Volvo 912-D Manual de usuario
Instruction No Version Part. No.
8698855 1.0
Fuel driven heater 912
-
D
R8703687
Instruction No Version Part. No.
8698855 1.0
Fuel driven heater 912
-
D
R8703687
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation Fuel driven heater 912
-
D
-
8698855
-
V1.0
Side 1 / 24
Equipment
A0000162 A0000163 A0801450
M8703813
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation Fuel driven heater 912
-
D
-
8698855
-
V1.0
Side 2 / 24
M8703808
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation Fuel driven heater 912
-
D
-
8698855
-
V1.0
Side 3 / 24
INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to
minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available
before starting installation.
Certain steps in the instructions are only presented in the form
of images. Explanatory text is also given for more complicated
steps.
In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.
Note!
This accessory requires software unique to the car.
Applies to the V70 XC
1
M8503342
Applies to the V70 XC
Fold the centre seat cushion (1) forwards. Fold the centre
backrest (2) forwards by pulling the lever (3) towards you.
2
Remove the centre backrest. First pull the handle at the top of the
reverse of the backrest. Then pull the backrest upwards.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation Fuel driven heater 912
-
D
-
8698855
-
V1.0
Side 4 / 24
M8503340
Applies to the V70 and V70 XC
3
M8503773
Applies to the V70 and V70 XC
Fold the right
-hand rear seat cushion forward.
4
M8503886
Fold the right
-hand rear backrest forward.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation Fuel driven heater 912
-
D
-
8698855
-
V1.0
Side 5 / 24
5
A8502769
Remove the right
-hand side cushion. First pull the top edge (1)
towards you. Then lift the side cushion upwards (2).
Applies to S60 and S80
6
D8503879
Applies to S60 and S80
Remove the rear seat cushion (1) by pulling it up at the front and
then forwards.
7
Applies to the S80
Fold the right rear backrest forward
Remove the seat belt from the guide (1) on the right-hand side
cushion
Insert a hand down the side of the lower section of the right side
cushion
Release the catches. At the same time lift the side cushion
Put the cushion to one side.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation Fuel driven heater 912
-
D
-
8698855
-
V1.0
Side 6 / 24
D8502762
8
M8503548
Applies to the S60
Fold the right rear backrest forward
Remove the seat belt from the guide (1) on the right side cushion.
9
M8503549
Applies to the S60
Remove the clip (1) at the side of the right-hand side cushion
Pull out the top edge of the left front panel in the cargo
compartment to access the upper catch for the side cushion.
10 Applies to the S60
Remove the right
-hand side cushion. First press in the catches
(1) at the top edge of the reverse of the side cushion. Pull the
cushion out slightly
Grasp the cushion using both hands. Twist the cushion
clockwise until the catches on the inside release
Remove the side cushion. First pull out the upper edge of the
side cushion. Then pull upwards.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation Fuel driven heater 912
-
D
-
8698855
-
V1.0
Side 7 / 24
M8503367
Applies to all models
11
M8802583
Applies to all models
Applies to cars with mountings for Isofix on the right
side of the rear seat
Remove the screws (1). Slacken off the end mounting (2) for the
seat belt
Remove the nut (3) and the washer (4) from the stud
Remove the mounting (5).
12
M8503338
Applies to the right-hand side
Disconnect the connector (1) and the screw (2) on the right
backrest
Lift up the mounting (3) and pull out the backrest by twisting it
backwards and forwards to remove the pin from the mounting in
the left backrest
Remove the right backrest.
13
Push the insulation panel to one side so that the cover (1) is
accessible
Remove the nuts (2) and the cover
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation Fuel driven heater 912
-
D
-
8698855
-
V1.0
Side 8 / 24
D2302195
Drill out the connection (3) in the fuel tank unit (4). Use a 4 mm
(5/32”)
diameter drill bit.
Note!
Use a compressed air power drill with a greased bit.
14A
R2501320
14B
R2501321
Illustration A displays the front mounting
Illustration B displays the rear mounting
Remove the four screws (1) in the front and rear mountings so
that the fuel tank lowers slightly. This allows the suction pipe for
the
fuel tank to be installed.
15
Insert the pipe (1) (from the kit) into the connection (2). Press the
pipe down until it is in contact with the connection
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation Fuel driven heater 912
-
D
-
8698855
-
V1.0
Side 9 / 24
M2302970
Take the fuel line with the power cable from the kit. Apply tape
on the end on the section of the fuel line which is to be inserted
through the hole in the floor. (The one with a short free cable
end.)
Insert the whole cable assembly (3) between the floor and the
fuel tank out to the right.
16
M2302961
Press the quick-release connector (1) onto the connection until a
click is heard. Check that the quick-release connector is secure
Connect the power cable, routed with the fuel line to the
connector (2) in the connector bridge (3).
17
Position the wiring in the rubber grommet in the cover. Reinstall
the cover. Tighten the cover using the four nuts.
Applies to cars with Isofix mountings
Reinstall the Isofix mounting and seat belt buckle
Tighten the screw. Tighten to 40 Nm (30 lbf.ft.).Tighten the nut.
Tighten to 30 Nm (22 lbf.ft.).
Applies to all models
Reinstall the backrests, side cushions and seat cushions
Open the cover for the radiator expansion tank.
18
Route the fuel hose with the cable harness (1) at the rear edge
of the fuel tank. Route along the right-hand side of the fuel tank
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation Fuel driven heater 912
-
D
-
8698855
-
V1.0
Side 10 / 24
Otros manuales de Accesorios para automóviles de Volvo
Volvo
Volvo On Call Manual de usuario
Volvo
Volvo 31307006 Manual de usuario
Volvo
Volvo 30721673 Manual de usuario
Volvo
Volvo 30795637 Manual de usuario
Volvo
Volvo iP-VOL Manual de usuario
Volvo
Volvo 31316493 Manual de usuario
Volvo
Volvo 30660998 Manual de usuario
Volvo
Volvo 31285564 Manual de usuario
Volvo
Volvo 31346058 Manual de usuario
Volvo
Volvo 240 Manual de usuario
Volvo
Volvo Carplay MMI BOX Manual de usuario
Volvo
Volvo 8613309 Manual de usuario
Volvo
Volvo 1324 Manual de usuario
Volvo
Volvo 31334457 Manual de usuario
Volvo
Volvo Centrax Guía de configuración
Volvo
Volvo 31269625 Manual de usuario
Volvo
Volvo C30 - ANNEXE 798 Manual de usuario
Volvo
Volvo RTI S6 Manual de usuario
Volvo
Volvo 31269496 Manual de usuario
Volvo
Volvo 31330255 Manual de usuario
