Whispbar K324W Manual de usuario

K324W

Fitting Kit

EN Fitting Instructions for Basic Carrier

x 8 x 4 x 4 x 4

Revision No: 6F 1

Fitting Kit EN

K324W

First Time Installation

●Remove parts from inside the package and

check. Contact your dealer if any parts are

missing or damaged.

●This kit fits type A, B, C and D.

●These instructions show type A crossbar

fitted. They also apply to type B, C and D.

●Use keys to remove covers.

Fitting Kit EN

K324W

●Use hex screwdriver to reverse adjusting

screw 10 turns.

●Press adjusting screw and pull crossbar

legs out. Refer to the crossbar instructions

for crossbar adjustment method.

●Ensure each end of the crossbar is

adjusted equally.

●Remove plastic clamp block by gripping bar

leg with fingers and push firmly with

thumbs until clamp block drops out behind

leg.

Fitting Kit EN

K324W

●Remove both pins from each leg. Use

tapered end of spanner located inside left

hand cover to assist.

●Detach foot from leg. Store loose parts in a

safe place.

●Repeat for all legs.

●Select a guttermount assembly from fitting

kit. Unscrew and remove clamps.

Fitting Kit EN

K324W

●Assemble guttermount assembly into leg

(ensure guttermount blade interlocks with

leg).

●Using short capscrew and washer, secure

assembly onto leg (use Hex Screwdriver

supplied with crossbar to assist)

●Tighten firmly (3Nm).

●Use two M5 x 12mm self tapping screws to

secure the leg to the guttermount blade.

●Do not over tighten.

●Repeat for all legs.

●Tighten adjusting screw to 2 Nm (1.5 ft lb)

hand tight.

Fitting Kit EN

K324W

Fitment

●Place crossbar on vehicle. Minimum

recommended spacing between the bars is

700mm (27 1/2") (unless otherwise stated).

●Place crossbar into gutter of vehicle.

●Adjust crossbar in or out to suit vehicle.

Refer to the crossbar instructions for

crossbar adjustment.

●Loosely position crossbar ensuring the

guttermount blade is hard against the

inside of the vehicle gutter.

●Tighten adjusting screw to 2 Nm (1.5 ft lb)

hand tight.

Fitting Kit EN

K324W

●Loosely line up clamp over the vehicle

gutter.

●Use same capscrew and washer to secure

clamp onto leg.

●Once crossbars are in position, tighten

screw to 3 Nm (2.2 ft lb).

●Repeat for all legs.

●Check crossbar is securely attached to the

vehicle.

●Use keys to fit and lock covers

Fitting Kit EN

K324W

CAUTION: Recheck all fasteners immediately after

a load is applied to the crossbars.

Regularly check screws are tight.

Fitting Kit EN

K324W

Maintenance

●Clean the car roof and surfaces of the

product that will be in contact with the car

roof.

●Follow the fitting instructions for fitting the

product to your vehicle. Make sure all steps

are carried out in order.

●Set crossbars a minimum distance of

700mm (27 1/2") apart where no other

distance is specified in the fitting

instructions. This is especially important

when carrying long loads.

●Check unit is securely attached whenever

you refit it to the vehicle. If the unit feels

loose, refer to the fitting instructions and

readjust.

●Some glass/panoramic roofs and radio

antennae may not be able to be used when

the product is fitted.

●Do not modify this product.

●Refer to the maximum permitted load

capacity specified in the fitting instructions.

Do not exceed the vehicle manufacturers

roof load rating if it is lower than the

maximum load capacity specified in the

fitting instructions.

●Loads should not overhang the sides of the

product and be evenly distributed with the

lowest possible centre of gravity.

●Long loads should be secured with non-

elastic straps to the front and rear of the

vehicle.

●Objects with pointed ends (e.g. ski poles)

should be carried with the pointed ends to

the rear of the vehicle.

●Remove all loose or removable objects

from the load prior to loading.

●Make sure all loads are securely fastened

with non-elastic straps. Check regularly

during longer journeys.

●A loaded roof rack system can alter the

performance of your vehicle. Be especially

aware of the effects of side winds,

changing of direction, and braking

performance. Avoid rapid acceleration and

deceleration. Drive carefully.

●Note that the total height of the vehicle

increases when upright loads are carried.

●Products should be locked during transport

if they have locks fitted.

Fitting Kit EN

K324W

●Check and replace worn out or defective

parts.

●Keep the product clean and maintained.

●Never drive into a car wash with the roof

rack system fitted.

●Lubricate locks and adjusting screws at

regular intervals.

●Remove the products from the vehicle

when not in use. Make sure all loose parts

are stored safely.

●Yakima Australia Pty Ltd

17 Hinkler Court

Brendale QLD 4500

AUSTRALIA

www.whispbar.com

www.whispbar.com.au

www.whispbar.co.nz

www.whispbar.co.uk

www.whispbar.co.za

www.whispbar.eu

www.whispbar.ca

Tabla de contenidos

Otros manuales de Accesorios para automóviles de Whispbar

Whispbar

Whispbar K822W Manual de usuario

Whispbar

Whispbar K916W Manual de usuario

Whispbar

Whispbar K838W Manual de operación e instalación

Whispbar

Whispbar K475W Manual de usuario

Whispbar

Whispbar K428 Manual de usuario

Whispbar

Whispbar S11W Manual de usuario

Whispbar

Whispbar K383W Manual de usuario

Whispbar

Whispbar K532W Manual de usuario

Whispbar

Whispbar K488W Manual de usuario

Whispbar

Whispbar K802W Manual de operación e instalación

Whispbar

Whispbar K143W Manual de operación e instalación

Whispbar

Whispbar K420 Manual de usuario

Whispbar

Whispbar K748W Manual de usuario

Whispbar

Whispbar K448W Manual de usuario

Whispbar

Whispbar K513W Manual de usuario

Whispbar

Whispbar K800W Manual de operación e instalación

Whispbar

Whispbar K683W Manual de usuario

Whispbar

Whispbar K526W Manual de usuario

Whispbar

Whispbar K673W Manual de usuario

Whispbar

Whispbar S51W Manual de usuario

Whispbar

Whispbar K677 Manual de usuario

Whispbar

Whispbar K505W Manual de usuario

Whispbar

Whispbar K833W Manual de operación e instalación

Whispbar

Whispbar K192W Manual de usuario

Manuales populares de Accesorios para automóviles de otras marcas

James Baroud

James Baroud Odyssey Manual de usuario

Motorola

Motorola i50sx Manual de usuario

Yakima

Yakima 9MM STANDARD BIKE MOUNT Manual de usuario

Feniex

Feniex T3 Manual de usuario

Renault

Renault 77 11 423 180 Manual de usuario

Kia

Kia E8300-4D000 Manual de usuario

Brink

Brink 756843 Manual de usuario

v.link

v.link CI-VL2-PC-HSD Manual de usuario

Viking

Viking Stack-Rack Guía de configuración rápida

Aries

Aries 203015 Manual de usuario

Choetech

Choetech AT0005 Manual de usuario

ZZ2

ZZ2 ZZAIR-PRO Manual de usuario

Holman

Holman 4A80L Manual de usuario

Thule

Thule 2075 Manual de usuario

Motorola

Motorola T325 Manual de usuario

TAUBENREUTHER

TAUBENREUTHER 16-3950 Guía de instalación

DV8

DV8 FBJL-02 Manual de usuario

Prorack

Prorack K1163 Manual de usuario