Vaisala WAV151 Manual de usuario

USER'S GUIDE

Wind Vane

WAV151

M210294en-A

PUBLISHED BY

Vaisala Oyj Phone (int.):+358 9 8949 1

P.O. Box 26 Fax: +358 9 8949 2227

FIN-00421 Helsinki

Finland

Visit our Internet pages at http://www.vaisala.com/

No part of this manual may be reproduced in any form or by any

means, electronic or mechanical (including photocopying), nor may its

contents be communicated to a third party without prior written

permission of the copyright holder.

The contents are subject to change without prior notice.

Please observe that this manual does not create any legally binding

obligations for Vaisala towards the customer or end user. All legally

binding commitments and agreements are included exclusively in the

applicable supply contract or Conditions of Sale.

___________________________________________________________________

VAISALA___________________________________________________________1

Table of Contents

CHAPTER 1

GENERAL INFORMATION.......................................................3

About This Manual..................................................3

Contents of This Manual.......................................3

Version Information...............................................4

Related Manuals...................................................4

Safety.......................................................................4

General Safety Considerations.............................4

Product Related Safety Precautions.....................5

ESD Protection.....................................................5

Regulatory Compliances........................................6

Warranty..................................................................6

CHAPTER 2

PRODUCT OVERVIEW.............................................................7

Introduction to WAV151 Wind Vane......................7

CHAPTER 3

INSTALLATION ........................................................................9

Selecting Location..................................................9

Installation Procedure..........................................10

Mounting.............................................................10

Alignment............................................................12

Verification..........................................................12

Connector..............................................................12

CHAPTER 4

MAINTENANCE ......................................................................15

Periodic Maintenance...........................................15

Cleaning .............................................................15

Testing Proper Operation ...................................15

Replacing Consumables.....................................16

Parts List for Consumables .................................20

User's Guide ________________________________________________________

2 ______________________________________________________ M210294en-A

CHAPTER 5

TROUBLESHOOTING............................................................21

Common Problems ..............................................21

Getting Help.......................................................... 22

Return Instructions ..............................................23

CHAPTER 6

TECHNICAL DATA.................................................................25

Specifications....................................................... 25

MTBF .....................................................................26

MTTR .....................................................................27

List of Figures

Figure 1 WAV151 Wind Vane.................................................8

Figure 2 Recommended Mast Location in Open Area............9

Figure 3 Recommended Mast Length on the Top of

Building ..................................................................10

Figure 4 Mounting of Wind Sensor.......................................11

Figure 5 WAV151 Connector................................................12

Figure 6 WAV151 Assembly.................................................19

List of Tables

Table 1 Manual Revisions.....................................................4

Table 2 Related Manuals ......................................................4

Table 3 Available Spare Parts.............................................20

Table 4 Some Common Problems and their Remedies......21

Table 5 WAV151 Wind Vane Specifications........................25

Table 6 Output from Connector Pins C to H........................26

Table 7 MTBF Values..........................................................26

Chapter 1 ___________________________________________General Information

VAISALA___________________________________________________________3

CHAPTER 1

GENERAL INFORMATION

About This Manual

This manual provides information for installing, operating,

and maintaining the WAV151 Wind Vane.

Contents of This Manual

This manual consists of the following chapters:

- Chapter 1, General Information, provides important

safety, revision history, and warranty information for the

product.

- Chapter 2, Product Overview, introduces the WAV151

Wind Vane features and advantages.

- Chapter 3, Installation, provides you with information

that is intended to help you install this product.

- Chapter 4, Maintenance, provides information that is

needed in the basic maintenance of the WAV151 Wind

Vane.

- Chapter 5, Troubleshooting, describes common problems,

their probable causes and remedies, and contact

information.

- Chapter 6, Technical Data, provides the technical data of

the WAV151 Wind Vane.

User's Guide ________________________________________________________

4 ______________________________________________________ M210294en-A

Version Information

Table 1 Manual Revisions

Manual Code Description

M210294en-A This manual, the first version of the

WAV151 Wind Vane User's Guide.

Related Manuals

Table 2 Related Manuals

Manual Code Manual Name

M210293en WAA151 Anemometer - User's Guide

Safety

General Safety Considerations

Throughout the manual, important safety considerations are

highlighted as follows:

WARNING Warning alerts you to a serious hazard. If you do not read

and follow instructions very carefully at this point, there is

a risk of injury or even death.

CAUTION Caution warns you of a potential hazard. If you do not read

and follow instructions carefully at this point, the product

could be damaged or important data could be lost.

NOTE Note highlights important information on using the product.

Chapter 1 ___________________________________________General Information

VAISALA___________________________________________________________5

Product Related Safety

Precautions

The WAV151 Wind Vane delivered to you has been tested

for safety and approved as shipped from the factory. Note

the following precautions:

WARNING Ground the product, and verify outdoor installation

grounding periodically to minimize shock hazard.

CAUTION Do not modify the unit. Improper modification can damage

the product or lead to malfunction.

ESD Protection

Electrostatic Discharge (ESD) can cause immediate or latent

damage to electronic circuits. Vaisala products are

adequately protected against ESD for their intended use.

However, it is possible to damage the product by delivering

electrostatic discharges when touching, removing, or

inserting any objects inside the equipment housing.

To make sure you are not delivering high static voltages

yourself:

- Handle ESD sensitive components on a properly

grounded and protected ESD workbench. When this is

not possible, ground yourself to the equipment chassis

before touching the boards. Ground yourself with a wrist

strap and a resistive connection cord. When neither of the

above is possible, touch a conductive part of the

equipment chassis with your other hand before touching

the boards.

User's Guide ________________________________________________________

6 ______________________________________________________ M210294en-A

- Always hold the boards by the edges and avoid touching

the component contacts.

Regulatory Compliances

The WAV151 complies with the following performance and

environmental test standards:

- Wind tunnel tests per ASTM standard method D5366-96

(for starting threshold, damping ratio, overshoot ratio, and

delay distance; refer to technical data)

- Exploratory vibration test per MIL-STD-167-1

- Humidity test per MIL-STD-810E, Method 507.3

- Salt fog test per MIL-STD-810E, Method 509.3

Warranty

For certain products Vaisala normally gives a limited one

year warranty. Please observe that any such warranty may

not be valid in case of damage due to normal wear and tear,

exceptional operating conditions, negligent handling or

installation, or unauthorized modifications. Please see the

applicable supply contract or conditions of sale for details of

the warranty for each product.

Chapter 2 ____________________________________________ Product Overview

VAISALA___________________________________________________________7

CHAPTER 2

PRODUCT OVERVIEW

This chapter introduces the WAV151 Wind Vane features

and advantages.

Introduction to WAV151 Wind Vane

The WAV151 Wind Vane is a counter-balanced, low-

threshold optoelectronic wind vane. Infrared LEDs and

phototransistors are mounted on six orbits on each side of a

6-bit GRAY-coded disc. Rotated by the vane, the disc

creates changes in the code received by the phototransistors.

The code is changed in steps of 5.6°, one bit at a time to

eliminate any ambiguities in the coding.

A heating element in the shaft tunnel keeps the temperature

of the bearings above the freezing level in cold climates.

Nominally, it provides 10 W of heating power. It is

recommended to use a thermostat switch in the sensor cross

arm for switching the heating power on below +4 °C.

User's Guide ________________________________________________________

8 ______________________________________________________ M210294en-A

0204-044

Figure 1 WAV151 Wind Vane

The following numbers refer to Figure 1 above:

1=Vaneassembly

2=Sensorshaft

3 = Lower body

Otros manuales para WAV151

Tabla de contenidos

Otros manuales de Instrumento de medición de Vaisala

Vaisala

Vaisala WAC151 Manual de usuario

Vaisala

Vaisala GMP252 Manual de usuario

Vaisala

Vaisala Veriteq viewLinc 4.3 Manual de usuario

Vaisala

Vaisala GroundCast DRS611 Manual de usuario

Vaisala

Vaisala WAA151 Manual de usuario

Vaisala

Vaisala LT31 Manual de usuario

Vaisala

Vaisala RT20A Manual de usuario

Vaisala

Vaisala Optimus OPT100 Manual de usuario

Vaisala

Vaisala CARBOCAP GM70 Manual de usuario

Vaisala

Vaisala HM41 Manual de usuario

Vaisala

Vaisala DMP5 Manual de usuario

Vaisala

Vaisala Radiosonde RS41-SGM Manual de usuario

Vaisala

Vaisala WAA251 Manual de usuario

Vaisala

Vaisala DMP80 Series Manual de usuario

Vaisala

Vaisala FC-11 Manual de usuario

Vaisala

Vaisala MGP261 Manual de usuario

Vaisala

Vaisala BAROCAP PTB330 Manual de usuario

Vaisala

Vaisala RS41 Manual de usuario

Vaisala

Vaisala Indigo80 Manual de usuario

Vaisala

Vaisala HUMICAP HMI41 Manual de usuario

Vaisala

Vaisala SHM40 Manual de usuario

Vaisala

Vaisala WA252 Manual de usuario

Vaisala

Vaisala K-PATENTS PR-23-SD Generation 1 Instrucciones de uso

Vaisala

Vaisala GMP252 Manual de usuario

Manuales populares de Instrumento de medición de otras marcas

Suaoki

Suaoki D40 Manual de usuario

Elster

Elster BK-G1.6 Manual de usuario

Endress+Hauser

Endress+Hauser Deltabar FMD71 Manual

Duratool

Duratool D03128 Manual de usuario

Vega

Vega VEGAPULS 65 Manual de usuario

Tonghui

Tonghui TH2618B Manual de usuario

Tenmars

Tenmars TM-801 Manual de usuario

MSR

MSR 145 Manual de usuario

TPS

TPS WP-82 Manual de usuario

ELMETRON

ELMETRON CP-511 Manual de usuario

PCB Piezotronics

PCB Piezotronics 003C30 Manual de usuario

Tenma

Tenma 72-10465 Manual de usuario

Endress+Hauser

Endress+Hauser Proline Promag 50 Especificaciones técnicas

Siemens

Siemens SITRANS F Coriolis FCT030 Manual de lista de piezas

KLINGER

KLINGER CMF V Series Manual de usuario

EXFO

EXFO FTB-2 Manual de operación y mantenimiento

Keysight

Keysight M8290A Manual de usuario

ADTEK

ADTEK MW-5 Manual de usuario