Advantech PCIE-1756 Manual de usuario

PCIE-1756

64-ch Isolated Digital I/O PCI

Express Card

User Manual

PCIE-1756 User Manual ii

The documentation and the software included with this product are copy-

righted 2012 by Advantech Co., Ltd. All rights are reserved. Advantech

Co., Ltd. reserves the right to make improvements in the products

described in this manual at any time without notice. No part of this man-

ual may be reproduced, copied, translated or transmitted in any form or

by any means without the prior written permission of Advantech Co., Ltd.

Information provided in this manual is intended to be accurate and reli-

able. However, Advantech Co., Ltd. assumes no responsibility for its use,

nor for any infringements of the rights of third parties, which may result

from its use.

Acknowledgements

Intel and Pentium are trademarks of Intel Corporation.

Microsoft Windows and MS-DOS are registered trademarks of

Microsoft Corp.

All other product names or trademarks are properties of their respective

owners.

Part No. 2003E75610 1st Edition

Printed in Taiwan March 2012

iii

Product Warranty (2 years)

Advantech warrants to you, the original purchaser, that each of its prod-

ucts will be free from defects in materials and workmanship for two years

from the date of purchase.

This warranty does not apply to any products which have been repaired or

altered by persons other than repair personnel authorized by Advantech,

or which have been subject to misuse, abuse, accident or improper instal-

lation. Advantech assumes no liability under the terms of this warranty as

a consequence of such events.

Because of Advantech’s high quality-control standards and rigorous test-

ing, most of our customers never need to use our repair service. If an

Advantech product is defective, it will be repaired or replaced at no

charge during the warranty period. For out-of-warranty repairs, you will

be billed according to the cost of replacement materials, service time and

freight. Please consult your dealer for more details.

If you think you have a defective product, follow these steps:

1. Collect all the information about the problem encountered. (For

example, CPU speed, Advantech products used, other hardware

and software used, etc.) Note anything abnormal and list any

onscreen messages you get when the problem occurs.

2. Call your dealer and describe the problem. Please have your man-

ual, product, and any helpful information readily available.

3. If your product is diagnosed as defective, obtain an RMA (return

merchandize authorization) number from your dealer. This allows

us to process your return more quickly.

4. Carefully pack the defective product, a fully-completed Repair and

Replacement Order Card and a photocopy proof of purchase date

(such as your sales receipt) in a shippable container. A product

returned without proof of the purchase date is not eligible for war-

ranty service.

5. Write the RMA number visibly on the outside of the package and

ship it prepaid to your dealer.

PCIE-1756 User Manual iv

This product has passed the CE test for environmental specifications

when shielded cables are used for external wiring. We recommend the use

of shielded cables. This kind of cable is available from Advantech. Please

contact your local supplier for ordering information.

FCC Class A

This equipment has been tested and found to comply with the limits for a

Class A digital device, pursuant to part 15 of the FCC Rules. These limits

are designed to provide reasonable protection against harmful interfer-

ence when the equipment is operated in a commercial environment. This

equipment generates, uses, and can radiate radio frequency energy and, if

not installed and used in accordance with the instruction manual, may

cause harmful interference to radio communications. Operation of this

equipment in a residential area is likely to cause harmful interference in

which case the user will be required to correct the interference at his own

expense.

Technical Support and Assistance

Step 1. Visit the Advantech web site at www.advantech.com/support

where you can find the latest information about the product.

Step 2. Contact your distributor, sales representative, or Advantech's cus-

tomer service center for technical support if you need additional

assistance. Please have the following information ready before

you call:

- Product name and serial number

- Description of your peripheral attachments

- Description of your software (operating system, version, appli-

cation software, etc.)

- A complete description of the problem

- The exact wording of any error messages

Packing List

Before setting up the system, check that the items listed below are

included and in good condition. If any item does not accord with the

table, please contact your dealer immediately.

• PCIE-1756 DA&C Card

• StartUp or User Manual

• Companion DVD-ROM with DAQNavi drivers included

Safety Precaution - Static Electricity

Follow these simple precautions to protect yourself from harm and the

products from damage.

1. To avoid electrical shock, always disconnect the power from your

PC chassis before you work on it. Don't touch any components on

the CPU card or other cards while the PC is on.

2. Disconnect power before making any configuration changes. The

sudden rush of power as you connect a jumper or install a card may

damage sensitive electronic components.

PCIE-1756 User Manual vi

vii

Contents

Chapter 1 Introduction ..................................................... 2

1.1 Features ............................................................................. 2

1.2 Applications ..................................................................... 5

1.3 Installation Guide ............................................................. 5

Figure 1.1:Installation Flow Chart ................................. 6

1.4 Software Overview ........................................................... 7

1.5 DAQNavi Device Driver Programming Roadmap .......... 8

1.6 Accessories........................................................................ 9

Chapter 2 Installation ..................................................... 12

2.1 Unpacking ....................................................................... 12

2.2 Driver Installation ........................................................... 13

Figure 2.1:Setup Screen of Advantech Automation Soft-

ware 13

Figure 2.2:DAQNavi Installation Setup Screen .......... 14

2.3 Hardware Installation ...................................................... 15

2.4 Device Setup & Configuration ....................................... 16

Figure 2.3:The Device Setting of PCIE-1756 .............. 16

Figure 2.4:The Digital I/O Setting Page ...................... 17

Figure 2.5:The Device Testing of PCIE-1756 ............. 18

Chapter 3 Signal Connections ........................................ 20

3.1 Overview ......................................................................... 20

3.2 Switch and Jumper Settings ........................................... 20

Figure 3.1:Connector and Switch Locations ................ 20

3.2.1 Board ID (SW1) ........................................................... 21

Table 3.1:Board ID Setting (SW1) .............................. 21

3.2.2 Power On Configuration(JP1) ..................................... 22

Table 3.2:Power on configuration after hot reset (JP1) 22

3.2.3 Channel-Freeze Function (JP2) ................................... 22

Table 3.3:Channel-Freeze Function Input Mode (JP2) 22

3.3 Signal Connections.......................................................... 23

Figure 3.2: I/O Connector Pin Assignments ................ 23

3.3.1 I/O Connector Pin Definition ....................................... 24

Table 3.4:I/O Connector Signal Descriptions .............. 24

3.3.2 Isolated Digital Input ................................................... 25

Figure 3.3:Isolated Digital Input Connection .............. 25

3.3.3 Isolated Digital Output ................................................. 26

Figure 3.4:Isolated Digital Output Connection ............ 26

3.3.4 Channel-Freeze Function ............................................. 27

Figure 3.5:Wiring in wet contact input mode .............. 27

Figure 3.6:Wiring in dry contact input mode .............. 27

3.4 Field Wiring Considerations .......................................... 28

Appendix A Specifications ................................................. 30

PCIE-1756 User Manual viii

A.1 Isolated Digital Input....................................................... 30

A.2 Isolated Digital Output .................................................... 30

A.3 General ............................................................................ 31

Appendix B Block Diagrams ............................................. 34

Appendix C ADAM-3951 Pin Assignment ....................... 36

Figure C.1:Connect to PCL-10250 CON1 ................... 36

Figure C.2:Connect to PCL-10250 CON2 ................... 37

CHAPTER

Introduction

This chapter introduces the PCIE-1756

cards and their typical applications.

Sections include:

• Features

• Applications

• Installation Guide

• Software Overview

• Device Driver Roadmap

• Accessories

PCIE-1756 User Manual 2

Chapter 1 Introduction

Thank you for buying the Advantech PCIE-1756 which is a 32/32-ch

isolated digital input/output card. It is an advanced-performance data

acquisition card based on 32-bit PCI Express bus architecture. It features

a unique circuit design and complete functions for data acquisition and

control. The following sections of this chapter will provide further

information about features of PCIE-1756, a Quick Start for installation,

together with some brief information on software and accessories.

1.1 Features

• 32/32 isolated digital input/output channels

• Wide input range (10 ~ 30 VDC)

• Either +/- voltage input for DI by group

• Wide output range (5 ~ 40 VDC)

• High sink current on isolated output channels (500mA max./ch)

• High over-voltage protection (70 VDC)

• High-voltage isolation (2,500 VDC)

• 2,000 VDC ESD protection

• Output status read-back

• Keeps the output settings and values after system hot reset

• Interrupt handling capability

• Channel-freeze function

• Board ID

PCIE-1756 offers the following main features:

Robust Protection

The PCIE-1756 features a robust isolation protection for applications in

industrial, lab and machinery automation. The PCIE-1756 can durably

withstand a voltage up to 2,500 VDC, preventing your host system from

any incidental harms.

Tabla de contenidos

Otros manuales de Hardware de computadora de Advantech

Advantech

Advantech ASMB-816 Series Manual de usuario

Advantech

Advantech AIMB-279 Manual de usuario

Advantech

Advantech AIMB-707 Manual de instalación y operación

Advantech

Advantech SOM-5786 Manual de usuario

Advantech

Advantech ITA-2230 Series Manual de instalación y operación

Advantech

Advantech SKY-MXM-T1000 Manual de usuario

Advantech

Advantech PCE-5B05V-30B1E Manual de instalación y operación

Advantech

Advantech PCL-846 Series Manual de usuario

Advantech

Advantech PCM-3350 Series Manual de usuario

Advantech

Advantech PCM-9591 Manual de instalación y operación

Advantech

Advantech PCL-740 Manual de usuario

Advantech

Advantech MIC-3365 Manual de usuario

Advantech

Advantech PCL-818L Manual de usuario

Advantech

Advantech PCA-6654 Manual de usuario

Advantech

Advantech PCIE-1158 Manual de instalación y operación

Advantech

Advantech HPC-6240 Manual de usuario

Advantech

Advantech ASMB-588 Manual de instalación y operación

Advantech

Advantech SOM-E780 Manual de usuario

Advantech

Advantech PCIE-1753 Manual de usuario

Advantech

Advantech PCA-6148 Manual de usuario

Advantech

Advantech ASMB-785 Manual de instalación y operación

Advantech

Advantech AdvLinuxTU Manual de usuario

Advantech

Advantech EPD-332 Manual de usuario

Advantech

Advantech PCA-6143P Manual de usuario

Manuales populares de Hardware de computadora de otras marcas

EMC2

EMC2 VNX Series Manual del propietario

Panasonic

Panasonic DV0PM20105 Manual de usuario

Mitsubishi Electric

Mitsubishi Electric Q81BD-J61BT11 Manual de usuario

Gigabyte

Gigabyte B660M DS3H AX DDR4 Manual de usuario

Raidon

Raidon iT2300 Manual de usuario

National Instruments

National Instruments PXI-8186 Manual de usuario

Hauppauge

Hauppauge WinTV-HVR-2250 Manual de usuario

Kontron

Kontron CP6002 Manual de usuario

Manhattan

Manhattan 702843 Manual de usuario

Aphex

Aphex 230 Manual de usuario

AMD

AMD Phenom II Manual operacional

Intel

Intel NUC 12 Pro Manual de usuario

dbx

dbx Zone Pro 1260 Manual de usuario

Galaxy

Galaxy GHDX2-2430S-24F4D Manual de usuario

Intel

Intel AXXRMFBU4 Manual de usuario

Kontron

Kontron DIMM-PC/MD Manual de usuario

ST X-NUCLEO-SAFEA1B Instrucciones de funcionamiento

STEINWAY LYNGDORF

STEINWAY LYNGDORF SP-1 Manual de usuario