Viessmann VITOTROL 100 Guía rápida

Installation and service

instructions

for contractors

VIESMANN

Vitotrol 100

Type UTA

Room thermostat for the Vitotronic 100

For applicability, see the last page

VITOTROL 100

5862 628 GB 10/2012 Please keep safe.

Please follow these safety instructions closely to prevent accidents and mate-

rial losses.

Safety instructions explained

Danger

This symbol warns against the

risk of injury.

!Please note

This symbol warns against the

risk of material losses and envi-

ronmental pollution.

Note

Details identified by the word "Note" con-

tain additional information.

Target group

These instructions are exclusively

designed for qualified personnel.

■ Work on gas equipment must only be

carried out by a qualified gas fitter.

■ Work on electrical equipment must

only be carried out by a qualified elec-

trician.

■ The system must be commissioned by

the system installer or a qualified per-

son authorised by the installer.

Regulations

Observe the following when working on

this system

■ all legal instructions regarding the pre-

vention of accidents,

■ all legal instructions regarding envi-

ronmental protection,

■ the Code of Practice of relevant trade

associations,

■ all current safety regulations as

defined by DIN, EN, DVGW, TRGI,

TRF, VDE and all locally applicable

standards,

■ Gas Safety (Installation & Use) Regu-

lations

– the appropriate Building Regulation

either the Building regulations, the

Building Regulation (Scotland),

Building Regulations (Northern Ire-

land),

– the Water Fittings Regulation or

Water Bylaws in Scotland,

– the current I.E.E. Wiring Regula-

tions.

If you smell gas

Danger

Escaping gas can lead to explo-

sions which may result in serious

injury.

■ Never smoke. Prevent naked

flames and sparks. Never

switch lights or electrical appli-

ances ON or OFF.

■ Close the gas shut-off valve.

■ Open windows and doors.

■ Remove all people from the

danger zone.

■ Notify your gas or electricity

supplier from outside the build-

ing.

■ Shut off the electricity supply to

the building from a safe place

(outside the building).

Safety instructions

5862 628 GB

If you smell flue gas

Danger

Flue gas can lead to life-threat-

ening poisoning.

■ Shut down the heating system.

■ Ventilate the boiler room.

■ Close all doors leading to the

living space.

Working on the system

■ When using gas as fuel, also close the

main gas shut-off valve and safeguard

against unauthorised reopening.

■ Isolate the system from the power sup-

ply and check that it is no longer 'live',

e.g. by removing a separate fuse or by

means of a main isolator.

■ Safeguard the system against unau-

thorised reconnection.

!Please note

Electronic modules can be dam-

aged by electro-static dis-

charges.

Touch earthed objects, such as

heating or water pipes, to dis-

charge static loads.

Repair work

!Please note

Repairing components which ful-

fil a safety function can compro-

mise the safe operation of your

heating system.

Replace faulty components only

with original Viessmann spare

parts.

Ancillary components, spare and

wearing parts

!Please note

Spare and wearing parts which

have not been tested together

with the heating system can com-

promise its function. Installing

non-authorised components and

non-approved modifications/con-

version can compromise safety

and may invalidate our warranty.

For replacements, use only orig-

inal spare parts from Viessmann

or those which are approved by

Viessmann.

Safety instructions

Safety instructions (cont.)

5862 628 GB

Installation instructions

Preparing for installation

Installation site...................................................................................................... 5

Installation sequence

Fitting the room thermostat.................................................................................. 6

Electrical connection............................................................................................ 6

Adjusting the room thermostat............................................................................. 9

Service instructions

Specification....................................................................................................... 12

Certificates

Declaration of conformity...................................................................................... 13

Index

5862 628 GB

■ In the main living room on an internal

wall opposite radiators.

■ Approximately 1.5 m above floor level.

■ Away from windows or doors.

■ Not on shelves or in recesses.

■ Away from heat sources (radiators,

direct sunlight, fireplace, TV set etc.).

Never install further controllers in this

main living room. If the radiators are

equipped with thermostatic valves, these

must always be fully opened.

Preparing for installation

Installation site

5862 628 GB

Installation

10°

30°

90°

Electrical connection

Recommended connecting cable:

■ Without earth conductor: 3 x 1.5 mm²

■ With earth conductor: 4 x 1.5 mm²

Installation sequence

Fitting the room thermostat

5862 628 GB

10°

30°

90°

Information on step 1

Press cables flat into the base.

Wiring subject to the type of

Vitotronic 100, see the following chap-

ter.

Installation sequence

Electrical connection (cont.)

5862 628 GB

Installation

Connection to the Vitotronic 100 with a terminal strip

1 2 3 4 5 6 7 8 9 10 11 12

ATerminal strip inside the

Vitotronic 100, type KC3

DVitotrol 100, type UTA

Remove jumper across terminals 4 and

Connection to the Vitotronic 100 with plug lH

1 L ?N

3 2 6

Installation sequence

Electrical connection (cont.)

5862 628 GB

Connection to the Vitotronic 100 with plug gH

LS LR N

3 6

2 4

Adjusting the room thermostat

Note

Set room thermostat code, if required;

see the installation and service instruc-

tions for the Vitotronic control unit.

10°

30°

10°

30°

AController for electronic feedback

BController for adjusting the temper-

ature

Installation sequence

Electrical connection (cont.)

5862 628 GB

Installation

Electronic feedback (setting the hysteresis)

The switching hysteresis is influenced by

the electronic feedback.

The Vitotrol 100 is set up at the factory

for standard mode. Only change this set-

ting if the control unit must be adapted to

the heating system.

approx. 0.4K

approx. 0.8K

approx. 1.3K

approx. 1.5K

AStandard mode (delivered condi-

tion)

Bring the controller for the electronic

feedback into the required position using

a screwdriver.

Temperature adjustment

To adapt to local conditions, a temperature adjustment may be required, such as

when installing it on a cold concrete wall, for example.

Installation sequence

Adjusting the room thermostat (cont.)

5862 628 GB

Otros manuales para VITOTROL 100

Tabla de contenidos

Otros manuales de Termostato de Viessmann

Viessmann

Viessmann VITOTROL 100 Instrucciones de funcionamiento

Viessmann

Viessmann VITOTROL 100 UTA-RF Manual de usuario

Viessmann

Viessmann VITOTROL 100 Manual de usuario

Viessmann

Viessmann Vitotrol 100 UTDB-RF2 Guía rápida

Viessmann

Viessmann Vitotrol 100 UTA Manual de usuario

Viessmann

Viessmann VITOTROL 100 Manual de usuario

Viessmann

Viessmann VITOTRONIC 200 Guía rápida

Viessmann

Viessmann VITOTROL 100 Manual de usuario

Viessmann

Viessmann VITOTROL 100 Manual de usuario

Viessmann

Viessmann VITOPLANAR Manual de usuario

Viessmann

Viessmann VITOTROL 100 Manual de usuario

Viessmann

Viessmann VITOTROL 100 Manual de usuario

Viessmann

Viessmann Tado Manual del propietario

Manuales populares de Termostato de otras marcas

EWELLY

EWELLY EW-181 Manual de usuario

Prolon

Prolon T1100 Instrucciones de instalación

Computherm

Computherm Q20 Manual de usuario

Heatmiser

Heatmiser neoStat Manual de usuario

Aube Technologies

Aube Technologies TH111GFCI-NP 240 VCA Manual de usuario

Mars

Mars HEAT CONTROLLER IR Wireless Thermostat Manual de usuario

Saswell

Saswell SAS920XWHB-7-S-RF Guía

Aircalo

Aircalo TFP1-ET85P2 Manual de usuario

Honeywell

Honeywell CM721 Manual de usuario

Carrier

Carrier DEBONAIR 33CS Manual de usuario

Lennox

Lennox iHarmony Zone Thermostat Instrucciones de montaje

Gemtech

Gemtech GT7000 Manual de instrucciones

Rollei

Rollei Smartes 45000 Manual de usuario

Sinope

Sinope TH1300RF Manual de usuario

Honeywell

Honeywell RLV4305 Manual de usuario

Honeywell

Honeywell Prestige 2.0 THX9421 Manual de usuario

NuTone

NuTone NTBZ48 Instrucciones de funcionamiento originales

Stelpro

Stelpro MAESTRO ASMT402AD Manual de usuario