Travis Industries 250-05727 Manual de usuario

This kit is for replacement of the incorrect exhaust restrictor that was inadvertently packaged on some of

the 564 25K GSR2 and 564 25K GSR2 CF fireplaces. The included “flat” restrictor will not work correctly

and needs to be replaced with the exhaust restrictor included in this kit.

AFFECTED SKU NUMBERS:

98500277, 98500278

AFFECTED SERIAL NUMBER RANGE:

3409-043397 through 3409-044388

Appliances that are installed straight out the back or with a minimum rise that require the exhaust restrictor

to be removed according to the installation instructions need no action taken. The exhaust restrictor does

not need to be replaced - simply removed - on these types of installations.

All other installations need to have the “incorrect” exhaust restrictor changed out.

INSTRUCTIONS:

1. Remove the old “incorrect” exhaust restrictor by removing the (2) 1/4” hex head screws holding it in place.

2. Install the new “correct” exhaust restrictor in it’s place using the (2) 1/4” hex head screws removed in step

#1.

IMPORTANT - be sure to set the exhaust restrictor in the proper position for your specific vent configuration

(refer to the installation manual for detailed information on configurations).

Thank you for your attention to this issue. We apologize for any inconvenience this may have caused. Please

don’t hesitate to contact us with any question.

564 25K Exhaust Restrictor Kit

250-05727

17602205

Page 1

FOR REAR VENT APPLICATIONS WITH NO VERTICAL RISE ONLY

•When using a rear vent configuration with no vertical rise remove and discard the exhaust restrictor and

install the exhaust deflector (included with the fireplace) as shown below.



Remove and

discard the

exhaust restrictor

(keep the screws).

Install the exhaust

deflector using the

screws removed

earlier. Note how it

angles upwards

and fits into the

exhaust box.

3 feet

915mm

0 feet

0 feet mm

1' (max) 300mm

- Remove the Exhaust Restrictor

and Install Exhaust Deflector

- Intake Restrictor # 1 (stock)

- Diffuser Position # 1 (stock)

• Max. 12" (102mm) Horizontal Section

• No Elbows Allowed

17602205

Page 2

Approved Vent Configurations

Restrictor Position

Intake and exhaust restrictors are built into the appliance to adjust the flow rate of intake air and

exhaust gases. Depending upon the vent configuration, you may be required to adjust the restrictor

positions. The charts for acceptable vent configurations detail the correct vent restrictor positions.

Exhaust Restrictor Adjustment

If the diffuser is required to be in position # 2, you may wish to adjust the diffuser while the exhaust

restrictor is removed.

NOTE: If removing the restrictor, make sure to replace the screws in the firebox ceiling.



Loosen these 2 screws on

the exhaust restrictor.

Slide the restrictor to the correct

position (see illustration above).

The rear screw location indicates

restrictor position.

Back Wall of Firebox

Firebox Roof

WHEN USING POSITION #4 (OR GREATER

BEND THIS FLANGE DOWN FLAT

(closed)# 4

# 3

# 2

(open) # 1

This restrictor is in position # 4.

Tighten the screws to secure the

restrictor.

NOTE: These obround holes allow

for the restrictor to be removed

with the screws still in place.

17602205

Page 3

Tabla de contenidos

Otros manuales de Accesorios para chimeneas de Travis Industries

Travis Industries

Travis Industries 96100110 Manual de usuario

Travis Industries

Travis Industries shield 6015 Manual de usuario

Travis Industries

Travis Industries 96100278 Manual de usuario

Travis Industries

Travis Industries 616 GSR Insert Manual de usuario

Travis Industries

Travis Industries GreenStart Igniter 3 Manual de usuario

Travis Industries

Travis Industries Illuminations 4915 Manual de usuario

Travis Industries

Travis Industries 864 TRV 31K Manual de usuario

Travis Industries

Travis Industries 54PB Manual de usuario

Travis Industries

Travis Industries 95600654 Manual de usuario

Travis Industries

Travis Industries 616 DF Manual de usuario

Travis Industries

Travis Industries shield 6015 Manual de usuario

Travis Industries

Travis Industries 864 ST GS Manual de usuario

Travis Industries

Travis Industries ProBuilder 36 Manual de usuario

Travis Industries

Travis Industries Fireplace Xtrordinair 96300770 Manual de usuario

Travis Industries

Travis Industries GreenSmart DFC Instrucciones de instalación y funcionamiento

Travis Industries

Travis Industries 96100593 Manual de usuario

Travis Industries

Travis Industries 95100055 Manual de usuario

Travis Industries

Travis Industries 99300471 Manual de usuario

Travis Industries

Travis Industries DVL EmberGlo GSR2 Insert Manual de usuario

Travis Industries

Travis Industries 94700882 Manual de usuario

Travis Industries

Travis Industries 33 DVI Manual de usuario

Travis Industries

Travis Industries 250-00128 Manual de usuario

Travis Industries

Travis Industries 250-02736 Manual de usuario

Travis Industries

Travis Industries Fyre 430 Manual de usuario

Manuales populares de Accesorios para chimeneas de otras marcas

Valor

Valor L2 1700K Manual de usuario

Exodraft

Exodraft Xzense Manual de usuario

Whalen

Whalen Ruso MNFP62BF23-6 Manual de usuario

Lopi

Lopi Hearthview 864 Manual de usuario

Woodstock Soapstone

Woodstock Soapstone Fireview 201 Manual de usuario

EdilKamin

EdilKamin SERBATOIO 250 Guía de inicio rápido

Bronpi

Bronpi KIT-1 Manual de usuario

Town & Country Fireplaces

Town & Country Fireplaces 22150051 Manual de usuario

Superior

Superior ASD3628-TI Manual de usuario

pleasant hearth

pleasant hearth OFP28WG Manual de usuario

IHP

IHP Astria Series Manual de usuario

Firegear

Firegear FG-H-2110SS Manual de usuario

Nibe

Nibe Contura C i31 Manual de usuario

kozy heat

kozy heat KZK-052 Manual de usuario

SimpliFire

SimpliFire SF-WM36 Manual de usuario

Bluegrass Living

Bluegrass Living BC18NR Guía de inicio rápido

pleasant hearth

pleasant hearth IRIS SCROLL Manual de usuario

Cooke

Cooke Glass Wind Guard Manual de usuario