Western Digital Ultrastar Serv60+8 Guía rápida

Recommended Rack

Configurations

Ultrastar®Serv60+8

Regulatory Model: H4060-S

February 2019

Rev. 1.0

1ET1640

Long Live Data ™| www.hgst.com

Contents

Revision History..............................................................................................3

Points of Contact.............................................................................................4

Chapter 1 Overview....................................................................................6

1.1 Ultrastar Serv60+8 Rack Requirements............................................6

1.2 Rack Safety........................................................................................7

1.3 CMA Standard Recommended Racks...............................................8

1.4 CMA Lite Recommended Racks........................................................9

1.5 Vertical Rack Rail Settings...............................................................11

1.6 Recommended PDUs and Available Installation Space...................12

Chapter 2 CMA Standard Rack Specifications......................................14

2.1 CRENLO/EMCOR............................................................................14

2.2 AFCO/Legrand.................................................................................14

2.3 TRIPP LITE......................................................................................15

2.4 APC/Schneider.................................................................................16

Chapter 3 CMA Lite Rack Specifications...............................................18

3.1 CRENLO/EMCOR............................................................................18

3.2 AFCO/Legrand.................................................................................18

3.3 TRIPP LITE......................................................................................19

3.4 APC/Schneider.................................................................................20

Chapter 4 Installation...............................................................................22

4.1 PDU Mounting Bracket Installation (KIT-MBVPT-1B).......................22

4.2 PDU Mounting Bracket Installation (KIT-MB-40)..............................29

Contents

Recommended Rack Configurations

Revision History

CommentRevisionDate

Initial ReleaseRevision 1.0January 2019

Revision History

Recommended Rack Configurations

Points of Contact

For further assistance with an HGST product, contact Platform Engineering technical support. Please be

prepared to provide the following information: Serial Number (S/N), product name, model number, and a brief

description of the issue.

Email:

[email protected]

Website:

https://portal.wdc.com/Support/s/

Points of Contact

Recommended Rack Configurations

The following paragraph does not apply to the United Kingdom or any country where such provisions

are inconsistent with local law: HGST a Western Digital company PROVIDES THIS PUBLICATION "AS

IS" WITHOUT WARRANTY OF ANY KIND, EITHER EXPRESS OR IMPLIED, INCLUDING, BUT NOT

LIMITED TO, THE IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR

PURPOSE. Some states do not allow disclaimer or express or implied warranties in certain transactions,

therefore, this statement may not apply to you.

This publication could include technical inaccuracies or typographical errors. Changes are periodically made

to the information herein; these changes will be incorporated in new editions of the publication. HGST may

make improvements or changes in any products or programs described in this publication at any time.

It is possible that this publication may contain reference to, or information about, HGST products (machines

andprograms),programming,orservices that are not announced in yourcountry. Such referencesorinformation

must not be construed to mean that HGST intends to announce such HGST products, programming, or

services in your country.

Technical information about this product is available by contacting your local HGST representative or on the

Internet at: [email protected]

HGST may have patents or pending patent applications covering subject matter in this document. The furnishing

of this document does not give you any license to these patents.

Western Digital

5601 Great Oaks Parkway

San Jose, CA 95119

Long Live Data™is a trademark of HGST, Inc. and its affiliates in the United States and/or other countries.

HGST trademarks are authorized for use in countries and jurisdictions in which HGST has the right to use,

market and advertise the brands.

Other product names are trademarks or registered trademarks of their respective owners.

One MB is equal to one million bytes, one GB is equal to one billion bytes, one TB equals 1,000GB (one trillion

bytes) and one PB equals 1,000TB when referring to storage capacity. Usable capacity will vary from the raw

capacity due to object storage methodologies and other factors.

References in this publication to HGST products, programs or services do not imply that HGST intends to

make these available in all countries in which HGST operates.

Product information is provided for information purposes only and does not constitute a warranty.

Information is true as of the date of publication and is subject to change. Actual results may vary. This publication

is for general guidance only. Photographs may show design models.

Recommended Rack Configurations

Chapter

1 Overview

This section provides an overview of rack requirements and recommendations.

1.1 Ultrastar Serv60+8 Rack Requirements

The Ultrastar Serv60+8 is designed to be installed into a rack that meets the EIA-310 standard at a minimum

1200 mm (47.24in.) of usable rack space, frame to frame. The vertical rack rails must be set between 32 in.

- 36 in. to support the enclosure. It requires 4U of rack space, and it should be installed into the rack at the

lowest possible U height to keep the load on the rack balanced.

Table 1: Required Rack Specifications

RequirementParameter

1200 mm (47.24in.) of usable rack space, frame to

frame

Rack Depth

450mm with (17.72in.) with 465mm (18.31in.) ±

1.5mm nominal hole spacing. See EIA-310 Rack

Standard

Rack Width

4URack Units (U)

32 in. - 36 in.Vertical Rack Rail Spacing

1360.7 kg. / 3000 lbs.Static Load Rating

1020.5 kg. / 2250 lbs.Dynamic Load Rating

Warning: When extended out of the rack on the rail system, the Ultrastar Serv60+8 will

be ~950 mm / 37.4in. extended outward. This may be a potential tipping hazard depending on the

configuration of the rack. Ensure that leveling feet, anti-tilt, and any other safety features recommended

by the specific rack manufacturers have been deployed before servicing.

The following section provides specific information necessary to install, service, and remove the Ultrastar

Serv60+8. The installation of the Ultrastar Serv60+8 requires two people and a space of 1371mm / 54in. in

front of the installation space. The servicing of the enclosure requires one person and a minimum of 1219.2mm

/ 48in. of space in front of the installation space. The removal of the enclosure requires two people, 1371mm

/ 54in. of space in front of the installation space, and 24in. on either side of the enclosure for two people to

remove the enclosure.

Warning: The handles on the front of the chassis are not intended to be used to support the weight of

the Ultrastar Serv60+8. Lifting the unit by the chassis handles or trying to support the unit on the handles

can cause them to fail. This can cause serious damage to the unit or serious bodily harm to those

1 Overview

Recommended Rack Configurations 1.1 Ultrastar Serv60+8 Rack Requirements

handling the unit. Always team lift the chassis by gripping the underside of the unit, and never try to lift

a chassis that is filled with drives.

Figure 1: Installation, Servicing, and Removal

Attention: Do not install or remove the enclosure while it is populated with drives. The fully populated

enclosure exceeds the amount of weight that a team of two should lift.

1.2 Rack Safety

If the chassis is being installed into a rack that will be shipped fully assembled, you must install eight (four

per side) of the included M5 x 10mm T15 Torx screws into the two brackets at the front of the chassis in the

1 Overview

Recommended Rack Configurations 1.2 Rack Safety

following locations. These screws should be tightened to 3.38-3.61 Nm / 30-32 in-lbf using a Long T15 Torx

Screwdriver.

Figure 2: Shipping Bracket Screw Locations

ScrewLocation

1.3 CMA Standard Recommended Racks

The following is a list of racks that are recommended for the Ultrastar Serv60+8 using CMA Standard.

Table 2: Recommended Racks

NotesDimensionsRack

Units

Part NumberVendor

N/AH: 2060mm x W: 600mm x D: 1200mm/

H: 81.1in. x W: 23.6in. x D: 47.2in.

42AS-160099-03EMCOR/CRENLO

N/AH: 2057mm x W: 600mm x D: 1270mm/

H: 80.98in. x W: 23.6in. x D: 50in.

42DC-42U2448-G

N/AH: 2989.2mm x W: 609.6mm x D:

1317.6mm/

H: 98in. x W: 24in. x D: 51.9in.

52WEDIT602AFCO/Legrand

1 Overview

Recommended Rack Configurations 1.3 CMA Standard Recommended Racks

NotesDimensionsRack

Units

Part NumberVendor

N/AH: 2311.4mm x W: 609.6mm x D:

1317.6mm/

H: 91in. x W: 24in. x D: 51.9in.

48WEDIT603

N/AH: 2178.1mm x W: 609.6mm x D:

1317.6mm/

H: 85.75in. x W: 24in. x D: 51.8in.

45WEDIT604

N/AH:2044.7mm x W: 609.6mm x D:

1317.6mm/

H: 80.5in. x W: 24in. x D: 51.8in.

42WEDIT605

N/AH: 2444.8mm x W: 609.6mm x D:

1317.6mm/

H: 96.25in. x W: 24in. x D: 51.8in.

51WEDIT606

The rear door must

be removed when

H: 1991mm x W: 600mm x D: 1222mm

H: 78.4in. x W: 23.6in. x D: 48.18in.

42AR3300WAPC/Schneider

using the standard

CMA with this rack.

N/AH: 2444.8mm x W: 609.6mm x D:

1200mm or 1403.2mm w/ Rack Extender/

H: in. x W: in. x D: in. w/ Rack Extender

42Rack:SR42UBDP

Extender:

SREXTENDER

TRIPP LITE w/

Rack Extender

1.4 CMA Lite Recommended Racks

The following is a list of racks that are recommended for the Ultrastar Serv60+8 using CMA Lite.

Table 3: Recommended Racks

NotesDimensionsRack

Units

Part NumberVendor

N/AH: 2060mm x W: 600mm x D: 1200mm/

H: 81.1in. x W: 23.6in. x D: 47.2in.

42AS-160099-03EMCOR/CRENLO

N/AH: 2057mm x W: 600mm x D: 1270mm/

H: 80.98in. x W: 23.6in. x D: 50in.

42DC-42U2448-G

The enclosure

cannot be installed

H: 2989.2mm x W: 609.6mm x D:

1317.6mm/

H: 98in. x W: 24in. x D: 51.9in.

52WEDIT602AFCO/Legrand

into the U spaces

that are in line with

the front door

stiffeners or the

door latch in the

CMA Lite

conguration.

1 Overview

Recommended Rack Configurations 1.4 CMA Lite Recommended Racks

NotesDimensionsRack

Units

Part NumberVendor

The enclosure

cannot be installed

H: 2311.4mm x W: 609.6mm x D:

1317.6mm/

H: 91in. x W: 24in. x D: 51.9in.

48WEDIT603

into the U spaces

that are in line with

the front door

stiffeners or the

door latch in the

CMA Lite

conguration.

The enclosure

cannot be installed

H: 2178.1mm x W: 609.6mm x D:

1317.6mm/

H: 85.75in. x W: 24in. x D: 51.8in.

45WEDIT604

into the U spaces

that are in line with

the front door

stiffeners or the

door latch in the

CMA Lite

conguration.

The enclosure

cannot be installed

H:2044.7mm x W: 609.6mm x D:

1317.6mm/

H: 80.5in. x W: 24in. x D: 51.8in.

42WEDIT605

into the U spaces

that are in line with

the front door

stiffeners or the

door latch in the

CMA Lite

conguration.

The enclosure

cannot be installed

H: 2444.8mm x W: 609.6mm x D:

1317.6mm/

H: 96.25in. x W: 24in. x D: 51.8in.

51WEDIT606

into the U spaces

that are in line with

the front door

stiffeners or the

door latch in the

CMA Lite

conguration.

N/AH: 1991mm x W: 600mm x D: 1222mm

H: 78.4in. x W: 23.6in. x D: 48.18in.

42AR3300WAPC

N/AH: 2444.8mm x W: 609.6mm x D:

1200mm or 1403.2mm w/ Rack Extender/

H: in. x W: in. x D: in. w/ Rack Extender

42Rack:SR42UBDP

Extender:

SREXTENDER

Tripplite w/ Rack

Extender

1 Overview

Recommended Rack Configurations 1.4 CMA Lite Recommended Racks

Otros manuales para Ultrastar Serv60+8

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Almacenamiento de Western Digital

Western Digital

Western Digital BLACK 2 Manual de usuario

Western Digital

Western Digital WDBVHT0040JCH Manual de usuario

Western Digital

Western Digital WDBAAH0015HCH - My Book Elite Manual de usuario

Western Digital

Western Digital Caviar Green WD15EARX Manual de operación

Western Digital

Western Digital Scorpio Blue WD1200BEVE Instrucciones de instalación

Western Digital

Western Digital My Book WDH1CS10000 Manual de usuario

Western Digital

Western Digital My Book WDH1U10000 Manual de usuario

Western Digital

Western Digital WDBABS3200ABK - My Passport AV Manual de usuario

Western Digital

Western Digital WD1000FYPS Manual de usuario

Western Digital

Western Digital OpenFlex F3 Series Manual de usuario

Western Digital

Western Digital WDBFKT0040BGY-WESN Manual de usuario

Western Digital

Western Digital My Book Mac Edition Manual de usuario

Western Digital

Western Digital WDG2TP10000N - My Book Pro Edition II Hard Drive... Manual de usuario

Western Digital

Western Digital WDMT3200 - My Passport Studio Manual de usuario

Western Digital

Western Digital WDE1MS1200 Manual de usuario

Western Digital

Western Digital WDXUB3200JB - Dual-Option USB Manual de usuario

Western Digital

Western Digital wd Cloud Manual de usuario

Western Digital

Western Digital WDE4360 Manual del producto

Western Digital

Western Digital My Book Studio Manual de usuario

Western Digital

Western Digital WDCaviar Black WD1001FALS Manual de usuario

Western Digital

Western Digital WDXB1200JBR - Dual-option External Hard Drive 120... Manual de usuario

Western Digital

Western Digital MY PASSPORT AIR Manual de usuario

Western Digital

Western Digital VelociRaptor WD3000GLFS Manual de usuario

Western Digital

Western Digital WDBGLG0010HBK Instrucciones de instalación

Manuales populares de Almacenamiento de otras marcas

QNAP

QNAP TS 32PXU Series Manual de usuario

LaCie

LaCie RUGGED RAID Manual de usuario

Freecom

Freecom CLS DOCK Manual de usuario

PNY

PNY Attache P-FD64MBATT3 Manual de usuario

HP StorageWorks MSL2024 Manual de usuario

OLT

OLT 6x6 Maximizer Manual de usuario

Transcend

Transcend JetFlash 160 Manual de usuario

LaCie

LaCie RUGGED MINI Manual de usuario

Thunderbolt

Thunderbolt 600 Manual de usuario

Panasonic

Panasonic LB-DH8 series Manual

Intel

Intel RAID High Availability Manual de usuario

LaCie

LaCie 12big Thunderbolt 3 Manual de usuario

Spectra Logic

Spectra Logic T-Series Spectra T50e Manual de usuario

Panasonic

Panasonic LKM-F931-1 Manual de usuario

Tabernus

Tabernus Enterprise Erase E2400 Manual de usuario

Rocstor

Rocstor COMMANDER 3F series Manual de usuario

HP P9000 Manual de usuario

Dell

Dell PowerVault MD3600f Series Manual de usuario