AFe Power Magnum FORCE Manual de usuario

advanced FLOW engineering Magnum FORCE Stage-2 Air Intake System

Instruction Manual P/N: 51-12642-1B / 54-12642-1B / 52-12642-1H

Make: Ford Model: F-150 Year: 2015-2021 Engine: V6-2.7L (tt) EcoBoost

Make: Ford Model: F-150 Year: 2015-2016 Engine: V6-3.5L (tt) EcoBoost

(CARB exempt 15-16 under D-550-28 only)

Label Qty. Description Part Number

A1 2 Air Filter (Pro DRY S) 21-90069 (51-12642-B/52-12642-H)

A2 2 Air Filter (Pro 5R) 24-90069 (54-12642/52-12642-H)

B1 1 Tube #1 of 2 05-12642B1 (For 51/54-12642-B)

B2 1 Tube #2 of 2 05-12642B2 (For 51/54-12642-B)

B3 1 Tube #1 of 2 05-12642H1 (For 52-12642-H)

B4 1 Tube #2 of 2 05-01242H2 (For 52-12642-H)

C1 1 Housing 05-12642B3 (For 51/54-12642-B)

C2 1 Housing 05-12642L3 (For 52-12642-H)

D 1 Coupling, Straight 05-01242

E 1 Coupling, Reducer 05-01358

F 1 Coupling, Reducer 05-01331

G 2 Clamp #060 03-50002

H 1 Clamp #072 03-50010

I 2 Clamp #032 03-50016

J 1 Clamp #052 03-50008

K 1 Grommet 03-50050

L 1 Seal Trim (23") 05-00072

M 1 Cover 05-12188-B (*Optional)

N 3 Screws 03-50113 (*Optional)

O 1 Vent Insert 05-01405

Installation will require the following tools:

8mm Nut Driver, Flat Head Screwdriver

• Please read the entire instruction manual before proceeding.

• Ensure all components listed are present.

• If you are missing any of the components, call customer support at 951-493-7100.

• Ensure you have all necessary tools before proceeding.

• Do not attempt to work on your vehicle when the engine is hot.

• Disconnect the negative battery terminal before proceeding.

NOTE: Retain factory parts for future use.

Page 2

aFepower.com

Page 3

A1 A2

C1/C2

Refer to Figure A for steps 1-4

Step 1: Disconnect the Manifold Air Pressure (MAP) sensor plug from stock airbox. 1

Step 2: Loosen the OE intake clamps using an 8mm nut driver from the left and right side runners. 2

Step 3: Unclamp the top portion of the OE airbox. 3

Step 4: Remove the OE intake and the top portion of the OE airbox by pulling straight up and out of the

vehicle.

REMOVAL

Page 4

Figure A

Refer to Figure B for step 5

Step 5: Carefully remove plastic wire harness clips from back edge of lower airbox.

Figure B

Page 5

REMOVAL

aFepower.com

Refer to Figure C for steps 6-7

Step 6: Install aFe housing and fasten clips.

Step 7: Insert ﬁlters and place clamps loosely.

Page 6

INSTALL

Figure C

aFepower.com

Refer to Figure D for steps 8-9

Step 8: Remove the MAP sensor from the OE intake 1/4 turn counter-clockwise.

Step 9: Install the MAP sensor on the rear aFe intake tube using the provided grommet. The grommet

can be held inside the tube to give support while inserting.

Figure D

Page 7

INSTALL

Refer to Figure E for steps 10-14

Step 10: Install the small straight coupling on the cross over tube, install clamps, but do not tighten.

Step 11: Fit tubes into the remaining couplers. Adjust for best ﬁt and tighten all clamps.

Step 12: Connect sensor harness.

Step 13:Install edge trim on housing if no cover is to be used.

Step 14: Remove trim if using optional cover.

NOTE: Proceed to the following pages for vent insert on 2016 models.

Figure E

INSTALL

Page 8

Page 9

(These procedures should be done with the inlet tubes installed on the engine. It is shown off the vehicle

for better illustration.)

Step 15: Locate the o.e. plastic tube feeding the driver’s side turbo inlet.

aFepower.com

Refer to Figure F for Step 15

Figure F

INSTALL

Vent insert installation:

Page 10

Refer to Figure G for Step 16

Step 16: Locate the valve cover vent tube that feeds into driver’s side turbo inlet. It is not

necessary to remove the engine cover.

Figure G

INSTALL

Tabla de contenidos

Otros manuales de Accesorios para automóviles de aFe Power

aFe Power

aFe Power 52-10002D Manual de usuario

aFe Power

aFe Power 77-47001 Manual de usuario

aFe Power

aFe Power 46-39102 Manual de usuario

aFe Power

aFe Power SCORCHER GT 77-47004 Manual de usuario

aFe Power

aFe Power 05-01016 Manual de usuario

aFe Power

aFe Power advanced FLOW engineering Manual de usuario

aFe Power

aFe Power Scorpion 79-21005L Manual de usuario

aFe Power

aFe Power advanced FLOW engineering Manual de usuario

aFe Power

aFe Power Scorpion 79-21001L Manual de usuario

aFe Power

aFe Power dfs780 Manual de usuario

aFe Power

aFe Power 54-12208 Manual de usuario

aFe Power

aFe Power 46-70162 Manual de usuario

aFe Power

aFe Power Takeda 56-10005D Manual de usuario

aFe Power

aFe Power Scorcher Manual de usuario

aFe Power

aFe Power 77-83046 Manual de usuario

aFe Power

aFe Power 46-71180A Manual de usuario

aFe Power

aFe Power SCORCHER 77-44008 Manual de usuario

aFe Power

aFe Power 77-43025 Manual de usuario

aFe Power

aFe Power Momentum hd Manual de usuario

aFe Power

aFe Power 51-74201 Manual de usuario

aFe Power

aFe Power SCORPION 79-21003L Manual de usuario

aFe Power

aFe Power takeda 56-70005D Manual de usuario

aFe Power

aFe Power QUANTUM 53-10005D Manual de usuario

aFe Power

aFe Power 46-20299-B Manual de usuario

Manuales populares de Accesorios para automóviles de otras marcas

James Baroud

James Baroud Odyssey Manual de usuario

Motorola

Motorola i50sx Manual de usuario

Yakima

Yakima 9MM STANDARD BIKE MOUNT Manual de usuario

Feniex

Feniex T3 Manual de usuario

Renault

Renault 77 11 423 180 Manual de usuario

Kia

Kia E8300-4D000 Manual de usuario

Brink

Brink 756843 Manual de usuario

Whispbar

Whispbar K085W Manual de usuario

v.link

v.link CI-VL2-PC-HSD Manual de usuario

Viking

Viking Stack-Rack Guía de configuración rápida

Aries

Aries 203015 Manual de usuario

Choetech

Choetech AT0005 Manual de usuario

ZZ2

ZZ2 ZZAIR-PRO Manual de usuario

Holman

Holman 4A80L Manual de usuario

Thule

Thule 2075 Manual de usuario

Motorola

Motorola T325 Manual de usuario

TAUBENREUTHER

TAUBENREUTHER 16-3950 Guía de instalación

DV8

DV8 FBJL-02 Manual de usuario

aFe Power Magnum FORCE Manual de usuario

Manuales populares de Accesorios para automóviles de otras marcas