Whispbar K905W Manual de usuario

K905W

Fitting Kit

EN Fitting Instructions for Basic Carrier

x 8 x 1 x 8 x 8

x 1 x 16 x 8 x 16

x 8 x 8

Revision No: 3C 1

Fitting Kit K905W

MAX kgs (lbs)

W/P WHD

LDV

V80 Maxus, 5dr Van 11-+ EU 100 kgs (220 lbs) 100 kgs (220 lbs)

V80 Maxus, 5dr Van 11-+ CN 100 kgs (220 lbs) 100 kgs (220 lbs)

V80 SWB Low Roof, 5dr Van 11-+ NZ 100 kgs (220 lbs) 100 kgs (220 lbs)

V80 SWB Low Roof, 5dr Van 14-+ AU 100 kgs (220 lbs) 100 kgs (220 lbs)

Fitting Kit K905W

V80 Maxus, 5dr Van 11-+ (EU)

V80 Maxus, 5dr Van 11-+ (CN)

V80 SWB Low Roof, 5dr Van 11-+ (NZ)

V80 SWB Low Roof, 5dr Van 14-+ (AU)

A B C 1 2 3

150mm 890mm 1630mm 1290mm 1290mm 1290mm

5 7/8ths" 35 1/16ths" 64 3/16ths" 50 13/16ths" 50 13/16ths" 50 13/16ths"

150mm 890mm 1630mm 1290mm 1290mm 1290mm

5 7/8ths" 35 1/16ths" 64 3/16ths" 50 13/16ths" 50 13/16ths" 50 13/16ths"

150mm 890mm 1630mm 1290mm 1290mm 1290mm

5 7/8ths" 35 1/16ths" 64 3/16ths" 50 13/16ths" 50 13/16ths" 50 13/16ths"

150mm 890mm 1630mm 1290mm 1290mm 1290mm

5 7/8ths" 35 1/16ths" 64 3/16ths" 50 13/16ths" 50 13/16ths" 50 13/16ths"

1290mm

50 13/16ths"

1290mm

50 13/16ths"

1290mm

50 13/16ths"

1290mm

50 13/16ths"

2370mm

93 2/8ths"

2370mm

93 2/8ths"

2370mm

93 2/8ths"

2370mm

93 2/8ths"

Fitting Kit EN

K905W

Items you will require:

●Tape measure

Pen

Hammer

Cordless drill

Depth stop

Vacuum cleaner

Rust inhibitor

Small paint brush

Neutral cure silicon sealant

Rivet gun

First Time Installation

●Remove parts from inside the package and

check. Contact your dealer if any parts are

missing or damaged.

●This kit fits type A, B, C and D.

●These instructions show type A crossbar

fitted. They also apply to type B, C and D.

Fitting Kit EN

K905W

●Use keys to remove covers.

●Use hex screwdriver to reverse adjusting

screw 10 turns.

●Remove plastic clamp block by gripping bar

leg with fingers and push firmly with

thumbs until clamp block drops out behind

leg.

Fitting Kit EN

K905W

●Select plastic internal block (from fitting kit)

and insert into foot.

●Repeat for all legs.

●Permanent Mount Fitment

●Apply masking tape to vehicle roof in all

positions.

Fitting Kit EN

K905W

●Place mounting block into position as

shown.

●Repeat for all positions.

●Fit rubber pads (supplied with fitting kit) to

foot. Pad may vary in shape to that shown.

●Make sure the pad fits into the holes

underneath the foot.

●Place crossbar on vehicle.

●Adjust crossbar in or out to suit vehicle.

Refer to the crossbar instructions for

crossbar adjustment.

●Make sure there is no interference between

what you intend to carry with aerials,

sunroof or tailgate.

●Mark as shown.

●Lightly mark position of outside holes of the

mounting block in the roof channel.

Fitting Kit EN

K905W

●CAUTION: Maximum depth 7mm.

Use 7mm drillstop over supplied 4.9mm

drill bit.

Drill two outside holes at marked positions.

●Take care not to drill too deep.

●Remove tape.

●Vacuum and clean swarf from channel.

●Treat holes to prevent corrosion.

Fitting Kit EN

K905W

●Apply neutral cure silicon sealant in and

around drilled holes.

●Install rivets through permanent mount

blocks.

●Rivet into place.

WARNING: Do not use countersunk screws as an

alternative fixing method to the rivets supplied with

this kit.

Fitting Kit EN

K905W

●Assemble as shown.

Fitment

●Select grubscrews and screw into the

vehicle's fixed points.

●Do not over tighten.

●Repeat for all positions.

●Fit nut to grubscrew.

Tabla de contenidos

Otros manuales de Accesorios para automóviles de Whispbar

Whispbar

Whispbar K386W Manual de operación e instalación

Whispbar

Whispbar K931W Manual de usuario

Whispbar

Whispbar K855W Manual de usuario

Whispbar

Whispbar K192W Manual de usuario

Whispbar

Whispbar K472W Manual de usuario

Whispbar

Whispbar K469W Manual de usuario

Whispbar

Whispbar K500W Manual de usuario

Whispbar

Whispbar K797W Manual de usuario

Whispbar

Whispbar K566W Manual de usuario

Whispbar

Whispbar K082W Manual de usuario

Whispbar

Whispbar K988W Manual de usuario

Whispbar

Whispbar K112W Manual de usuario

Whispbar

Whispbar K740W Manual de operación e instalación

Whispbar

Whispbar K600W Manual de usuario

Whispbar

Whispbar K031W Manual de operación e instalación

Whispbar

Whispbar K937W Manual de usuario

Whispbar

Whispbar K449W Manual de usuario

Whispbar

Whispbar K186W Manual de usuario

Whispbar

Whispbar K340W Manual de operación e instalación

Whispbar

Whispbar K372W Manual de usuario

Whispbar

Whispbar K482W Manual de usuario

Whispbar

Whispbar K375W Manual de usuario

Whispbar

Whispbar S43W Manual de usuario

Whispbar

Whispbar WB201 Manual de usuario

Manuales populares de Accesorios para automóviles de otras marcas

James Baroud

James Baroud Odyssey Manual de usuario

Motorola

Motorola i50sx Manual de usuario

Yakima

Yakima 9MM STANDARD BIKE MOUNT Manual de usuario

Feniex

Feniex T3 Manual de usuario

Renault

Renault 77 11 423 180 Manual de usuario

Kia

Kia E8300-4D000 Manual de usuario

Brink

Brink 756843 Manual de usuario

v.link

v.link CI-VL2-PC-HSD Manual de usuario

Viking

Viking Stack-Rack Guía de configuración rápida

Aries

Aries 203015 Manual de usuario

Choetech

Choetech AT0005 Manual de usuario

ZZ2

ZZ2 ZZAIR-PRO Manual de usuario

Holman

Holman 4A80L Manual de usuario

Thule

Thule 2075 Manual de usuario

Motorola

Motorola T325 Manual de usuario

TAUBENREUTHER

TAUBENREUTHER 16-3950 Guía de instalación

DV8

DV8 FBJL-02 Manual de usuario

Prorack

Prorack K1163 Manual de usuario