ground wires must be reconnected to

ensure that the dryer is properly grounded.

W001R1

IMPORTANT: Refer to wiring diagram for aid in testing

dryer components.

No Timer Advance in Automatic Cycles

For a description of Automatic drying feature, refer to How Your

Dryer Works. If dryer heats but the timer does not advance, per-

form the following service procedures:

Electric Dryers

1. Remove any damp clothing from the dryer.

2. Set the timer to an Automatic cycle. Set fabric selector switch

to Regular.

3. Remove the top 3 screws holding the control hood to the rear

panel.

4. Start dryer by pushing in timer knob.

5. Using a volt/ohm meter set to AC voltage, measure the volt-

age across terminal “T” and terminal “M” on timer. Refer to

Figure 2 .

6. Meter should read no voltage when the unit is first started and

the dryer is still heating. Continue to monitor these points un-

til the heating element has shut off (this will take several mi-

nutes even with an empty load). When the heating element

shuts off, meter should read 120 Volts and the timer motor

should advance the cycle.

7. If meter does not read 120 Volts after the unit has reached

proper operating temperature use meter to check for 120 AC

Voltage between terminal “A” and terminal “N” (neutral) on

the timer.

8. If voltage is present, recheck voltage between “T” and “M”.

9. If voltage is present, but timer does not advance, replace tim-

er.

10. If meter does not read 120 Volts at “A” and “N”, check the

wire connections at the heating element and timer (blue/black

wire). If the connections are good, UNPLUG dryer, remove

wire at terminal “A” on timer and perform an ohms check on

wire continuity between the heating element and timer. If the

wire shows continuity, replace timer.

1. "T"

2. "N"

3. "M"

4. "A"

Figure 2

Gas Dryers

1. Remove any damp clothing from the dryer.

2. Set the timer to an Automatic cycle. Set fabric selector switch

to Regular.

3. Remove the top 3 screws holding the control hood to the rear

panel.

4. Start dryer by pushing in timer knob.

5. Using a volt/ohm meter set to AC voltage, measure the volt-

age across terminal “T” and terminal “N” on timer. Refer to

Figure 2 .

6. Meter should read no voltage when the unit is first started and

the dryer is still heating. Continue to monitor these points un-

til the burner has shut off (this will take several minutes even

Troubleshooting

DO NOT COPY or TRANSMIT

10 Part No. D515517ENR3

Este manual sirve para los siguientes modelos

126

Tabla de contenidos

Otros manuales de Secadora de Alliance Laundry Systems

Alliance Laundry Systems

Alliance Laundry Systems 25 Series Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems DC0220SFG Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems 506126R5 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems FES17AxF Instrucciones de montaje

Alliance Laundry Systems

Alliance Laundry Systems 120 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems JCD32DG Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems 120 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems LTZ87A*H0902 Series Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems 0904004427 Manual del propietario

Alliance Laundry Systems

Alliance Laundry Systems ADG41F1 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems DRY710C Guía

Alliance Laundry Systems

Alliance Laundry Systems Huebsch DR5102WG Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems LES33 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems CHD25G2 Instrucciones de funcionamiento

Alliance Laundry Systems

Alliance Laundry Systems AT120FG Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems BA120L Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems BD3LLFGS401UW01 Instrucciones de funcionamiento

Alliance Laundry Systems

Alliance Laundry Systems D310IE3B Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems DRY710C Guía

Alliance Laundry Systems

Alliance Laundry Systems CHD25G2-CA025L Manual del propietario

Alliance Laundry Systems

Alliance Laundry Systems PD3JGBGS403UG01 Manual del propietario

Alliance Laundry Systems

Alliance Laundry Systems ADE3TFWS431AW01 Instrucciones de funcionamiento

Alliance Laundry Systems

Alliance Laundry Systems TMB795C Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems ADEE9BGS433XW34 Manual de usuario

Manuales populares de Secadora de otras marcas

Bosch

Bosch WTA79200GB Manual de usuario

Amana

Amana W10233410A Manual de usuario

Miele

Miele TWH 780 WP Manual de usuario

Asko

Asko T760 Manual de usuario

Bosch

Bosch Logixx 10 WTB76556GB Hoja de especificaciones

STIEBEL ELTRON

STIEBEL ELTRON Ultronic S Manual de instrucciones

Electrolux

Electrolux EW2H328R2 Manual de usuario

Beko

Beko DS8433RX1M Manual de usuario

Dawlance

Dawlance Spinner DS 6000 C Manual de usuario

Electrolux

Electrolux TP5080TW Manual de usuario

AEG

AEG TR838P4OB Manual de usuario

Indesit

Indesit IDV 75 Manual de usuario

Infiniton

Infiniton SD-DG85C Manual de usuario

BOMANN

BOMANN WT 5019 Manual de usuario

Asko

Asko T793C Manual de usuario

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer Manual de usuario

Frigidaire

Frigidaire CAQE7077KW0 Manual del propietario

Bosch

Bosch WTX8HKM9SN Manual de usuario