Webasto Thermo Top E Manual de usuario

WARNING!

Hazard warning:

Incorrect installation or repair of Webasto heating systems may cause a fire or result

in the emission of carbon monoxide, which can be fatal. Serious or fatal injuries can

be caused as a result.

Specialist company training, technical documentation, specialized tools and

equipment are required to install and repair Webasto heating and cooling systems.

NEVER attempt to install or repair Webasto heating or cooling systems if you have not

successfully completed the company training and thereby acquired the required

technical skills, or if you do not have access to the required technical documentation,

tools and equipment needed to carry out correct installation and repairs.

ALWAYS follow all Webasto installation and repair instructions and observe all

warnings.

Webasto does not accept any liability for defects and damage that are attributable to

installation by untrained staff.

Feel the drive

Renault Scenic / Grand Scenic / Megane

(international)

Diesel

from Model Year 2006

Electrical auxiliary heater

Manual transmission

Left-hand drive vehicle

Ident. No.: 1311308C_EN Fee Euro 10 © Webasto AG

Water Heater Unit

Thermo Top E Additional Heater

Thermo Top C Additional Heater

Thermo Top P Additional Heater

Installation Instructions

00 0003

00 0002

00 0104

Renault Scenic / Grand Scenic / Megane

Validity

Vehicle and engine types, equipment variants as well as national specifications, which are not listed in

these installation instructions, have not been tested. However, installation according to these

installation instructions may be possible.

The installation location of a digital timer and summer/winter switch should be confirmed with the end

customer before installation.

Manufacturer Model Type EG-BE No./ABE

Renault Scenic/Grand Scenic JM e2 * 2001/116 * 0274

Engine type Engine model Output in kW Displacement in cm³

F9Q Diesel 96 1870

Manufacturer Model Type EG-BE No./ABE

Renault Megane M e2 * 98/14 * 0272

Engine type Engine model Output in kW Displacement in cm³

K9K Diesel 76 1461

Validity 2

Delivery scope 3

Foreword 3

General Instructions 3

Special Tools 3

Explanatory Notes on Document 4

Preliminary Work 5

Heater unit installation location 5

Preparing electrical system 6

Electrical Connections 7

Fan controller for manual air conditioning 8

Automatic air-conditioning fan controller 10

Remote option (Telestart) 11

Remote option (Thermo Call) 12

Preparing installation location 13

Preparing heater unit 15

Installing heater unit 16

Coolant connection 17

Fuel Connection 21

Combustion air 23

Exhaust system 24

Final Work 26

Operating Instructions for End Customer 27

Table of Contents

Renault Scenic / Grand Scenic / Megane

Delivery scope

Heater unit recommended for the respective vehicle class:

The selection of the heater unit is based on the passenger compartment size of the vehicle and the

level of comfort required by the customer!

Foreword

These installation instructions apply to Renault Scenic / Grand Scenic / Megane Diesel vehicles with

electric auxiliary heater - for validity, see page 2 - from model year 2006 and later, assuming technical

modifications to the vehicle do not affect installation, any liability claims excluded. Depending on the

vehicle version and equipment, modifications may be necessary during installation with respect to

these installation instructions.

However,thestipulationsin the "installationinstructions"and"operatingandmaintenanceinstructions"

for the Thermo Top C/P/E must always be observed.

The corresponding rules of technology and any information from the vehicle manufacturer should be

observed during the installation work.

General Instructions

Installation should be carried out according to the general, standard rules of technology. Unless

specified otherwise, fasten hoses, lines and wiring harnesses to original vehicle lines and wiring

harnesses using cable ties.

Sharp edges should be fitted with edge protectors (split-open plastic hose).

Spray unfinished body areas, e.g. drilled holes, with anti-corrosion wax (Tectyl 100K, Order No.

111329).

Special Tools

- Torque wrench for 2.0 - 10 Nm

- Hose clamping pliers

- Metric thread-setter kit

- Torx E 5 3/8“ nut

- Flexible socket wrench, 7 mm and 10 mm

- Center bit, 36 mm dia

NOTE

Please ask customers to bring in the vehicle with as little fuel in the fuel tank as possible.

Quantity Description Order No.:

1 Retail accessories with desired heater control See Renault price list

1 International installation kit Renault Scenic / Grand Scenic /

Megane from 2003 Diesel 9008865C

Vehicle Heater unit

Compact car Thermo Top E

Mid-size car, station wagon Thermo Top C

Full-size car, van, offroader Thermo Top P

Special features are highlighted using the following symbols:

Mechanical system

Electrical system

Coolant connection

Fuel connection

Exhaust system

Combustion air

The arrow in the vehicle icon indicates the position on

the vehicle and the viewing angle.

Renault Scenic / Grand Scenic / Megane

Specific risk of injury or fatal accidents.

Specific risk of damage to components.

Specific risk of fire or explosion.

Reference to general installation instructions of

Webasto components or to the manufacturer's vehicle-

specific documents.

Reference to a special technical feature.

Explanatory Notes on Document

To provide you with a quick overview of the individual working steps, you will find an identification mark

on the outside top right corner of the page in question.

Renault Scenic / Grand Scenic / Megane

Heater unit installation location

1Heater unit

Installation

location

Preliminary Work

WARNING!

- Depressurize the cooling system.

- Copy the factory number from the original type label to the duplicate type label.

- Remove years that do not apply from the duplicate label.

- Attach the duplicate label (type label) in the appropriate place.

- Remove the battery complete with the carrier plate.

- Remove the air filter together with the intake hose.

- Open the fuel tank cap, ventilate the tank.

- Close the tank cap again.

- Detach the wheel well trim on the right and left.

- Remove the bumper.

- Remove the underride protection of the engine compartment.

- Note the radio security code.

- Remove the A/C control panel according to the manufacturer's specifications.

- Remove the side trim of the instrument panel on the driver's side (only with Telestart option).

- Remove the center console (only with Thermo-Call option).

- Please remove page 27 of the “Operating instructions for the end customer” and add this to the

vehicle operating instructions.

Renault Scenic / Grand Scenic / Megane

Preparing electrical system

For all vehicles

1Perforated bracket

Bending

perforated

bracket

Only with automatic air-conditioning

Cutting

additional

green/

white

(gn/ws)

wire to

length

Complete fuse F4 1 A as shown in wiring

diagram and install on fuse holder. Install

cable section 2in insulating hose provided.

Fuse F4

approx. 160°

90°

gn/ws

1 2

F4 1A

gn/ws

1gn/ws

85 30

87a87

rt/

br rt

swbr

Renault Scenic / Grand Scenic / Megane

Electrical Connections

Fuse holder, K3 relay with manual air

conditioning

16.5 mm hole, perforated bracket, M6x12 bolt,

flanged nut on battery trim

2Retaining plate of fuse holder, K3 relay,

M5x12 bolt, washers, M5 nut on perforated

bracket

Fuse holder, K3 relay with automatic air-

conditioning

16.5 mm hole, perforated bracket, M6x12 bolt,

flanged nut on battery trim

2Retaining plate of fuse holder, K3 relay,

M5x12 bolt, washers, M5 nut on perforated

bracket

3Fuse F4 1 A

Wiring

harness

installation

diagram

Wiring harness pass through

1Protective rubber plug

2Wiring harnesses of fan controller, digital

timer, additional green/white (gn/ws) wire with

automatic air-conditioning

Digital timer and summer/winter switch option

1Digital timer

2Summer/winter switch, drilled hole 12 mm dia.

1 2

Do not install themeteringpump

cableharnessuntillatertogether

with fuel pipe along the original

vehicle fuel lines on the

underbody

1 2

Renault Scenic / Grand Scenic / Megane

Fan controller for manual air

conditioning

Until 02/2006

Expose horizontally running, original vehicle

wiring harness behind A/C control panel.

Produce connections as shown in wiring

diagram.

1Yellow/brown (ge/br) wire from fuse

4Red (rt) wire to K3/87a

2Yellow/brown (ge/br) wire to resistor group

3Black (sw) wire from K3/30

Con-

nection to

resistor

group

From 02/2006

Connection to 6-pin connector 1in left-hand

footwell. Produce connections as shown in

wiring diagram.

2Yellow/brown (ge/br) wire to 6-pin

connector

3Black (sw) wire from K3/30

4Red (rt) wire to K3/87a

5Yellow/brown (ge/br) wire to original

vehicle fuse

Con-

nection to

resistor

group

Renault Scenic / Grand Scenic / Megane

Wiring

diagram

for manual

air con-

ditioning

Webasto components Renault components Colors and symbols

Legend

HG Heater unit TT-C/E GM Fan motor rt red

X1 6-pin connector F Fuse 30A ws white

F3 25 A fan fuse WG Resistor group sw black

K3 Fan relay GS Fan switch br brown

gn green

ge yellow

XCutting point

Wiring colors may vary.

Webasto

Renault

F3 F

rt/ws

gn/

ge/

B1 A1 A2 A3 A4

p1 p2

2 3 4 5 1

85 30

87a87

X1 4

Renault Scenic / Grand Scenic / Megane

Automatic air-conditioning fan

controller

Produce connections as shown in wiring

diagram. Watch direction of flow of diode.

1Yellow/brown (ge/br) wire from fuse F1

7Red (rt) wire to K3/87a

2Yellow/brown (ge/br) wire to fan controller

6Black (sw) wire from K3/30

3Yellow (ge) wire from fuse F2

4Yellow (ge) wire to connector A

5Green/white (gn/ws) wire from fuse F4

Con-

necting air-

con-

ditioning

control

element

Automatic

air-con-

ditioning

circuit

diagram

Webasto components Renault components Colors and symbols

Legend

HG Heater unit TT-C/E GM Fan motor rt red

X1 6-pin connector F1 Fuse 30A ws white

F3 25 A fan fuse F2 15 A fuse sw black

F4 1 A additional fuse KB Air-conditioning control

element br brown

K3 Fan relay GRr Fan controller gn green

D1 1 A diode St A 12-pin connector, blue ge yellow

XCutting point

Wiring colors may vary.

Webasto

Renault

F3 F1

rt/ws

gn/

ge/

F4 KB

gn/wsgn/ws

GRr

St A 10 26

5 2

143

ge/br

X1 4

85 30

87a87

Otros manuales para Thermo Top E

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Calentador de agua de Webasto

Webasto

Webasto Thermo Top E Parking Manual del operador

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto GBW 300 Manual de usuario

Webasto

Webasto Thermo Top C Manual de usuario

Webasto

Webasto thermo top evo Manual de usuario

Webasto

Webasto Thermo Top Z Guía de instalación

Webasto

Webasto Thermo Top C Manual de usuario

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto Thermo Top P Manual de usuario

Webasto

Webasto Thermo Top E Manual del operador

Webasto

Webasto Thermo Top C Manual de usuario

Webasto

Webasto Thermo Top E Manual

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto thermo top evo Manual del operador

Webasto

Webasto Thermo Top C Manual de usuario

Webasto

Webasto Thermo Top C Manual de usuario

Webasto

Webasto thermo top evo Manual de usuario

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto thermo top evo Manual del operador

Webasto

Webasto Thermo Top E Manual de usuario

Webasto

Webasto Thermo Top C Manual de usuario

Webasto

Webasto Thermo Top Pro 120 Manual de usuario

Webasto

Webasto Thermo Top V Manual de usuario

Manuales populares de Calentador de agua de otras marcas

Kenmore

Kenmore 153.582400 Manual de usuario

Applimo

Applimo Edel AIR Manual de usuario

STIEBEL ELTRON

STIEBEL ELTRON Eltronom SHU 5 S Manual de usuario

clage

clage E-Mini Series Manual de usuario

Toyotomi

Toyotomi Oil Miser OM-180 Manual de usuario

Bradford White

Bradford White EF Series Manual de usuario

Eccotemp

Eccotemp 40-H Manual de usuario

Dimplex

Dimplex ECSd125-580 Guía

Dux

Dux 32FCR6N Manual de usuario

Toyotomi

Toyotomi Oil Miser OM-148 (Type D) Guía de solución de problemas

Noritz

Noritz N-132M Manual de instrucciones

TESY

TESY GCV7/4S 10047 Hoja de especificaciones

A.O. Smith

A.O. Smith Gphe 50 Manual de usuario

Koryo

Koryo KWHZF15Y Manual de usuario

Pentair

Pentair PSC-14-4-02 Manual de usuario

GE 40M06AAG Instrucciones de montaje

Thermor

Thermor AEROMAX SPLIT 2 Manual de usuario

American Hometec

American Hometec AHQ-B03X Manual de usuario