Whispbar K505W Manual de usuario

K505W

Fitting Kit

EN Fitting Instructions for Basic Carrier

x 4 x 4 x 4 x 8

x 4 x 2 x 1 x 1

x 4 x 2 x 2

Revision No: 7C 1

Fitting Kit K505W

MAX kgs (lbs)

W/P WHD

Hyundai

ix35 , 5dr SUV 10-+ EU 75 kgs (165 lbs) 75 kgs (165 lbs)

Fitting Kit EN

K505W

First Time Installation

●Remove parts from inside the package and

check. Contact your dealer if any parts are

missing or damaged.

●This kit fits type A, B, C and D.

●These instructions show type A crossbar

fitted. They also apply to type B, C and D.

●Use keys to remove covers.

Fitting Kit EN

K505W

●Use hex screwdriver to reverse adjusting

screw 10 turns.

●Press adjusting screw and pull crossbar

legs out. Refer to the crossbar instructions

for crossbar adjustment method.

●Ensure each end of the crossbar is

adjusted equally.

●Set bars to length (revert to rear of these

instructions).

●Clamps onto flush roof rail. Pins locate on

inside of rail.

Fitting Kit EN

K505W

●Tighten adjusting screw to 5 Nm (3.7 ft lb)

hand tight.

●Remove plastic clamp block by gripping bar

leg with fingers and push firmly with

thumbs until clamp block drops out behind

leg.

●Remove both pins from each leg. Use

tapered end of spanner located inside left

hand cover to assist.

Fitting Kit EN

K505W

●Detach foot from leg. Store loose parts in a

safe place.

●Repeat for all legs.

●Select four feet assemblies and match the

left and right assemblies to the left and

right roof rack legs.

●Assemble foot from kit into leg by pressing

it down.

●Ensure foot interlocks with leg.

●Using short capscrew and washer, secure

assembly onto leg (use Hex Screwdriver

supplied with crossbar to assist)

●Do not over tighten.

●Repeat for all legs.

Fitting Kit EN

K505W

●Use two M5 x 12 mm self tapping screws to

secure the assembly onto the leg.

●Do not over tighten.

Fitment

●Locate two holes at each position along the

inside of the roof rails.

●Place crossbars approximately above

these holes on roof rails.

●Ensure back edge of foot sits flush with the

back edge of vehicle roof rail.

●NOTE: FRONT CROSSBAR ONLY

●Ensure the clamp point faces towards the

front of vehicle.

Fitting Kit EN

K505W

●Apply protective strip as shown.

Trim if required.

●It is important to put the clamps in the

correct position on the vehicle.

●Letters refer to the part numbers stamped

on clamps.

●Clamp Part Number:

A = 685D

B = 731A

C = 732A

●Ensure the two pins of the clamp engages

correctly with the holes in the roof rail.

●Place one hand on the leg and apply

downward pressure.

●Slide clamp through opening in leg.

Fitting Kit EN

K505W

●Thread the coach bolt through the clamp

and the leg.

●Ensure the two pins of the clamp engages

correctly with the holes in the roof rail.

●Tighten the plastic knob.

●Ensure the plastic knob is in the position

shown when fully tightened.

●Do not over tighten.

●Repeat for all four positions.

●Ensure the clamp engages correctly on

inside of roof rail.

●Use keys to fit and lock covers

●Check crossbar is securely attached to the

vehicle.

Fitting Kit EN

K505W

CAUTION: Recheck all fasteners immediately after

a load is applied to the crossbars.

Regularly check screws are tight.

Otros manuales para K505W

Tabla de contenidos

Otros manuales de Accesorios para automóviles de Whispbar

Whispbar

Whispbar K088W Manual de usuario

Whispbar

Whispbar K303W Manual de usuario

Whispbar

Whispbar K111W Manual de usuario

Whispbar

Whispbar K387W Manual de usuario

Whispbar

Whispbar K827W Manual de usuario

Whispbar

Whispbar K308W Manual de usuario

Whispbar

Whispbar K086W Manual de usuario

Whispbar

Whispbar K470W Manual de operación e instalación

Whispbar

Whispbar K663W Manual de usuario

Whispbar

Whispbar K927 Manual de usuario

Whispbar

Whispbar K453W Guía de instalación

Whispbar

Whispbar K424W Manual de usuario

Whispbar

Whispbar K083W Manual de usuario

Whispbar

Whispbar K411W Manual de operación e instalación

Whispbar

Whispbar K359W Manual de operación e instalación

Whispbar

Whispbar WB751 Manual de usuario

Whispbar

Whispbar K651W Manual de operación e instalación

Whispbar

Whispbar K432W Manual de usuario

Whispbar

Whispbar WB300 Manual de usuario

Whispbar

Whispbar K619W Manual de operación e instalación

Whispbar

Whispbar K078W Manual de usuario

Whispbar

Whispbar K590W Manual de usuario

Whispbar

Whispbar K525W Manual de usuario

Whispbar

Whispbar K174W Manual de usuario

Manuales populares de Accesorios para automóviles de otras marcas

James Baroud

James Baroud Odyssey Manual de usuario

Motorola

Motorola i50sx Manual de usuario

Yakima

Yakima 9MM STANDARD BIKE MOUNT Manual de usuario

Feniex

Feniex T3 Manual de usuario

Renault

Renault 77 11 423 180 Manual de usuario

Kia

Kia E8300-4D000 Manual de usuario

Brink

Brink 756843 Manual de usuario

v.link

v.link CI-VL2-PC-HSD Manual de usuario

Viking

Viking Stack-Rack Guía de configuración rápida

Aries

Aries 203015 Manual de usuario

Choetech

Choetech AT0005 Manual de usuario

ZZ2

ZZ2 ZZAIR-PRO Manual de usuario

Holman

Holman 4A80L Manual de usuario

Thule

Thule 2075 Manual de usuario

Motorola

Motorola T325 Manual de usuario

TAUBENREUTHER

TAUBENREUTHER 16-3950 Guía de instalación

DV8

DV8 FBJL-02 Manual de usuario

Prorack

Prorack K1163 Manual de usuario